Cybertruck Service Manual

    Body Panel (Refinish)

    Refer to the Collision Repair procedure for information on maintaining the finish of the stainless steel body panels on Cybertruck. See Exterior Stainless Steel Panel Refinishing.

    Parent topic: 1010 - Body Panels
    • Cybertruck Service Manual
    • Release Notes
    • GENERAL INFORMATION
      • INTRODUCTION
        • Abbreviations and Symbols
        • Flat Rate Times
        • How To Use This Manual
        • Repairs and Replacements
        • Warranty Service Regions
      • BEST PRACTICES
        • Airbag and Supplementary Restraint System (SRS) Precautions
        • Air Conditioning System Precautions
        • Diagnostic Connector Location
        • Electrical Precautions
        • Environmental Precautions
        • Event Data Recorder Retrieval
        • Flexible Pipes and Hoses
        • General Fitting Instructions
        • General Precautions
        • Locking Devices
        • Oil Seals
        • Personal Protection
        • Pre-Installation Glass Inspection
        • SRS Component Replacement Policy
        • Vehicle Cameras and Autopilot
        • Vehicle Weight Information and Lifting Precautions
      • CHARGING
        • General
        • Precautions
      • FLUIDS AND CAPACITIES
        • Fluid Capacities
        • Fluids
      • IDENTIFICATION NUMBERS
        • Vehicle and Wheel Paint Codes
        • Vehicle Identification Number (VIN)
      • TECHNICAL DATA
        • Brakes
        • Suspension
        • Tire Pressures
        • Wheel Alignment
        • Wheels
    • 00 - INSPECTION AND SERVICE
      • 0001 - Scheduled Service
        • Maintenance Service Intervals
      • 0002 - Firmware Service
        • Software Reinstall - Touchscreen (Restore)
        • Software Update (Over The Air)
      • 0005 - Service Modes
        • Gateway (Unlock)
        • Service Mode
        • Toolbox 3 (Connect and Disconnect)
    • 10 - BODY
      • 1000 - Vehicle Lifting
        • Raise Vehicle - 2 Post Lift
        • Raise Vehicle - Jack
      • 1001 - Bumper/Fascia
        • Body Side Bracket - LH - Rear Fascia (Remove and Install)
        • Foam Seal - Side - Front Grille (Remove and Install)
        • Front Center Applique Assembly (Remove and Install)
        • Front End Carrier Plastic Assembly (Remove and Install)
        • Front End Carrier Plastic Assembly (Remove and Replace)
        • Front Energy Absorber - Front Bumper Beam Assembly (Remove and Install)
        • Front Fascia Fairing Assembly - LH (Remove and Install)
        • Front Fascia Lower Camera Cover (Remove and Install)
        • Front Fascia (Remove and Install)
        • Front Fascia (Remove and Replace)
        • Foam Seal - Upper/Lower - Front Grille (Remove and Install)
        • Front Lower Grille (Remove and Install)
        • Frunk Switch (Remove and Install)
        • Lower Tow Eye Cap - LH - Front Grille (Remove and Replace)
        • Rear Fascia (Remove and Install)
        • Rear Fascia (Remove and Replace)
        • Step Bracket Center - LH - Rear Fascia (Remove and Install)
        • Support Bracket - Center - Front Energy Absorber (Remove and Install)
        • Support Bracket - LH - Front Energy Absorber (Remove and Install)
        • Trailer Hitch Cover (Remove and Install)
        • Rear Energry Absorber - Cast Bumper Assembly - LH (Remove and Install)
        • Rear Energry Absorber - Center Bracket (Remove and Install)
        • Rear Energry Absorber - Fascia Step Bracket - Center (Remove and Install)
      • 1010 - Body Panels
        • Bed Side Applique Corner Bracket - RH (Remove and Install)
        • Bed Side Outer Assembly - LH (Long Range) (Remove and Install)
        • Bed Side Outer Assembly - LH (Remove and Install)
        • Body Panels - Rear Under Body - Rear Fascia Bracket - LH (Remove and Install)
        • Body Panel (Refinish)
        • Dash Absorber - LH (Remove and Install)
        • Dash Absorber - RH (Remove and Install)
        • Door - Front - LH (Remove and Install)
        • Door - Front - LH (Remove and Replace)
        • Door - Rear - LH (Remove and Install)
        • Door - Rear - LH (Remove and Replace)
        • Fender Assembly - Front - LH (Remove and Install)
        • Fender Assembly - Front - LH (Remove and Replace)
        • Front Fascia Lower Dummy LP Cover (Remove and Install)
        • Lamp Step Bracket - LH (Remove and Replace)
        • Lamp Step Bracket - RH (Remove and Replace)
        • Powergate Fascia (Remove and Install)
        • Powergate Hood (Remove and Install)
        • Powergate Hood (Remove and Replace)
        • Powergate (Manual Release)
        • Tailgate Assembly (Remove and Install)
        • Tailgate Assembly (Remove and Replace)
        • Trim - Cantrail - Roof Rail - LH (Remove and Install)
        • Trim - Cantrail - Roof Rail - LH (Remove and Replace)
      • 1020 - Windshield and Body Glass
        • Clean Forward Camera View (Precision Cleaning of Inboard Glass) (Restore)
        • Edge Seal - Windshield - Front (Remove and Replace)
        • Edge Seal - Windshield - LH (Remove and Replace)
        • Fixed Glass Roof Assembly (Remove and Replace)
        • Fixed Backlite Glass (Remove and Install)
        • Moving Glass - Door - Front - LH (Remove and Install)
        • Moving Glass - Door - Rear - LH (Remove and Install)
        • Primary Seal - Door - Front - LH (Remove and Install)
        • Primary Seal - Door - Rear - LH (Remove and Install)
        • Quarter Glass - Front - LH (Remove and Install)
        • Seal - Header - LH (Remove and Install)
        • Seal - Quarter Glass - Front - LH (Remove and Install)
        • Windshield and Roof Glass Repair and Replacement Guidelines
        • Windshield Assembly (Remove and Replace)
        • Windshield Chip Repair
      • 1030 - Paint
    • 11 - CLOSURE COMPONENTS
      • 1120 - Tonneau
        • Applique - Lower - Fabric Tonneau (Long Range) (Remove and Install)
        • Applique - Upper - Fabric Tonneau (Long Range) (Remove and Install)
        • Bushing Slat and Seal (Remove and Install)
        • Cam Block - LH - Fabric Tonneau (Long Range) (Remove and Install)
        • Chain Link - Tonneau (Remove and Install)
        • Corner Bracket - LH - Fabric Tonneau (Long Range) (Remove and Install)
        • Flat Cassette Assembly - LH (Remove and Replace)
        • Foam Datum Pad - Fabric Tonneau (Long Range) (Remove and Install)
        • Hinge Pivot - LH - Applique - Fabric Tonneau (Long Range) (Remove and Install)
        • Horizon Rail Assembly - LH - Fabric Tonneau (Long Range) (Remove and Install)
        • Manual Release - Tailgate (Remove and Install)
        • Mid Slat - Tonneau (Remove and Install)
        • Seal - Closeout - Fabric Tonneau (Long Range) (Remove and Install)
        • Sealing Slat - Tonneau (Remove and Install)
        • Slat System - Tonneau (Remove and Install)
        • Slat System - Tonneau (Rework) (Modify)
        • Strut - Bed Cargo Tub (Remove and Install)
        • Tonneau Applique (Remove and Install)
        • Tonneau Horizontal Rail - LH (Remove and Install)
        • Tonneau Lower Assembly (Remove and Install)
        • Tonneau Motor Assembly - LH (Remove and Install)
        • Tonneau NVH Barrier Assembly (Remove and Install)
        • Tonneau Rail - LH (Remove and Install) (Post 11/4/2024)
        • Tonneau Rail - RH (Remove and Install) (Post 11/4/2024)
        • Tonneau Slats (Manual Release) (Removal)
      • 1133 - Closure Assist Mechanisms and Hinges
        • Bumpstop - Tailgate (Remove and Install)
        • Cable Strap - Tailgate (Remove and Install)
        • Check Strap - Front Door - LH (Remove and Replace)
        • Check Strap, Rear (Remove and Replace)
        • Cinching Latch - Tailgate - LH (Remove and Install)
        • Door Latch - Front - LH (Remove and Install)
        • Door Latch - Rear - LH (Remove and Install)
        • Door Presenter - Front Door - LH (Remove and Replace)
        • Door Presenter - Rear Door - LH (Remove and Replace)
        • Door Striker - Rear - LH (Remove and Install)
        • Hinge - Body Side - Tailgate - RH (Remove and Install)
        • Hinge - Upper - Front Door - LH (Remove and Install)
        • Hinge - Upper - Rear Door - LH (Remove and Install)
        • Hood Strut (Remove and Install)
        • Latch - Powergate (Remove and Install)
        • Latch - Powergate (Remove and Replace)
        • Powergate Hinge - LH (Remove and Install)
        • Striker - Powergate (Remove and Install)
        • Striker - Tailgate (Remove and Install)
        • Strut Damper - Tailgate (Remove and Install)
        • Tailgate Latch and Striker - LH Body - Side Hinge, Tailgate (Remove and Install)
        • Tailgate Torsion Rod (Remove and Install)
        • Closure Assist Mechanisms and Hinges - Hinges - Front Door Hinge - Lower - LH (Remove and Install)
        • Closure Assist Mechanisms and Hinges - Hinges - Rear Door - Lower Hinge - LH (Remove and Install)
      • 1140 - Interior Door Handles
      • 1145 - Exterior Door Handles
      • 1150 - Door Glass and Regulators
        • Closeout Panel - Front Door - LH (Remove and Install)
        • Closeout Panel - Rear Door - LH (Remove and Replace)
        • Moving Glass - Front Door - LH (Adjust)
        • Moving Glass - Rear Door - LH (Adjust)
        • Window Regulator, 48V Q-Motor (Remove and Install)
        • Window Regulator - Front Door - LH (Remove and Install)
        • Window Regulator - Rear Door - LH (Remove and Install)
      • 1170 - Seals Body Enclosures
        • Aero Seal - LH - Powergate (Remove and Install)
        • Edge Seal - Rear - Roof Glass (Remove and Replace)
        • Glass Run Seal - Front Door - A-Pillar - LH (Remove and Install)
        • Seal - LH - Tailgate (Remove and Install)
        • Secondary Seal - Front Door - LH (Remove and Install)
        • Secondary Seal - Rear Door - LH (Remove and Install)
        • Waist Belt Seal - Inner - Front Door - LH (Remove and Install)
        • Waist Belt Seal - Inner - Rear Door - LH (Remove and Install)
        • Waist Belt Seal - Outer - Front Door - LH (Remove and Install)
        • Waist Belt Seal - Outer - Rear Door - LH (Remove and Install)
        • Water Management Seal - LH - Center - Tonneau (Remove and Install)
    • 12 - EXTERIOR FITTINGS
      • 1201 - Wheel Arch Liners
        • Wheel Liner - Front - LH (Remove and Replace)
        • Wheel Liner - Rear - LH (Remove and Install)
      • 1203 - Undertray and Diffuser
        • Aeroshield - Front (Remove and Install)
        • Skid Plate - Rear (Remove and Install)
        • Aeroshield - Rear (Remove and Install)
        • Diffuser - Rear (Remove and Install)
        • Lower Tub Crossmember (Remove and Install)
        • Skid Plate (Remove and Install)
      • 1205 - Badges and Films
      • 1207 - License Plate Mountings
        • Bracket - License Plate - Front (Retrofit)
        • License Plate Assembly - Front (Remove and Install)
      • 1209 - Exterior Mirrors
        • Exterior Mirror Assembly - Electromechanical - LH (Remove and Install)
        • Exterior Mirror Glass - Flat - Electrochromic Dimming - LH (Remove and Install)
        • Skull Cap - Exterior Mirror - LH (Remove and Install)
      • 1215 - Truck Bed
        • Bed Closeout - Rear - LH (Remove and Install)
        • Bed Floor Assembly (Long Range) (Remove and Install)
        • Bed Floor Assembly (Remove and Install)
        • Bed Side Wall - LH (Remove and Install)
        • Bed Side Wall - Lower - LH (Long Range) (Remove and Install)
        • Bed Side Wall - Upper - LH (Long Range) (Remove and Install)
        • Bed Tiedown Assembly - Fore - LH (Remove and Install)
        • Bumpstops - Bed Cargo Tub (Remove and Install)
        • Cover - Inner - Tailgate (Remove and Install)
        • Forged Bed Tiedown Assembly (Remove and Install)
        • Front Wall Assembly - Truck Bed (Remove and Install)
        • Lid - Bed Cargo Tub (Remove and Replace)
        • Manual Release Cap - Tailgate Cover (Remove and Install)
        • Seal - Bed Cargo Tub (Remove and Install)
        • Under Bed Storage Assembly (Remove and Install)
      • 1220 - Exterior Trim
        • Applique - Backlite - LH (Remove and Install)
        • Applique - B-Pillar - LH (Remove and Install)
        • Applique - Closeout - Lamp - Rear - LH (Remove and Install)
        • Applique - C-Pillar - LH (Remove and Install)
        • Applique - Roof - LH (Remove and Install)
        • Applique - Roof - LH (Standalone) (Rework)
        • Applique - Sail Baffle - LH (Remove and Install)
        • Applique - Upper - Fascia (Remove and Install)
        • Applique - Wiper (Remove and Install)
        • Baffle - Fender - Front - LH (Remove and Install)
        • Beauty Cover - Lightbar - LH (Remove and Install)
        • Bed Side Wall Assembly - Upper - LH (Remove and Install)
        • Bracket - Applique - Roof (Remove and Install)
        • Bracket - Beauty Cover - Lightbar - LH (Remove and Install)
        • Carrier - Fender Flare - Aft - Front - LH (Remove and Install)
        • Carrier - Fender Flare - Aft - Rear - LH (Remove and Install)
        • Carrier - Fender Flare - Aft - Rear - RH (Remove and Install)
        • Carrier - Fender Flare - Fore - Front - LH (Remove and Install)
        • Carrier - Fender Flare - Fore - Rear - LH (Remove and Install)
        • Closeout - Applique - B-Pillar - LH (Remove and Install)
        • Closeout - Applique - C-Pillar - LH (Remove and Install)
        • Closeout - Sail Baffle - LH (Remove and Install)
        • Fairing - Rocker Panel - Rear - LH (Remove and Replace)
        • Fender Flare - Aft - Rear - LH (Remove and Install)
        • Fender Flare - Fore - Rear - LH (Remove and Install)
        • Fender Flare - Rear - RH (Remove and Install)
        • Mud Flap - Front - LH (Remove and Install)
        • Mud Flap - Rear - LH (Remove and Install)
        • Mud Flaps (Retrofit)
        • Rocker - Structural - Off Road - LH (Remove and Install)
        • Rocker Panel Assembly - LH (Remove and Install)
        • Rocker Step Reinforcement - Front - LH (Remove and Install)
        • Rocker Step Reinforcement - Rear - LH (Remove and Install)
        • Truck Bed Exterior Trim - Sail Applique Set (Retrofit)
        • Sail Applique - LH (Long Range) (Remove and Install)
        • Sail Applique - LH (Remove and Install) (Post 11/4/2024)
        • Sail Applique - LH (Remove and Replace)
        • Sail Applique - RH (Remove and Install) (Post 11/4/2024)
        • Sail Applique - RH (Remove and Replace)
        • Top Applique - Tailgate (Remove and Replace)
      • 1224 - Luggage Compartment Trim
        • Access Panel - Frunk (Remove and Install)
        • Frunk Assembly (Remove and Install)
        • Lamp - Frunk (Remove and Install)
        • Safety Lock Switch (Remove and Install)
        • Seal - Frunk (Remove and Install)
      • 1225 - Underhood Trim
        • Underhood Apron - LH (Remove and Install)
        • Underhood Apron - Rear (Remove and Install)
      • 1230 - Trailer Hitch
        • Tow Hitch (Remove and Install)
      • 1245 - Door Triggers
        • Door Trigger - Front Door - LH (Remove and Install)
        • Door Trigger - Rear Door - LH (Remove and Install)
    • 13 - SEATS
      • 1301 - Front Seat Tracks
        • Button - 8WY/Lumbar - 1st Row Seat - LH (Remove and Install)
        • Button - Cushion Adjust - 1st Row Seat - LH (Remove and Install)
        • Button - Cushion Adjust - 1st Row Seat - RH (Remove and Install)
        • Button - Recline - 1st Row Seat - LH (Remove and Install)
        • Button - Recline - 1st Row Seat - RH (Remove and Install)
        • Cover - Crossmember Riser - 1st Row Seat - LH (Remove and Install)
        • Frame - Seat Cushion - 1st Row Seat - LH (Remove and Install)
        • Motor - Recline - 1st Row Seat - LH (Remove and Install)
        • Motor - Seat Height - 1st Row Seat - LH (Remove and Install)
        • Motor - Seat Tilt - 1st Row Seat - LH (Remove and Install)
        • Riser - Inboard 1st Row Seat - LH (Remove and Replace)
        • Riser - Outboard - 1st Row Seat - LH (Remove and Install)
        • Riser - Outboard - 1st Row Seat - RH (Remove and Install)
        • Seatback Assembly - 1st Row Seat - LH (Remove and Install)
        • Track Cover - 1st Row Seat (Remove and Install)
      • 1302 - 2nd Row Seat Tracks and Motors
      • 1304 - Front Seat Assemblies and Hardware
        • Seat Assembly - 1st Row - LH (Remove and Install)
        • Seat Assembly - 1st Row - RH (Remove and Install)
      • 1305 - 2nd Row Seat Assemblies and Hardware
        • Armrest - 2nd Row Seat (Remove and Install)
        • Back Lumbar - 2nd Row Seat (Remove and Install)
        • Bezel - Cupholder - Armrest - 2nd Row Seat (Remove and Install)
        • Bolster - Inboard - LH - 2nd Row Seat Back (Remove and Install)
        • Bolster - Outboard - LH - 2nd Row Seat Back (Remove and Install)
        • Cap - Top Tether - Center - 2nd Row Seat (Remove and Install)
        • Cap - Shoulder Cover - 2nd Row Seat (Remove and Install)
        • Closeout - Armrest - 2nd Row Seat (Remove and Install)
        • Cushion Assembly - 2nd Row Seat - RH (Remove and Replace)
        • Cushion Assembly - 2nd Row Seat - LH (Remove and Install)
        • Headrest - Center - 2nd Row Seat (Remove and Install)
        • Mounting Bracket - Armrest - 2nd Row Seat (Remove and Install)
        • Seat Back Assembly - 2nd Row Seat - LH (Remove and Install)
        • Seat Back Assembly - 2nd Row Seat - RH (Remove and Install)
        • Shoulder Cover - LH - 2nd Row Seat (Remove and Install)
        • Strap - Release Buckle - Seat Cushion - 2nd Row Seat (Remove and Install)
        • Underbelly - 2nd Row Seat - LH (Remove and Install)
        • Underbelly - 2nd Row Seat - RH (Remove and Install)
      • 1307 - Front Seat Covers, Pads, and Trims
        • Foam - Seat Cushion - 1st Row Seat - LH (with Ventilation) (Remove and Install)
        • Foam - Seat Back - 1st Row Seat - LH (with Ventilation) (Remove and Install)
        • Screw Cover - 1st Row Seat - LH (Remove and Install)
        • Side Shield - Inboard - 1st Row Seat - LH (Remove and Install)
        • Side Shield - Outboard - 1st Row Seat - LH (Remove and Install)
        • Trim - Seat Back - 1st Row - LH (Remove and Install)
        • Trim - Seat Cushion - 1st Row Seat - RH (Remove and Install)
      • 1308 - 2nd Row Seat Covers Pads and Trims
        • A-Cover - Front - Outboard - 2nd Row - LH (Remove and Replace)
        • A-Cover - Front - Outboard - 2nd Row - RH (Remove and Replace)
        • B-Cover - Outboard - 2nd Row - LH (Remove and Replace)
        • B-Cover - Outboard - 2nd Row - RH (Remove and Replace)
        • Buckle Closeout - 2nd Row - LH (Remove and Replace)
        • Closeout Split - Buckle - 2nd Row Seat - LH (Remove and Replace)
        • Closeout Split - Buckle - 2nd Row Seat - RH (Remove and Replace)
        • Foam - Back Rest Insert - 2nd Row Seat (Remove and Install)
        • Substrate - Back Rest - 2nd Row Seat - LH (Remove and Install)
        • Substrate - Back Rest - 2nd Row Seat - RH (Remove and Install)
        • Trim - Back Rest Insert - 2nd Row Seat (Remove and Install)
        • 2nd Row Seat Covers, Pads and Trims - 2nd Row Seat Covers and Pads - 2nd Row Seatback Bolster Foam - Inboard - LH (Remove and Install)
        • 2nd Row Seat Covers, Pads and Trims - 2nd Row Seat Covers and Pads - 2nd Row Seatback Inboard Bolster Trim - LH (Remove and Install)
    • 14 - INSTRUMENT PANELS AND PEDALS
      • 1405 - Instrument Panel
        • Aerobracket Assembly - Instrument Panel (Remove and Install)
        • Aerobracket Assembly - Instrument Panel (Remove and Replace)
        • Airwave Module - Instrument Panel (Remove and Install)
        • Airwave Panel Duct - LH (Remove and Install)
        • Bracket - Steering Column - Instrument Panel (Remove and Install)
        • Cover - Footwell (Remove and Install)
        • Defrost Panel (Remove and Install)
        • Demist Duct - Driver (Remove and Install)
        • Demist Duct - Front Passenger (Remove and Install)
        • Demist Duct - Side Window - LH (Remove and Install)
        • Display Bracket - LH - Instrument Panel (Remove and Install)
        • Display Shroud - Instrument Panel (Remove and Install)
        • Downleg Bracket - LH - Instrument Panel (Remove and Install)
        • Floor Duct - Outboard - LH - Instrument Panel (Remove and Install)
        • Glovebox Assembly (Remove and Install)
        • Lower Assembly - Instrument Panel (Remove and Install)
        • Mid Panel Assembly - Instrument Panel (Remove and Install)
        • Module (RJ45) - Ethernet Diagnostic (Remove and Install)
        • Puddle Lamp - Glovebox (Remove and Install)
        • Puddle Lamp - Footwell - Instrument Panel (Remove and Install)
        • Quarter Panel Assembly - LH - Instrument Panel (Remove and Replace)
        • Service Panel - Center Shroud - Instrument Panel (Remove and Install)
        • Supercarrier Assembly (Remove and Install)
        • Super Cowl Assembly (Remove and Replace)
        • Top Pad Assembly - Instrument Panel (Remove and Install)
    • 15 - INTERIOR TRIM
      • 1505 - Interior Mirror and Sun Visors
        • Beauty Cover - Rearview Mirror (Remove and Install)
        • Glare Shield - Rearview Mirror (Remove and Install)
        • Overhead Console Assembly - Front (Remove and Install)
        • Overhead Console Assembly - Front (Remove and Replace)
        • Rearview Mirror (Remove and Install)
        • Sun Visor - LH (Remove and Install)
        • Interior Mirror and Sun Visors - Sun Visors - Sunvisor and Curtain Assembly - LH (Remove and Install)
      • 1511 - Liftgate Trim
      • 1513 - Door Trim
        • Ambient Light - Map Pocket - Door Panel - Front - LH (Remove and Install)
        • Ambient Light - Map Pocket - Door Panel - Rear - LH (Remove and Install)
        • Beltline Assembly - Door Panel - Front - LH (Remove and Install)
        • Beltline Assembly - Door Panel - Front - LH (Remove and Replace)
        • Beltline Assembly - Door Panel - Rear - LH (Remove and Install)
        • Beltline Assembly - Door Panel - Rear - LH (Remove and Replace)
        • NVH Foam - Door - Front - LH (Remove and Install)
        • NVH Foam - Door - Rear - LH (Remove and Install)
        • Panel - Door Trim - Front - LH (Remove and Install)
        • Panel - Door Trim - Rear - LH (Remove and Install)
        • Puddle Lamp - Door Panel - Front - LH (Remove and Install)
        • Puddle Lamp - Door Panel - Rear - LH (Remove and Install)
        • Reflector - Door - Front - LH (Remove and Install)
        • Switch - Door Release - Front - LH (Remove and Install)
        • Switch - Door Release - Rear - LH (Remove and Install)
        • Switch - Window - Front - LH (Remove and Install)
        • Switch - Window - Front - RH (Remove and Install)
        • Switch - Window - Rear - LH (Remove and Install)
      • 1518 - Pillar and Sill Trim
        • Bezel - Trim - B-Pillar - Upper - LH (Remove and Install)
        • Ramp Bracket - C-Pillar - LH (Remove and Install)
        • Trim - A-Pillar - Forward - LH (Remove and Install)
        • Trim - A-Pillar - Lower - LH (Remove and Install)
        • Trim - A-Pillar - Mid - LH (Remove and Install)
        • Trim - A-Pillar - Upper - LH (Remove and Install)
        • Trim - B-Pillar - Lower - LH (Remove and Install)
        • Trim - B-Pillar - Upper - LH (Remove and Install)
        • Trim - C-Pillar - Lower - LH (Remove and Install)
        • Trim - C-Pillar - Upper - LH (Remove and Install)
      • 1519 - Center Console
        • Airwave Assembly - Center Console (Remove and Install)
        • Armrest Assembly - Center Console (Remove and Install)
        • Cap - Airwave - Center Console (Remove and Install)
        • Cap - Armrest - Center Console (Remove and Install)
        • Center Console Assembly (Long Range) (Remove and Install)
        • Center Console Assembly (Remove and Install)
        • Controller - USB - Center Console (Remove and Install)
        • Controller - USB - Center Console (Remove and Replace)
        • Cupholder - Center Console (Remove and Install)
        • Decor - Top - Center Console (Remove and Install)
        • External Panel - LH - Center Console (Remove and Install)
        • Hub - USB - Panel - Rear - Center Console (Remove and Install)
        • Panel - Front - Center Console (Remove and Install)
        • Panel - Rear - Center Console (Long Range) (Remove and Install)
        • Panel - Rear - Center Console (Remove and Install)
        • Puddle Lamp - Center Console (Remove and Install)
        • Wireless Charger - Center Console (Remove and Install)
        • Wireless Charger - Center Console (Remove and Replace)
      • 1520 - Headliner
        • Bracket - TCU (Remove and Install)
        • Coathook and Maplight - LH (Remove and Install)
        • Maplight - Front (Remove and Install)
        • Spot Lamp - LH - Headliner (Long Range) (Remove and Install)
        • Trim - Cantrail - LH (Remove and Install)
        • Trim - Header - Front (Remove and Install)
        • Trim - Header - Rear (Remove and Install)
      • 1524 - Luggage Compartment Trim
      • 1530 - Carpeting and Mats
        • Bezel - Duct - Carpet - Rear (Remove and Install)
        • Bracket - Upper - Center Floor (Remove and Install)
        • Carpet Assembly - Driver (Remove and Install)
        • Carpet Assembly - Front Passenger (Remove and Install)
        • Carpet Assembly - Rear (Remove and Install)
        • Floor Mat Kit (Remove and Install)
        • NVH Pad - Cowl (Remove and Install)
        • NVH Pad - Dash (Remove and Install)
        • NVH Pad - Rear Wall (Remove and Install)
        • Rail - Center Floor - LH (Remove and Install)
        • Side Trim - Pedal (Remove and Install)
        • Trim - Center Floor - Lower (Remove and Install)
        • Trim - Lower - Rear Wall (Remove and Install)
    • 16 - BATTERY SYSTEM
      • 1601 - HV Battery Assembly
        • Chinstrap - Front - HV Battery (Remove and Install)
        • Cover - Pyro Access - HV Battery (Remove and Install)
        • Doubler - HV Connector Header - DC, FC (Remove and Install)
        • Flood Port (Remove and Install)
        • HV Battery (AWD) (Remove and Install)
        • HV Battery (AWD) (Remove and Replace)
        • HV Connector Header - 2-Pole/600V (Remove and Install)
        • HV Connector Header - DC, FC (Remove and Replace)
        • Littelfuse 828 - 30 (Remove and Install)
        • Skid Plate - Rear (Remove and Install)
        • Thermal Vent - HV Battery (Remove and Replace)
        • Venting Bracket - Rear - HV Battery (Remove and Install)
      • 1610 - HV Battery Enclosure
      • 1620 - HV Battery Cooling System
      • 1630 - HV Battery Electrical Components
        • AC Junction Box (Long Range) (Remove and Replace)
        • AC Junction Box (Remove and Install)
        • Ancillary Cover (Remove and Install)
        • Cover - Ancillary (Long Range) (Remove and Install)
        • Device Cluster - Ancillary Bay (Long Range) (Remove and Replace)
        • Device Cluster Assembly (Backup and Restore)
        • Device Cluster Assembly (Remove and Install)
        • Device Cluster Assembly (Remove and Replace)
        • Device Cluster (Long Range) (Remove and Install)
        • Flood Port (Remove and Install)
        • Fuse, 60A, 1000VDC, Eaton EVK22-60-T - Ancillary (Remove and Replace)
        • Fuse - Power Conversion System (Long Range) (Remove and Replace)
        • Harness - Ancillary (Long Range) (Remove and Replace)
        • Harness - Shunt Jumper (Remove and Install)
        • Harness - LV - Device Cluster (Remove and Replace)
        • Header - HV Connector - Front Drive Unit (Remove and Install)
        • Header - DC Input - Busbar (Long Range) (Remove and Replace)
        • HV Battery Contactor Seize Check (Test/Adjust)
        • HV Harness - AC Junction Box To FC (Remove and Install)
        • HV Harness - AC Junction Box To PCS (Remove and Replace)
        • HV Harness - Device Cluster (Remove and Install)
        • Jumper - ACJB to PCS (Long Range) (Remove and Replace)
        • Last Mile Busbar Assembly (Remove and Install)
        • PCB, AC Junction Box, B2 (Remove and Install)
        • Power Conversion System (Remove and Replace)
        • Pyro Disconnect (Remove and Install)
        • 30A Sand Fuse - Ancillary Bay (Remove and Install)
        • DC Inlet - Negative - Ancillary Bay (Remove and Install)
        • HV Battery Electrical Components - Ancillary Components - DC Inlet - Positive (Remove and Install)
        • HV Battery Electrical Components - Ancillary Components - Positive DC Busbar Link (Remove and Install)
    • 17 - ELECTRICAL
      • 1702 - MV Battery
        • Disconnect MV Power (Modify)
        • MV Battery - Li-ion 48V (Remove and Install)
        • MV Battery - Li-ion 48V (Remove and Replace)
        • MV Battery - Recover (Restore)
        • Vehicle HV Disablement Procedure (Test/Adjust)
      • 1710 - Harnesses
        • Center Display Cable Overlay (Repair)
        • Harness - Ancillary Bay (Remove and Replace)
        • Harness - Bed - LH (Remove and Install)
        • Harness - Bed - RH (Remove and Install)
        • Harness - Cabin Floor (Long Range) (Remove and Install)
        • Harness - Cabin Floor (Remove and Install)
        • Harness - Console (Remove and Install)
        • Harness - Cowl (Remove and Install)
        • Harness - Door - Front - LH (Remove and Install)
        • Harness - Door - Rear - LH (Remove and Install)
        • Harness - Door, Closures Devices (Remove and Install)
        • Harness - Fascia - Front (Remove and Install)
        • Harness - Fascia - Rear (Remove and Replace)
        • Harness - FEM (Remove and Install)
        • Harness - Front Drive Unit (Remove and Install)
        • Harness - Gate - Front (Remove and Install)
        • Harness - HVAC Dry Side (Remove and Install)
        • Harness - Instrument Panel (Remove and Install)
        • Harness - Jumper - Steer - Rear (Long Range) (Remove and Install)
        • Harness - LH - Bed (Long Range) (Remove and Install)
        • Harness - LH - Frunk (Remove and Install)
        • Harness - LH - Truck Bed (Long Range) (Remove and Install)
        • Harness - Megavac - Center (Remove and Install)
        • Harness - MV Backbone (Remove and Install)
        • Harness - RH - Frunk (Long Range) (Remove and Install)
        • Harness - RH - Frunk (Remove and Install)
        • Harness - Roof Accessory Jumper (Remove and Install)
        • Harness - Seat - 1st Row - LH (Remove and Replace)
        • Harness - Seat - 1st Row - RH (Remove and Replace)
        • Harness - Seat - 2nd Row (Remove and Replace)
        • Harness - Side Assembly - LH (Remove and Install)
        • Harness - Side Assembly - RH (Remove and Install)
        • Harness - Speaker - Cowl (Remove and Install)
        • Harness - Steer Jumper - Rear (Remove and Install)
        • Harness - Steering Jumper (Remove and Install)
        • Harness - Subframe - Rear (Dual Motor) (Remove and Install)
        • Harness - Subframe - Rear (Tri-Motor) (Remove and Replace)
        • Harness - Tailgate (Remove and Install)
        • Harness - Trim - A -Pillar - LH (Remove and Install)
        • Harness - Trim - Door - Front - LH (Remove and Install)
        • Harness - Trim - Door - Rear - LH (Remove and Install)
        • Harness - Windshield (Remove and Install)
      • 1715 - Electronic Control Modules
        • Body Controller - LH (Remove and Install)
        • Body Controller - LH (Remove and Replace)
        • Body Controller - Rear (Remove and Install)
        • Body Controller - Rear (Remove and Replace)
        • Body Controller - RH (Remove and Install)
        • Body Controller - RH (Remove and Replace)
        • Door Controller - Front - LH (Remove and Replace)
        • Door Controller - Rear - LH (Remove and Replace)
        • ECU - Trailer (Remove and Install)
        • ECU - Trailer (Remove and Replace)
        • MV Controller - Rear (Long Range) (Remove and Replace)
        • MV Locking Cover Circlip (Remove and Replace)
      • 1720 - Radar Sensor
        • Radar - Cabin (Remove and Install)
        • Radar - Cabin (Remove and Replace)
      • 1722 - Cameras
        • Bi-Cam - Forward Facing (Remove and Install)
        • Bi-Cam - Forward Facing (Remove and Replace)
        • Camera - B-Pillar - LH (Remove and Install)
        • Camera - B-Pillar - LH (Remove and Replace)
        • Camera - Fender Flare - LH (Remove and Install)
        • Camera - Fender Flare - LH (Remove and Replace)
        • Camera - Forward Facing - Front Fascia (Remove and Install)
        • Camera - Forward Facing - Front Fascia (Remove and Replace)
        • Camera - Forward Facing (Pitch Verification) (Test/Adjust)
        • Camera - Rear (Remove and Install)
        • Fan - Camera - Windshield (Remove and Replace)
      • 1724 - Interior Camera
        • Interior Camera (Remove and Install)
        • Interior Camera (Remove and Replace)
      • 1735 - Interior Lighting
      • 1740 - Exterior Lights
        • Bed Light - LH (Long Range) (Remove and Install)
        • Bed Light - LH (Remove and Install)
        • Headlamp Assembly - LH (Remove and Install)
        • Headlight - Adjust (Wall Method)
        • Lamp - License Plate (Remove and Install)
        • Lamp - Rear Marker - LH (Remove and Install)
        • Lamp - Reverse - LH (Remove and Install)
        • Lamp - Tailgate (Remove and Install)
        • Lightbar - Front (Remove and Install)
        • Tail Lamp - Body Side - LH (Remove and Install)
      • 1745 - Keyless Entry and Security
        • BLE End Point - Front Rear (Remove and Install)
        • BLE End Point - Interior (Remove and Install)
        • BLE End Point - Rear (Remove and Install)
        • BLE End Point - Rear (Remove and Replace)
        • BLE End Point - Wheel Well - Front - LH (Remove and Install)
        • BLE End Point - Wheel Well - Front - LH (Remove and Replace)
        • BLE End Point - Wheel Well - Front - RH (Remove and Install)
        • BLE End Point - Wheel Well - Rear - RH (Remove and Install)
        • BLE End Point - Wheel Well - Rear - RH (Remove and Replace)
        • Key Card - Program (Existing Key Present) (Program)
        • Key Card - Program (No Keys Present) (Program)
      • 1750 - Wipers and Washers
        • Cap - Tank - Washer - Windshield (Remove and Install)
        • Hose - Washer - Mega Beam (Remove and Install)
        • Hose - Washer - Wiper - Windshield (Remove and Install)
        • Motor - Wiper - Windshield (Remove and Install)
        • Neck - Tank - Washer - Windshield (Remove and Replace)
        • Pump - Washer - Windshield (Remove and Install)
        • Sensor - Level - Washer - Windshield (Remove and Install)
        • Tank - Washer - Windshield (Remove and Install)
        • Wiper Arm - Windshield (Remove and Install)
        • Wiper Arm and Blade Assembly - Windshield (Remove and Install)
        • Wiper Blade - Windshield (Remove and Install)
      • 1753 - Horn
      • 1754 - Pedestrian Warning Speaker
      • 1755 - Accelerator Pedal
        • Accelerator Pedal (Remove and Install)
        • Support Bracket - Accelerator Pedal (Remove and Install)
    • 18 - THERMAL MANAGEMENT
      • 1810 - Cabin HVAC
        • Actuator - Blend Door - HVAC (Remove and Replace)
        • Air Extractor (Remove and Install)
        • Blower - HVAC (Remove and Install)
        • Cover - HEPA Filter (Remove and Install)
        • Demist Duct - Quarter Glass - LH (Remove and Install)
        • Duct On Rails - 2nd Row (Remove and Install)
        • Floor Duct - Inboard - LH - Instrument Panel (Remove and Install)
        • Floor Duct - RH - Instrument Panel (Remove and Install)
        • Floor Y Duct - 2nd Row (Remove and Install)
        • HEPA Filter (Remove and Install)
        • HVAC Distribution (Remove and Install)
        • Jumper Duct - Center Console (Remove and Install)
        • Jumper Floor Duct (Remove and Install)
        • Panel Duct - RH (Remove and Install)
        • Pentaport AC Lines (Remove and Replace)
        • Riser Duct - Center Console (Remove and Install)
        • Sensor - Cabin Temperature, Fan Driven (Remove and Install)
        • Sensor - Relative Humidity and Temp (Remove and Install)
        • Sensor - Temperature and Relative Humidity - Windshield (Remove and Install)
        • Suction Discharge Lines (Remove and Install)
        • Wet Side - HVAC (Remove and Install)
      • 1820 - Refrigerant System
        • A/C Compressor (Remove and Replace)
        • A/C Refrigerant (Recovery and Recharge)
        • Acoustic Cover - Compressor (Remove and Install)
      • 1830 - Cooling System
        • Cooling System - Coolant (Drain and Refill)
        • Cooling System (Vacuum Refill)
        • Hose - Inverter to Heat Exchanger - Front Drive Unit (Remove and Install)
        • Hose - Inverter to Heat Exchanger - Rear Drive Unit - LH (Tri Motor) (Remove and Install)
        • Hose - Manifold To Radiator (Remove and Install)
        • Hose - Radiator To Manifold (Remove and Install)
        • Hose - Return - Powertrain (Remove and Install)
        • Hose - Return - Rear Drive Unit (Dual Motor) (Remove and Install)
        • Hose - Return - Rear Drive Unit (Tri Motor) (Remove and Install)
        • Hose - Supply - HV Battery (Remove and Install)
        • Hose - Supply - Inline - Front Drive Unit (Remove and Install)
        • Hose - Supply - Powertrain (Remove and Install)
        • Hose - Supply - Rear Drive Unit (Dual Motor) (Remove and Install)
        • Hose - Supply - Rear Drive Unit (Long Range) (Remove and Install)
        • Hose - Supply - Rear Drive Unit (Tri Motor) (Remove and Install)
        • Hose Bundle - Coolant - HV Battery (Long Range) (Remove and Install)
        • Hose Bundle - Powertrain (Remove and Install)
        • Module - Cooling Fan (Remove and Install)
      • 1840 - Supermanifold
        • Bottle - Coolant - Supermanifold (Remove and Install)
        • Check Valve - Supermanifold (Remove and Install)
        • Check Valve, 16MM - Supermanifold (Remove and Install)
        • Chiller - Supermanifold (Remove and Install)
        • Coil - Expansion Valve - Supermanifold (Remove and Install)
        • Coil, EXV4.5/VCV - Supermanifold (Remove and Replace)
        • Controller - Supermanifold (Remove and Replace)
        • Core - Expansion Valve - Supermanifold (Remove and Install)
        • Core - VCV - SuperManifold (Remove and Replace)
        • Desiccant - Supermanifold (Remove and Install)
        • Filter - ACC - Supermanifold (Remove and Replace)
        • Filter - Chiller - Supermanifold (Remove and Replace)
        • Filter - LCCR - Supermanifold (Remove and Replace)
        • Harness - Center - Supermanifold W/ Standalone Controller (Remove and Install)
        • Octovalve - Supermanifold (Remove and Install)
        • Pump - Coolant - Supermanifold (Remove and Install)
        • Sensor - Powertrain - High Pressure - Supermanifold (Remove and Install)
        • Sensor - Powertrain - Low Pressure - Supermanifold (Remove and Install)
        • Supermanifold (Remove and Replace)
    • 20 - SAFETY AND RESTRAINT
      • 2001 - Air Bags
        • Airbag - Curtain - Driver (Remove and Install)
        • Airbag - Driver (Remove and Install)
        • Airbag - Front Passenger (Remove and Install)
        • Airbag - Knee - Driver (Remove and Install)
        • Airbag - Knee - Front Passenger (Remove and Install)
      • 2005 - Seat Belts
        • Buckle, Mini Anchor - Seat Belt - LH - 2nd Row (Remove and Install)
        • Buckle - Seat Belt - Center/RH - 2nd Row (Remove and Install)
        • Buckle, ZF, Sumitomo - Seat Belt - Driver (Remove and Install)
        • Retractor - Seat Belt - Center - 2nd Row (Remove and Install)
        • Retractor - Seat Belt - Driver (Remove and Install)
        • Retractor - Seat Belt - Outboard - 2nd Row (Remove and Install)
        • Webguide - Seat Belt, Single Fastener (Remove and Install)
      • 2010 - Pre-Tensioners
        • Pretensioner - Lap - Driver (Remove and Install)
      • 2020 - Sensors
        • Impact Sensor - B-Pillar - LH (Remove and Install)
        • Impact Sensor - Fender - LH (Remove and Install)
        • Impact Sensor - Front End Module - LH (Remove and Install)
        • Impact Sensor - Front End Module - RH (Remove and Install)
        • Position Sensor - Seat Track - Driver (Remove and Install)
        • Pressure Sensor - Door - Front - LH (Remove and Install)
        • Pressure Sensor - Door - Front - LH (Remove and Replace)
        • Restraint Control Module (Remove and Install)
        • Restraint Control Module (Remove and Replace)
      • 2030 - Pedestrian Protection System
    • 21 - INFOTAINMENT
      • 2107 - Touchscreen
        • Touchscreen - Center Display Assembly (Remove and Install)
        • Touchscreen - Rear Display (Remove and Install)
      • 2110 - Car Computer
        • Car Computer - Drip Guard (Remove and Install)
        • Car Computer (Remove and Install)
        • Car Computer (Remove and Replace)
      • 2121 - Audio System - Speakers, Subwoofer, Amplifier
        • Horn - Low Tone - LH (Remove and Install)
        • Telephony Microphone - LH (Remove and Install)
        • Pedestrian Warning Speaker (Remove and Install)
        • Speaker (Full Range) - LH (Remove and Install)
        • Speaker - Header - Rear - LH (Remove and Install)
        • Speaker - Super Horn (Remove and Install)
        • Subwoofer - C-Pillar - LH (Remove and Install)
        • Subwoofer - Front Door - LH (Remove and Install)
        • Tweeter - LH (Remove and Install)
        • Audio System - Speakers, Subwoofer and Amplifier - Audio Speakers - Full Range Speaker 100mm (Remove and Install)
      • 2123 - Audio System - AM, FM and HD Radio
      • 2125 - Audio System - Bluetooth
      • 2126 - Audio System - USB Media Port
      • 2130 - Antenna - AM, FM, and HD Radio
      • 2131 - Antenna - Satellite Radio
      • 2132 - Antenna - GPS
      • 2133 - Antenna - Wi-Fi
      • 2135 - Antennas and Amplifiers
        • Antennas and Amplifiers - Antennas and Amplifiers - FM Amplifier Antenna (Remove and Install)
        • FM/HD Tuner (Remove and Install)
        • GPS Antenna (Remove and Install)
        • Telematics Control Unit (TCU) (Remove and Install)
        • Telematics Control Unit (TCU) (Remove and Replace)
    • 30 - CHASSIS
      • 3001 - Chassis and Subframes
        • Chassis Structure Assembly - Front (Remove and Install)
        • Inspect Underbody Fastener Torque
        • Front Inner Panels - Megabeam (Remove and Install)
        • Front Subframe - Recovery Hook - LH (Remove and Replace)
        • Recovery Hook - Pair (Install)
        • Subframe - Rear (Dual Motor) (Remove and Install)
        • Subframe - Rear (Dual Motor) (Remove and Replace)
        • Subframe - Rear (Tri Motor) (Remove and Replace)
    • 31 - SUSPENSION
      • Alignment Requirement - Suspension
      • 3100 - Adjustment
        • Alignment (Coil Spring) (Long Range) (Check and Adjust)
        • Four Wheel Alignment Check and Adjust (Test/Adjust)
        • Four Wheel Alignment Check (No Adjustment Needed) (Test/Adjust)
      • 3101 - Front Suspension (including Hubs)
        • Arm - Lower - Front - LH (Long Range) (Remove and Install)
        • Control Arm - Lower - Front - LH (Remove and Install)
        • Control Arm - Upper - Front - LH (Remove and Install)
        • Coil Spring Assembly - Front - LH (Long Range) (Remove and Replace)
        • Hub - Front - LH (Remove and Install)
        • Hub - Front - LH (Long Range) (Remove and Install)
        • Knuckle - Front - LH (Long Range) (Remove and Install)
        • Knuckle - Front - LH (Remove and Install)
        • Knuckle - Front - LH (Remove and Replace)
        • Link - Stabilizer Bar - Front - LH (Remove and Install)
        • Module - Air Spring - Front - LH (Remove and Install)
        • Stabilizer Bar - Front (Remove and Install)
      • 3103 - Rear Suspension (including Hubs)
        • Aeroshield - Control Arm - Lower - Rear - LH (Remove and Install)
        • Coil Spring Assembly - Rear - LH (Long Range) (Remove and Replace)
        • Control Arm - Lower - Rear - LH (Remove and Install)
        • Control Arm - Upper - Rear - LH (Remove and Install)
        • Hub - Rear- LH (Remove and Install)
        • Knuckle - Rear - LH (Remove and Install)
        • Link - Stabilizer Bar - Rear - LH (Remove and Install)
        • Module - Air Spring - Rear - LH (Remove and Install)
        • Stabilizer Bar - Rear (Remove and Install)
        • Rear Suspension (including Hubs) - Rear Knuckle - Hub and Bearing - Lower Balljoint Assembly (Remove and Install)
        • Rear Suspension (including Hubs) - Rear Knuckle - Hub and Bearing - Upper Balljoint Assembly (Remove and Install)
      • 3110 - Air Suspension System
        • Air Compressor Exhaust Assembly (Remove and Install)
        • Air Suspension Pressure Lines - Air Lines Leak (Inspection)
        • Airline Bundle - LH (Remove and Install)
        • Airline Bundle - Rear (Remove and Install)
        • Airline Bundle - RH (Remove and Install)
        • Airline - Inlet - Valve Block - Air Suspension (Remove and Install)
        • Bracket - Carrier - Compressor - Air Suspension (Remove and Install)
        • Compressor - Air Suspension (Remove and Install)
        • Fill Port - Air Suspension (Remove and Install)
        • Pressurize / Depressurize - Full System (Test/Adjust)
        • Reservoir - Air Suspension (Remove and Install)
        • Ride Height Calibration
        • SCUBA Valve Block Assembly (Remove and Install)
        • Sensor - Ride Height - Front - LH (Remove and Install)
        • Sensor - Ride Height - Rear - LH (Remove and Install)
        • Valve Block - Air Suspension (Remove and Replace)
    • 32 - STEERING
      • 3201 - Steering Rack and Lower Column
        • LPS Harness - Steering Actuator - Rear (Remove and Install)
        • Steering Actuator - Front (Remove and Install)
        • Steering Actuator - Front (Remove and Replace)
        • Steering Actuator - Rear (Remove and Install)
        • Steering Actuator - Rear (Remove and Replace)
        • Steering Gear - Rear (Long Range) (Remove and Install)
        • Tie Rod - Inner - LH - Steering Gear - Front (Remove and Replace)
        • Tie Rod - Outer - LH - Steering Gear - Front (Long Range) (Remove and Install)
        • Toe Link - Rear - LH (Remove and Install)
      • 3205 - Upper Column, Steering Wheel
        • Bezel - Switch - Steering Wheel (Remove and Replace)
        • Clip - Lower - Steering Column Shroud (Remove and Install)
        • Control Module - Steering Column (Remove and Install)
        • Control Module - Steering Column (Remove and Replace)
        • Gap Hider - Instrument Panel - Lower (Remove and Install)
        • Gap Hider - Instrument Panel (Remove and Install)
        • Harness - Steering Wheel (Remove and Install)
        • Set Handwheel Zero
        • Shroud - Lower - Steering Column (Remove and Install)
        • Shroud - Upper - Steering Column (Remove and Install)
        • Shroud - Upper - Steering Wheel (Remove and Install)
        • Steering Feedback Actuator (Remove and Replace)
        • Steering Wheel (Calibration)
        • Steering Wheel Pur Heated (Remove and Install)
        • Steering Wheel Pur Heated (Remove and Replace)
    • 33 - BRAKES
      • 3301 - Brake Discs and Calipers
        • Bleed Screw - Brake Caliper - Rear - LH (Remove and Install)
        • Bleed Screw Kit - Brake Caliper - Front (Remove and Replace)
        • Boot - Brake Caliper - Rear - LH (Remove and Install)
        • Boot Kit - Brake Caliper - Front (Remove and Install)
        • Brake Caliper - Front - LH (Remove and Install)
        • Brake Caliper - Rear - LH (Remove and Install)
        • Brake Pad Kit - Front (Remove and Install)
        • Brake Pad Kit - Rear (Remove and Install)
        • Brake Pads - Burnishing (Maintenance)
        • Brake Rotor - Front - LH (Remove and Install)
        • Brake Rotor - Rear - Base (Remove and Install)
        • Brake Shield - Brake - Rear - LH (Remove and Install)
        • Brake Shield - Front - LH (Remove and Install)
        • Clean And Lubricate Brake Calipers (Integrated Parking Brake) (Requires Code 34012501) (Maintenance)
        • Spring Kit - Brake Caliper - Front (Remove and Install)
        • Springs - Brake Caliper - Rear - LH
        • SVC Brake Caliper - Rear - LH (Without Pads) (Remove and Install)
        • Brake Discs and Calipers - Front Brake Rotors - Calipers and Pads - Front Brake Caliper - Performance - LH (Remove and Install)
        • Brake Discs and Calipers - Front Brake Rotors - Calipers and Pads - Front Brake Caliper - Performance without Pads - LH (Remove and Install)
        • Brake Discs and Calipers - Front Brake Rotors - Calipers and Pads- Front Brake Caliper without Pads - LH (Remove and Install)
        • Brake Discs and Calipers - Rear Brake Rotors - Calipers and Pads - Rear Brake Caliper - Performance - LH (Remove and Install)
        • Brake Discs and Calipers - Rear Brake Rotors - Calipers and Pads - Rear Brake Caliper - Performance without Pads - LH (Remove and Install)
      • 3303 - Brake Pipes and Hoses
        • Brake Fluid Bleed - One Caliper
        • Brake Fluid Bleed/Flush (Maintenance)
        • Brake Hose - Front - LH (Remove and Replace)
        • Brake Hose - Rear - LH (Remove and Replace)
        • Brake Tube Pipe Assembly - LH (Remove and Install)
        • HCU Brake Pipe Assembly (Remove and Install)
      • 3305 - Parking Brake
      • 3310 - ABS, Traction, and Stability Control
        • Bracket Assembly - Hydraulic Control Unit (Remove and Install)
        • Hydraulic Control Unit (Remove and Install)
        • Hydraulic Control Unit (Remove and Replace)
        • Wheel Speed Sensor - Front - LH (Remove and Install)
        • Wheel Speed Sensor - Rear - LH (Remove and Install)
      • 3320 - Electromechanical Brake Booster
        • Brake Booster Assembly (Remove and Install)
        • Brake Remote Reservoir (Remove and Install)
        • Remote Reservoir Tube (Remove and Install)
      • 3325 - Brake Pedal
        • Accelerator Pedal (Remove and Install)
        • Brake Pedal - Option (Remove and Install)
        • Support Bracket - Accelerator Pedal (Remove and Install)
    • 34 - WHEELS AND TIRES
      • 3401 - Wheels
        • Cover - Wheel (Long Range) (Remove and Install)
        • Steel Wheel (Long Range) (Remove and Replace)
        • Wheel Cover - Front - LH (Remove and Install)
        • Wheel Cover - Front - LH (Remove and Replace)
        • Wheel Assembly (Remove and Install)
        • Wheels - Wheel (Remove and Install)
      • 3402 - Tires
        • Replacement Tire Information
        • Tire - Front - LH (Repair) (Tire Repair)
        • Tire Rotation and Balance (Road Force)
        • Tire Rotation (Maintenance)
        • Tires - Tire 285/65R20 Goodyear Wrangler Territory RT (Remove and Install)
      • 3404 - Tire Pressure Monitoring System (TPMS)
        • Tire Pressure Monitoring System (TPMS) - Tire Pressure Monitor Sensor (Inspection)
        • Tire Pressure Monitor Sensor - Front - LH (Remove and Install)
        • Tire Pressure Monitor Sensor - Front - LH (Remove and Replace)
    • 39 - FRONT DRIVE UNIT
      • 3901 - Front Drive Unit Assembly
        • Axle Seal - Output - Front Drive Unit (Remove and Replace)
        • Breather Housing - Front Drive Unit (Remove and Install)
        • Bushing - Gearcase - Front Drive Unit (Remove and Install)
        • Bushing - Side - LH - Front Drive Unit (Remove and Install)
        • Drive Unit - Front (Remove and Install)
        • Drive Unit - Front (Remove and Replace)
        • Electric Oil Pump - Front Drive Unit (Remove and Replace)
        • Ground Strap - Front Drive Unit (Remove and Install)
        • Heat Exchanger - Front Drive Unit (Remove and Install)
        • Mount - Inverter - Front Drive Unit (Remove and Install)
        • NVH Covers - Inverter - Front Drive Uni (Remove and Install)
        • NVH Covers - Motor Side - Front Drive Unit (Remove and Install)
      • 3920 - Front Inverter
        • Cover - Phase Out - Inverter - Front Drive Unit (Remove and Install)
        • Inverter - Front Drive Unit (Remove and Replace)
      • 3930 - Front Gearbox and Halfshafts
        • Gearbox Fluid - Front Drive Unit (Drain and Fill) (Remove and Replace)
        • Front Drive Unit Assembly - Gearbox Fluid (Fill) (Test/Adjust)
        • Halfshaft - LH - Front Drive Unit (Remove and Install)
        • Halfshafts - LH and RH - Front Drive Unit (Remove and Replace)
    • 40 - REAR DRIVE UNIT
      • 4001 - Rear Drive Unit Assembly
        • Axle Seal - Output - Rear Drive Unit (Remove and Install)
        • Breather Housing - Rear Drive Unit (Long Range) (Remove and Install)
        • Breather Housing - Rear Drive Unit (Remove and Install)
        • Bushing - Gearcase - Rear Drive Unit (Remove and Install)
        • Bushing - Side - LH - Rear Drive Unit (Remove and Install)
        • Drive Unit - Rear (Dual Motor) (Remove and Install)
        • Drive Unit - Rear (Dual Motor) (Remove and Replace)
        • Drive Unit - Rear (Tri Motor) (Remove and Replace)
        • Electric Oil Pump - Rear Drive Unit (Remove and Install)
        • Electric Oil Pump - Rear Drive Unit (Remove and Replace)
        • Ground Strap - Rear Drive Unit (Dual Motor) (Remove and Install)
        • Ground Strap - Rear Drive Unit (Long Range) (Remove and Install)
        • Ground Strap - Rear Drive Unit (Tri Motor) (Remove and Replace)
        • Heat Exchanger - Rear Drive Unit - LH (Tri Motor) (Remove and Replace)
        • Heat Exchanger - Rear Drive Unit (Remove and Install)
        • Inverter - Rear (Long Range) (Remove and Replace)
        • Mount - Inverter - Rear Drive Unit (Remove and Install)
        • NVH Cover - Rear Drive Unit (Dual Motor) (Remove)
        • NVH Covers - Inverter - Rear Drive Unit (Remove and Install)
        • NVH Covers - Motor Side - Rear Drive Unit (Remove and Install)
        • Oil Pump - Rear Drive Unit - LH (Tri Motor) (Remove and Install)
        • Oil Pump - Rear Drive Unit - LH (Tri Motor) (Remove and Replace)
      • 4010 - Rear Motor
      • 4020 - Rear Inverter
        • Cover - Phase Out - Drive Inverter - Rear (Long Range) (Remove and Install)
        • Cover - Phase Out - Drive Inverter - Rear (Remove and Install)
        • Drive Inverter - Front and Rear - Set (Dual Motor) (Remove and Replace)
        • Drive Inverter - Rear - LH (Tri-Motor) (Remove and Replace)
        • Drive Inverter - Rear (Remove and Replace)
        • Rear Drive Unit - Rear Drive Inverter - Set (Tri-Motor) (Remove and Replace)
        • Front Drive Unit and LH Rear Drive Inverter (Tri-Motor) (Remove and Replace)
        • Front Drive Unit and RH Rear Drive Inverter (Tri-Motor) (Remove and Replace)
        • Front Drive Unit Assembly and LH and RH Rear Drive Inverters (Tri-Motor) (Remove and Replace)
      • 4030 - Rear Gearbox and Halfshafts
        • Gearbox Fluid - Rear Drive Unit (Dual Motor) (Top Off)
        • Gearbox Fluid - Rear Drive Unit (Tri Motor) (Drain and Fill)
        • Gearbox Fluid - Rear Drive Unit (Tri Motor) (Top Off)
        • Halfshafts - Rear Drive Unit - LH/RH (Remove and Replace)
        • Halfshaft - Rear Drive Unit - LH (Remove and Install)
    • 44 - HIGH VOLTAGE SYSTEM
      • 4400 - High Voltage Testing
        • HV Isolation Diagnostics (Long Range) (Test)
        • Isolation/Insulation Test (Test/Adjust)
      • 4401 - Charge System Inlet
        • Busbar - Chargeport (Long Range) (Remove and Install)
        • Busbar - Chargeport (Long Range) (Remove and Replace)
        • Busbar - Chargeport (Remove and Install)
        • Busbar - Chargeport (Remove and Replace)
        • Charge Port Voltage Check
        • Door - Charge Port (Remove and Install)
        • Door - Charge Port (Remove and Replace)
        • ECU - Charge Port Controller (Gen 4) (Remove and Replace)
        • HV Connector - Busbar - Charge Port (Long Range) (Remove and Install)
      • 4450 - HV Harnesses
        • Bed Outlet Assembly (Remove and Install)
        • Connector - Header - Busbar - Chargeport (Long Range) (Remove and Install)
        • HV Connector Header, Plug (Remove and Install)
        • HV Harness - AC Compressor (Remove and Install)
        • HV Harness - Bed Outlet (Remove and Install)
        • HV Harness - Cabin Outlets (Remove and Install)
        • HV Harness - Front Drive Unit (Remove and Install)
        • HV Harness - Rear Drive Unit - LH (Tri Motor) (Remove and Replace)
        • HV Harness - Rear Drive Unit - RH (Tri Motor) (Remove and Replace)
        • HV Harness - Rear Drive Unit (Dual Motor) (Remove and Install)
    • 50 - EXTERNAL CHARGING CONNECTORS
      • 5001 - Mobile Connector
        • Firmware Update - Mobile Connector
        • Remove Stuck Deadfront - Charge Handle
    • 90 - ACCESSORIES
      • Bed Floor D-Rings (Install)
      • Crossbars (Installation)
      • Off Road Lightbar (Remove and Install)
      • Off Road Lightbar (Remove and Replace)
      • Off Road Lightbar (Retrofit)
      • Retrofit Cybertruck CyberTent (Retrofit)
      • Spare Tire and Tool Kit (Retrofit)
    Send Procedure Feedback
    • © Tesla 2025

    Crowsfoot or Offset Wrench Extension Calculator

    Torque Calculator Values
    Note
    1. If the angle from the extension to the torque wrench is greater than 90° (Figure 2), input E as a positive number.
    2. If the angle from the extension to the torque wrench is less than 90° (Figure 3), input E as a negative number.
    3. If the angle from the extension to the torque wrench is exactly 90°, this calculator is not needed. Torque the fastener to T1.
    Figure 1
    Figure 2
    Figure 3