23/07/2024 17:26:49

Center Console - Wireless Charger Gen 5.0 (Remove and Install)

Correction code 1519023121 FRT 0.06 NOTE: Unless otherwise explicitly stated in the procedure, the above correction code and FRT reflect all of the work required to perform this procedure, including the linked procedures. Do not stack correction codes unless explicitly told to do so. NOTE: See Flat Rate Times to learn more about FRTs and how they are created. To provide feedback on FRT values, email LaborTimeFeedback@tesla.com. NOTE: See Personal Protection to make sure wearing proper PPE when performing the below procedure.

Warning IconA warning icon, calling your attention to a possibly risky situation
Warning
This procedure is a DRAFT. Although it has been validated, Warnings and Cautions might be missing. Follow safety requirements and use extreme caution when working on or near High Voltage systems and components. Provide corrections and feedback to ServiceDevelopment@teslamotors.com.

Remove

  1. Open the LH front door and lower the LH front window.
  2. Move the LH front seat fully rearward.
  3. Remove the LH center floor rail. See Passenger Compartment Carpet - Center Floor Rail - LH (Remove and Install).
  4. Remove the center console front panel. See Center Console - Front Panel Assembly (Remove and Install).
  5. Remove the screws (x4) that attach the center console wireless charger to the center console assembly, release the harness clip and disconnect the electrical connector, and then remove the wireless charger from the vehicle.
    5 Nm (3.7 lbs-ft)
    Tip: Use of the following tool(s) is recommended:
    • Torx T20 socket

Install

  1. Position the center console wireless charger to the center console assembly, secure the harness clip and connect the electrical connector, and then install the screws (x4) that attach the wireless charger to the vehicle.
    5 Nm (3.7 lbs-ft)
    Tip: Use of the following tool(s) is recommended:
    • Torx T20 socket
  2. Install the center console front panel. See Center Console - Front Panel Assembly (Remove and Install).
  3. Install the LH center floor rail. See Passenger Compartment Carpet - Center Floor Rail - LH (Remove and Install).
  4. Restore the LH front seat back to its original position.
  5. Raise the LH front window and close the LH front door.