2020-2024 Model Y Service Manual

  2. Video Library
    2. Video Library

    General Information

    Related links

    • Introduction
    • Best Practices
    • Charging
    • Technical Data
    • Identification Numbers
    • Fluids and Capacities
    • Fluids - Specifications (EMEA)
    • Model Y Service Manual
    • Release Notes
    • General Information
      • Introduction
        • Abbreviations and Symbols
        • Flat Rate Times
        • How to Use this Manual
        • Mobile Service Indicator
        • Repairs and Replacements
        • Warranty Service Regions
      • Best Practices
        • Airbag and Supplementary Restraint System (SRS) Component Replacement Policy
        • Airbag and Supplementary Restraint System (SRS) Precautions
        • Air Conditioning System Precautions
        • Consumable Parts
        • Diagnostic Connector Location
        • Diagnostic Trouble Codes (DTCs)
        • Electrical Precautions
        • Environmental Precautions
        • Ergonomic Precautions
        • Event Data Recorder Retrieval
        • Flexible Pipes and Hoses
        • General Fitting Instructions
        • General Precautions
        • General Safety and Health Precautions
        • Locking Devices
        • Multimeter (LoZ Setting)
        • Oil Seals
        • Personal Protection
        • Pre-Installation Glass Inspection
        • Vehicle Cameras and Autopilot
        • Wheels and Tires
          • Wheel Disposal (Rework)
      • Charging
        • General
      • Technical Data
        • Brakes
        • Electrical
        • Fuse Locations
        • Suspension and Steering
        • Tire Pressures
        • Wheel Alignment
        • Wheels
      • Identification Numbers
        • Vehicle Identification Number (VIN)
        • Serial Numbers
        • Drive Unit Number
        • Manufacturing Certification Label
        • Vehicle and Wheel Paint Codes
        • Type Approval (EU)
      • Fluids and Capacities
      • Fluids - Specifications (EMEA)
    • 00 - Inspection and Service
      • 0001 - Maintenance Service
        • Maintenance Service Intervals
        • Basic Vehicle Inspection (Inspection)
        • Comprehensive Vehicle Inspection
      • 0002 - Firmware Service
        • Software Reinstall - Touchscreen
        • Software Reinstall - Toolbox
        • Software Update
        • User Data (Factory Reset)
      • 0005 - Service Modes
        • OBD Connector (Retrofit)
        • Gateway Configuration (Display and Change)
        • Gateway (Unlock)
        • Diagnostic Trouble Codes (DTCs)
        • Service Mode
        • Service Mode Plus
        • Toolbox (Connect and Disconnect)
      • 0006 - Periodic Roadworthiness Inspections
        • Axle Lifting - 4-Post Lift
        • Ball Joints (Inspect)
        • Disabling PIN to Drive
        • Electronic Parking Brake (EPB) (Test)
        • Headlights and Fog Lights (Check Aiming)
        • Keeping the Vehicle in Neutral
        • Lifting the Vehicle
        • On-Board Diagnostics (OBD) Connector
        • Steering Column - Inspect for Lateral Play (Inspection)
        • Suspension - Front (Inspection)
        • Suspension - Rear (Inspection)
        • Suspension - Front and Rear (Inspection)
        • Vehicle Identification Number (VIN)
    • 10 - Body
      • Torque Specifications - Body
      • 1000 - Vehicle Lifting
        • Raise Vehicle - 2 Post Lift
        • Raise Vehicle - 4 Post Lift
        • Raise Vehicle - Floor Jack (Mobile Service)
      • 1001 - Bumper / Fascia
        • Ankle Catcher (Remove and Replace)
        • Bracket - Fascia Center To Fender - LH (Remove and Replace)
        • Bracket - Fascia Side to Fender - LH (Remove and Replace)
        • Bracket - Rear - Center (Remove and Replace)
        • Bracket - Rear Wing - LH (Remove and Replace)
        • Bracket - Taillight - LH (Remove and Replace)
        • Bumper Beam - Front (Remove and Replace)
        • Bumper Beam - Rear (Remove and Replace)
        • Cover - Tow Hook - Front (Remove and Install)
        • Cover – Trailer Hitch (Remove and Replace)
        • Cover - Trailer Hitch - Rear (Remove and Install)
        • Crush Can - Upper - Front - LH (Remove and Replace)
        • Crush Can - Upper - Front - LH (Structural Pack) (Remove and Replace)
        • Fascia - Front (Remove and Install)
        • Fascia - Front (Remove and Replace)
        • Fascia - Rear (Remove and Install)
        • Fascia - Rear - Lower (Remove and Replace)
        • Fascia - Rear - Upper (Remove and Replace)
        • Foam - Bumper Beam - Front (Remove and Replace)
        • Grille - Fascia - Front (Remove and Replace)
        • Upper Leg Support - Bumper Carrier - Front (Remove and Replace)
        • Super Dash (Structural Pack) (Remove and Replace)
        • Valance - Front Fascia (Remove and Replace)
      • 1010 - Body Panels
        • Body Reinforcement - Floor - 2nd Row (Remove and Replace)
        • Brace - Dash Pencil (Remove and Replace
        • Brace - Shock Tower (Remove and Replace)
        • Bracket - Front End Module (FEM) - LH (Remove and Replace)
        • Carrier - Front End (Remove and Replace)
        • Crush Can - Front Subframe - LH (Remove and Replace)
        • Door - Front - LH (Remove and Install)
        • Door - Front - LH (Remove and Replace)
        • Check Strap - Door - Front - LH (Remove and Replace)
        • Check Strap - Door - Rear - LH (Remove and Replace)
        • Door - Rear - LH (Remove and Install)
        • Door - Rear - LH (Remove and Replace)
        • Fender Assembly - Front - LH (Remove and Install)
        • Fender Assembly - Front - LH (Remove and Replace)
        • Hood (Remove and Install)
        • Hood (Remove and Replace)
        • Liftgate Assembly (Remove and Install)
        • Liftgate Assembly (Remove and Replace)
        • Panel Assembly - Rear (Remove and Replace)
      • 1020 - Windshield and Body Glass
        • Clean Forward Camera View (Precision Cleaning of Inboard Glass)
        • Glass - Backlight (Remove and Install)
        • Glass - Backlight (Remove and Replace)
        • Glass - Body - Rear Quarter - LH (Remove and Install)
        • Glass - Body - Rear Quarter - LH (Remove and Replace)
        • Glass - Roof - Fixed (Remove and Replace)
        • Glass - Roof - Fixed (Remove and Install)
        • Sensor - Relative Humidity and Temperature (Remove and Install)
        • Sensor - Relative Humidity and Temperature (Remove and Replace)
        • VIN Label - Windshield (Remove and Replace)
        • Windshield and Roof Glass Repair and Replacement Guidelines
        • Windshield and Roof Glass Chip Repair
        • Windshield Chip Repair (EMEA)
        • Windshield Scratch Repair
        • Windshield (HW4) (Remove and Replace)
        • Windshield (Non-Structural Pack) (Remove and Replace)
        • Windshield (Reuse Humidity and Temperature Sensor) (HW3) (Remove and Replace)
      • 1030 - Paint
        • Paint Defect Rectification
      • Panel Alignment
        • Fender Alignment
        • Front Door Alignment
        • Hood Alignment
        • Panel Alignment Specifications
    • 11 - Closures
      • Torque Specifications - Closures
      • 1133 - Closure Assist Mechanisms and Hinges
        • Ball Stud - Liftgate - LH (Remove and Replace)
        • Ball Stud - Liftgate - Body Side - Pair (Remove and Replace)
        • Bump Stop - Liftgate - LH (Remove and Replace)
        • Gas Strut - Hood - LH (Remove and Replace)
        • Hinge - Door - Front - Lower - LH (Remove and Replace)
        • Hinge - Door - Front - Lower - LH (Structural Pack) (Rework)
        • Hinge - Door - Front - Upper - LH (Remove and Replace)
        • Hinge - Door - Rear - Lower - LH (Remove and Replace)
        • Hinge - Door - Rear - Upper - LH (Remove and Replace)
        • Hinge - Door - Rear - Upper - LH (Structural Pack) (Rework)
        • Hinge - Hood - LH (Remove and Replace)
        • Hinge - Liftgate - LH (Remove and Replace)
        • Power Strut - Liftgate (Remove and Replace)
        • Strut Assist - Liftgate (Remove and Replace)
      • 1135 - Latches Strikers and Pinch Sensors
        • Actuator - Latch - Hood (Single Actuator System) (Remove and Replace)
        • Latch - Door - Front - LH (Remove and Replace)
        • Latch - Door - Rear - LH (Remove and Replace)
        • Latch - Hood (Remove and Replace)
        • Latch - Liftgate (Remove and Replace)
        • Manual Release - Door - Rear - LH (Actuate)
        • Striker - Door - Front - LH (Remove and Replace)
        • Striker - Door - Rear - LH (Remove and Replace)
        • Striker - Hood (Remove and Replace)
        • Striker - Liftgate (Remove and Replace)
        • Switch and Camera Assembly - Exterior Release - Liftgate (Remove and Replace)
        • Switch - Liftgate - Exterior (Remove and Replace)
        • Switch - Liftgate - Interior (Remove & Replace)
      • 1145 - Exterior Door Handles
        • Apply WD-40 to Door Handle Pivot Pins (Maintenance)
        • Handle - Exterior Release - Door - Front - LH (Remove and Replace)
        • Handle - Exterior Release - Door - Rear - LH (Remove and Replace)
      • 1150 - Door Glass and Regulators
        • Glass - Door - LH - Front (Remove and Replace)
        • Glass - Door - LH - Rear (Adjust)
        • Glass - Door - LH - Rear (Remove and Replace)
        • Switch - Window - Driver (Remove and Replace)
        • Switch - Window - Driver (Remove and Replace) (RHD)
        • Switch - Window - Front Passenger (Remove and Replace)
        • Switch - Window - Rear (Remove and Replace)
        • Window Regulator Motor - Front - LH (Remove and Replace)
        • Window Regulator Motor - Rear - LH (Remove and Replace)
        • Window Regulator - Front - LH (Remove and Replace)
        • Window Regulator - Rear - LH (Remove and Replace)
        • Window Regulator (Recalibrate)
      • 1170 - Seals Body Closures
        • Closeout Panel - Door - Front - LH (Remove and Replace)
        • Closeout Panel - Door - Rear - LH (Remove and Install)
        • Closeout Panel - Door - Rear - LH (Remove and Replace)
        • Seal - B-Pillar Applique - LH (Remove and Replace)
        • Seal - Body - Side - Front - Primary - LH (Remove and Replace)
        • Seal - Body - Side - Rear - Primary - LH (Remove and Replace)
        • Seal - Glass Run - Front Door - LH (Remove and Replace)
        • Seal - Header - LH (Remove and Replace)
        • Seal - Hood (Remove and Replace)
        • Seal - Inner Belt - Front Door - LH (Remove and Replace)
        • Seal - Inner Belt - Rear Door - LH (Remove and Replace)
        • Seal - Liftgate - Side - LH （Remove and Replace)
        • Seal - Outer Belt - Front Door - LH (Remove and Replace)
        • Seal - Outer Belt - Rear Door - LH (Remove and Replace)
        • Seal - Secondary - Front Door - LH (Remove and Replace)
        • Seal - Secondary - Rear Door - LH (Remove and Replace)
        • Seal - Trunk (Remove and Replace)
    • 12 - Exterior Fittings
      • Torque Specifications - Exterior Fittings
      • 1201 - Wheel Arch Liners
        • Noise Absorber - Motor Bay - Front (Remove and Replace)
        • Noise Absorber - Motor Bay - Rear (Remove and Replace)
        • Wheel Arch Liner - Front - LH (Non-Structural Pack) (Remove and Replace)
        • Wheel Arch Liner - Front - LH (Structural Pack) (Remove and Replace)
        • Wheel Arch Liner - Rear - LH (Non-Structural Pack) (Remove and Replace)
        • Wheel Arch Liner - Rear - LH (Structural Pack) (Remove and Replace)
      • 1203 - Undertray and Diffuser
        • Diffuser - Rear Fascia (Remove and Replace)
        • Panel - Aero Shield - Front (Non-Structural Pack) (Remove and Replace)
        • Panel - Aero Shield - Front (Structural Pack) (Remove and Replace)
        • Panel - Aero Shield - Rear (Remove and Replace)
      • 1205 - Badges and Films
        • Paint Protection Film - Rear Doors (Retrofit)
        • Sill Plate - Front - LH (Remove and Replace)
        • Tesla Badge - Front (Remove and Replace)
        • Tesla Badge - Rear (Remove and Replace)
        • Badge - Rear - LH (Remove and Replace) (China)
        • Vehicle Configuration Badge (Remove and Replace)
      • 1207 - License Plate Mountings
        • Bracket - License Plate - Front (EMEA) (Retrofit using Jig)
        • Bracket - License Plate - Front (Remove and Replace)
        • Bracket - License Plate - Front (Retrofit)
        • Bracket - License Plate - Rear (Retrofit)
        • Bracket - License Plate - Rear (EMEA and APAC) (Remove and Replace)
        • Bracket - License Plate - Rear (NA) (Remove and Replace)
      • 1209 - Exterior Mirrors
        • Door Mirror Assembly - LH (Remove and Install)
        • Glass - Door Mirror - LH (Remove and Replace)
        • Mirror - Door - LH (Remove and Replace)
        • Skull Cap - Door Mirror - LH (Remove and Replace)
      • 1220 - Exterior Trim
        • Applique - A-Pillar - Mirror - Door - LH (Remove and Replace)
        • Applique - B-Pillar - LH (Remove and Replace)
        • Brightwork - Upper - LH (Remove and Replace)
        • Carrier - Rocker Panel - LH (Remove and Replace)
        • Carrier - Rocker Panel - LH (Structural Pack) (Remove and Replace)
        • Cover - Applique - B-Pillar - LH (Remove and Replace)
        • Cover - Rocker Panel - Lower - LH (Remove and Replace)
        • Garnish - Fender - Rear - LH (Remove and Replace)
        • Garnish - Fender - Front - LH (Remove and Replace)
        • Mud Flaps (Retrofit)
        • Mud Flap - LH (Remove and Replace)
      • 1222 - Spoiler
        • Spoiler - Rear (Remove and Install)
        • Spoiler - Rear (Remove and Replace)
        • Spoiler - Rear (Retrofit using Jig)
      • 1225 - Underhood Trim
        • Baffle - Hood (Remove and Replace)
        • Bracket - Center - Cowl Screen (Remove and Replace)
        • Cover - Shock Tower - LH (Remove and Replace)
        • Panel - Cowl Screen (Remove and Replace)
        • Panel - Cowl Screen (Remove and Replace) (RHD)
        • Underhood Apron - Rear (Remove and Replace)
      • 1230 - Trailer Hitch
        • Assembly - Trailer Hitch (Remove and Replace)
        • Assembly - Trailer Hitch (Retrofit)
        • ECU – Trailer Hitch (Remove and Replace)
      • 1240 - Roof Rack
        • Roof Rack (Install)
    • 13 - Seats
      • Torque Specifications - Seats
      • 1301 - Front Seat Tracks and Motors
        • Button - Cushion Adjust - Driver Seat (Remove and Replace)
        • Cover - Front - Seat Track - 1st Row Seat (Remove and Replace)
        • Cover - Rear - Seat Track - 1st Row Seat (Remove and Replace)
        • Frame - Seat Cushion - Driver Seat (Remove and Replace)
        • Frame - Seat Cushion - Front Passenger Seat (Remove and Replace)
        • Module - ECU - Occupant Classification System (OCS) - Front Passenger (Remove and Replace)
        • Motor - Recliner - Backrest - Driver Seat (Remove and Replace)
        • Motor - Recliner - Back Rest - Front Passenger Seat (Remove and Replace)
        • Motor - Seat Height - Driver Seat (Remove and Replace)
        • Motor - Seat Track - Driver Seat (Remove and Replace)
        • Motor - Seat Track - Front Passenger Seat (Remove and Replace)
        • Motor - Seat Tilt - Driver Seat (Remove and Replace)
        • Motor - Seat Tilt - Front Passenger Seat (Remove and Replace)
        • Plastic Insulator - Suspension - Driver Seat (Remove and Replace)
        • Podium - Seat - Front - LH (Remove and Replace)
        • Recline Button - Switch - Driver Seat (Remove and Replace)
        • Riser - Driver Seat - LH (Remove and Replace)
        • Sensor - Position - Track - 1st Row Seat - RH (Remove and Replace)
        • Switch - Back Rest and Cushion Adjust - Front Passenger Seat (Rework)
        • Switch - Back Rest and Cushion Adjust - Driver Seat (Remove and Replace)
        • Track - Inner - Front Passenger Seat (Remove and Replace)
        • Track - Outer - Front Passenger Seat (Remove and Replace)
      • 1302 - 2nd Row Seat Tracks and Motors
        • Actuator - Floor Latch - 2nd Row Seat - LH (7-Seat) (Remove and Replace)
        • Actuator - Floor Latch - 2nd Row Seat - RH (7-Seat) (Remove and Replace)
        • Actuator - EZ Entry - 60 Track - 2nd Row Seat (7-Seat) (Remove and Replace)
        • Actuator - EZ Entry - 40 Track - 2nd Row Seat (7-Seat) (Remove and Replace)
        • Casting - Podium - 2nd Row Seat - LH (7-Seat) (Remove and Replace)
        • Cover - Seat Track - 2nd Row Seat - Center (7-Seat) (Remove and Replace)
        • Cover - Seat Track - 2nd Row Seat - LH (7-Seat) (Remove and Replace)
        • Cover - Seat Track - 2nd Row Seat - RH (7-Seat) (Remove and Replace)
        • Podium - 2nd Row Seat - RH (7-Seat) (Remove and Replace)
        • Seat Track - Inner - 2nd Row Seat - LH (7-Seat) (Remove and Replace)
        • Seat Track - Inner - 2nd Row Seat - RH (7-Seat) (Remove and Replace)
        • Seat Track - Outer - 2nd Row Seat - LH (7-Seat) (Remove and Replace)
        • Seat Track - Outer - 2nd Row Seat - RH (7-Seat) (Remove and Replace)
        • Sensor - Position - Seat Track - 2nd Row Seat - RH (Remove and Replace)
        • Towel Bar - 2nd Row Seat - LH (7-Seat) (Remove and Replace)
      • 1304 - Front Seat Assemblies and Hardware
        • Frame - Back Rest - Front Passenger Seat (Remove and Replace)
        • Lumbar Support - Backrest - Driver Seat (Remove and Replace)
        • Lumbar Support - Back Rest - Front Passenger Seat (Remove and Replace)
        • Post Guide - Headrest - Driver Seat (Remove and Replace)
        • Post Guide - Headrest - Front Passenger Seat (Remove and Replace)
        • Shell - Seat Back - Driver (Remove and Replace)
        • Seat Assembly - 1st Row - LH (Remove and Replace)
        • Seat Assembly - 1st Row - LH (Structural Pack) (Retrofit)
        • Trim - Headrest - Driver (Remove and Replace)
      • 1305 - 2nd Row Seat Assemblies and Hardware
        • 1305 - 2nd Row Seat Assemblies and Hardware (7-Seat)
          • Adjustment Guide - Headrest - 2nd Row (Remove and Replace)
          • Backrest Switch – Seat Back – 2nd Row – Center (Remove and Replace)
          • Cushion Pan - 2nd Row Seat - LH (7-Seat) (Remove and Replace)
          • Cushion Pan - 2nd Row Seat - RH (7-Seat) (Remove and Replace)
          • Headrest - 2nd Row - Center (Remove and Replace)
          • Headrest - 2nd Row - Outer - LH (Remove and Replace)
          • Lumbar Bun - 2nd Row - Center/20 (Remove and Replace)
          • Seat Assembly - 2nd Row - LH (7-Seat) (Remove and Replace)
          • Seat Assembly - 2nd Row - RH (7-Seat) (Remove and Replace)
          • Switch Box - Actuator - 2nd Row Seat - LH (7-Seat) (Remove and Replace)
          • Switch Box - Actuator - 2nd Row Seat - RH (7-Seat) (Remove and Replace)
        • 1305 - 2nd Row Seat Assemblies and Hardware (5-Seat)
          • Actuator - Recliner - 2nd Row - 20 (Remove & Replace)
          • Armrest - 2nd Row (Remove and Replace)
          • Adjustment Guide - Headrest - 2nd Row (Remove and Replace)
          • Backrest Switch – Seat Back – 2nd Row – Center (Remove and Replace)
          • Closeout - Armrest - 2nd Row (Remove and Replace)
          • Guide Lock - Headrest - 2nd Row (Remove and Replace)
          • Headrest - 2nd Row - Center (Remove and Replace)
          • Headrest - 2nd Row - Outer - LH (Remove and Replace)
          • Latch - Seat Back - 2nd Row - Center (Remove and Replace)
          • Lumbar Bun - 2nd Row - Center/20 (Remove and Replace)
          • Pivot Clamps - Seat Back - 2nd Row - Center/20 (Remove and Replace)
          • Pivot Bushing - Seat back - 2nd Row - Center (Remove and Replace)
          • Recliner Actuator - Seat Back - 2nd Row - RH (Remove and Replace)
          • Recliner Actuator - Seat Back - 2nd Row - LH (Remove and Replace)
          • Seat Back - 2nd Row - LH (Remove and Replace)
          • Seat Back - 2nd Row - RH (Remove and Replace)
          • Seat Cushion - Lower - 2nd Row (Remove and Replace)
          • Shoulder Switch – Seat Back – 2nd Row – LH (Remove and Replace)
          • Switch - Seat Fold (Remove and Replace)
      • 1306 - 3rd Row Seat Assemblies and Hardware
        • Actuator - Recliner - 3rd Row Seat - LH (Remove and Replace)
        • Back Panel - 3rd Row Seat - LH (Remove and Replace)
        • Bolster - Seat Cushion - 3rd Row - LH (Remove and Replace)
        • Headrest - 3rd Row - LH (Remove and Replace)
        • Seat Backs - 3rd Row (Remove and Replace)
        • Cushion - Seat - 3rd Row (Remove and Replace)
        • Shoulder Switch – Seat Back – 3rd Row – LH (Remove and Replace)
        • Substrate - Seat Back - 3rd Row - LH (Remove and Replace)
        • USB Hub - Seat - 3rd Row (Remove and Replace)
      • 1307 - Front Seat Covers Pads and Trims
        • Carrier - Side Shield - Inboard - Driver Seat (Remove and Replace)
        • Carrier - Side Shield - Outboard - Driver Seat (Remove and Replace)
        • Cover - Back Rest - Driver (With Inboard Airbag) (Remove and Replace)
        • Diamond Cover - Seat Side - 1st Row - LH (Remove and Replace)
        • Diamond Cover - Seat Side - 1st Row - RH (Remove and Replace)
        • Side Shield - Outboard - Driver Seat (Remove and Replace)
        • Foam - Backrest - Driver Seat (Remove and Replace)
        • Foam - Backrest - Driver Seat (With Inboard Airbag) (Remove and Replace)
        • Foam - Cushion - Driver Seat (Remove and Replace)
        • Foam - Cushion - Front Passenger Seat (Remove and Replace)
        • Foam - Seat Back - Front Passenger Seat (Remove and Replace)
        • Seat Cushion Foam and SBR Sensor and Heat Pad - 1st Row - LH (Remove and Replace)
        • Side Shield - Inboard - Driver Seat (Remove and Replace)
        • Stiffener - Sideshield - 1st Row Seat - Outer (Remove and Replace)
        • Suspension - Seat Cushion - Driver Seat (Remove and Replace)
        • Trim - Cushion - Driver Seat (Clip Fasteners) (Remove and Replace)
        • Trim - Cushion - Driver Seat (Hog Ring Fasteners) (Remove and Replace)
        • Trim - Cushion - Front Passenger Seat (Clip Fasteners) (Remove and Replace)
        • Trim - Seat Back - Driver Seat (Remove and Replace)
      • 1308 - 2nd Row Seat Covers Pads and Trims
        • 1308 - 2nd Row Seat Covers Pads and Trims (5-Seat)
          • Cover - Seat Back - 2nd Row - LH (5-Seat) (Remove and Replace)
          • Cover - Seat Back - 2nd Row Seat - RH (Remove and Replace)
          • Cup Holder - 2nd Row (Remove and Replace)
          • B-Cover - Inner - 2nd Row - Center (Remove and Replace)
          • B-Cover - Outer - Inboard - 2nd Row Seat - LH (Remove and Replace)
          • B-Cover - Outer - Inboard - 2nd Row Seat - RH (Remove and Replace)
          • B-Cover - Outer - 2nd Row - LH (Remove and Replace)
          • B-Cover - Outer - 2nd Row - RH (Remove and Replace)
          • B-Cover - Outer - 2nd Row - Center (Remove and Replace)
          • Back Panel – 2nd Row Seat – Center/20 (5-Seat) (Remove and Replace)
          • Back Panel – 2nd Row Seat – LH (Remove and Replace)
          • Back Panel – 2nd Row Seat – RH (Remove and Replace)
        • 1308 - 2nd Row Seat Covers Pads and Trims (7-Seat)
          • B-Cover - 2nd Row - Inner - LH (7-Seat) (Remove and Replace)
          • B-Cover - Outer - 2nd Row - RH (7-Seat) (Remove and Replace)
          • Back Panel – 2nd Row Seat – Center/20 (7-Seat) (Remove and Replace)
          • Cover - Seat Back - 2nd Row - LH (7-Seat) (Remove and Replace)
          • Cover - Seat Back - 2nd Row - RH (7-Seat) (Remove and Replace)
          • Cover - Toe Kick - 2nd Row Seat - RH (7-Seat) (Remove and Replace)
          • Cover - Toe Kick - 2nd Row Seat - LH (7-Seat) (Remove and Replace)
          • Foam - Cushion - 2nd Row Seat - LH (7-Seat) (Remove and Replace)
          • Shell - Backrest - 2nd Row - LH (7-Seat) (Remove and Replace)
          • Side Shield Sub-Assembly - 2nd Row Seat (7-Seat) (Remove and Replace)
          • Trim - Cushion - 2nd Row Seat - LH (7-Seat) (Remove and Replace)
          • Trim - Cushion - 2nd Row Seat - RH (7-Seat) (Remove and Replace)
      • 1309 - 3rd Row Seat Covers Pads and Trims
        • B-Cover - Inner - 3rd Row - Center (Remove and Replace)
        • B-Cover - Inner - 3rd Row - LH (Remove and Replace)
        • B-Cover - Outer - 3rd Row - Center (Remove and Replace)
        • B-Cover - Outer - 3rd Row - LH (Remove and Replace)
        • Closeout - Cup Holder - Seat - 3rd Row (Remove and Replace)
        • Headrest Closeout - 3rd Row Seat - LH (Remove and Replace)
        • Cover - Seat Back - 3rd Row - LH (Remove and Replace)
        • Liner - Cup Holder - Seat - 3rd Row (Remove and Replace)
    • 14 - Instrument Panel
      • Torque Specifications - Instrument Panel
      • 1405 - Instrument Panel
        • Beam - Cross Car (Remove and Replace)
        • Cover - Footwell - Driver (Remove and Replace)
        • Cover - Footwell - Passenger (LHD) (Remove and Replace)
        • Cover - Footwell - Passenger (RHD) (Remove and Replace)
        • Decor Trim - Instrument Panel - Main (LHD) (Remove and Replace)
        • Decor Trim - Instrument Panel - Main (Remove and Replace) (RHD)
        • Decor Trim - Instrument Panel - Main (Rework)
        • Defrost Cover - Instrument Panel - LH (Remove and Replace)
        • End Cap - Air Wave - LH (Remove and Replace)
        • End Cap - Instrument Panel - LH (Remove and Replace)
        • Finisher - Vent (Remove and Replace)
        • Gap Hider - Steering Column - Lower (Remove and Replace)
        • Gap Hider - Steering Column - Upper (Remove and Replace)
        • Glove Box - With Knee Airbags (Remove and Replace)
        • Glove Box - Without Knee Airbags (Remove and Replace)
        • Grille - Speaker - Instrument Panel (Remove and Replace)
        • Housing - Center Display (Remove and Replace)
        • IP Carrier (Remove and Install)
        • IP Carrier (Remove and Replace)
        • NVH Pad - Glove Box (Remove and Replace)
        • NVH Pad - Instrument Panel - Upper (Remove and Replace)
        • Vent - Front - LH (Remove and Replace)
        • Vent - Front - RH (Remove and Replace)
        • Riser - Instrument Panel (Remove and Replace)
        • Shroud - Upper - Steering Column (Remove and Replace)
    • 15 - Interior Trim
      • Torque Specifications - Interior Trim
      • 1505 - Interior Mirror and Sun Visors
        • Bezel - Rear View Mirror (Remove and Replace)
        • Check Base - Magnetic - Sun Visor - LH (Remove and Replace)
        • Check Base - Sun Visor - LH (Remove and Replace)
        • Glare Shield (Remove and Replace)
        • Mirror - Rear View (Remove and Replace)
        • Quad Camera Cover - Lower (Remove and Replace)
        • Quad Camera Cover - Upper (Remove and Replace)
        • Quad Camera Cover - Upper (Remove and Replace) (RHD)
        • Sun Visor - LH (Remove and Replace)
      • 1511 - Liftgate Trim
        • Bracket - Side Trim - Liftgate - LH (Remove and Replace)
        • Cover - Latch - Liftgate (Remove and Replace)
        • Grille - Speaker - Liftgate - LH (Remove and Replace)
        • Trim - Liftgate - Lower (Remove and Replace)
        • Trim - Upper - Liftgate (Remove and Replace)
      • 1513 - Door Trim
        • Armrest - Door - Driver Seat (Remove and Replace)
        • Decor - Trim - Front Door - LH (Remove and Replace)
        • NVH Pad - Door - Front - LH (Remove and Replace)
        • NVH Pad - Door - Rear - LH (Remove and Replace)
        • Panel - Door Trim - Front - LH (Remove and Install)
        • Panel - Door Trim - Front - LH (Remove and Replace)
        • Panel - Door Trim - Rear - LH (Remove and Install)
        • Panel - Door Trim - Rear - LH (Remove and Replace)
        • Reflector - Door - Front - LH (Remove and Replace)
        • Switch - Interior Door Release - Front - LH (Remove and Replace)
        • Switch - Interior Door Release - Rear - LH (Remove and Replace)
      • 1518 - Pillar and Sill Trim
        • Bezel - Seatbelt - C-Pillar - LH (Remove and Replace)
        • Bracket - C-Pillar - LH (Remove and Replace)
        • Bracket - Harness - Sill Panel - Front - LH (Remove and Replace)
        • Ramp - Airbag - B-Pillar - LH (Remove and Replace)
        • Trim - A-Pillar - Lower - LH (Remove and Replace)
        • Trim - A-Pillar - Middle - LH (Remove and Replace)
        • Trim - A-Pillar - Upper - LH (Remove and Replace)
        • Trim - B-Pillar - Lower - LH (Non-Structural Pack) (Remove and Replace)
        • Trim - B-Pillar - Lower - LH (Structural Pack) (Remove and Replace)
        • Trim - B-Pillar - Mid - LH (Structural Pack) (Remove and Replace)
        • Trim - B-Pillar - Upper - LH (Remove and Replace)
        • Trim - C-Pillar - Lower - LH (Remove and Replace)
        • Trim - C-Pillar - Lower - LH (7 Seat) (Remove and Replace)
        • Trim - C-Pillar - Upper - LH (Remove and Replace)
      • 1519 - Center Console
        • Armrest - Center Console (Remove and Replace)
        • Assembly - Rear Vent - Center Console (Remove and Replace)
        • Bright Strip - Center Console - LH (Remove and Replace)
        • Brightwork - Center Console (2.0) (Remove and Replace)
        • Center Console (Remove and Install)
        • Center Console (Remove and Replace)
        • Center Console (2.0) (Structural Pack) (Remove and Install)
        • Center Console (2.0) (Structural Pack) (Remove and Replace)
        • Cup Holder (Remove and Replace)
        • Decor Trim - Center Console - LH (Remove and Replace)
        • Decor Trim - Cup Holder - Center Console (Remove and Replace)
        • End Panel - Center Console (Remove and Replace)
        • H-Decor Trim - Center Console (2.0) (Remove and Replace)
        • Insert - Front Bin - Center Console (Remove and Replace)
        • LED Light - Center Console (Remove and Replace)
        • Liner - Cup Holder - Center Console (2.0) (Remove and Replace)
        • Module - Inductive Charger - Center Console (2.0) (Remove and Replace)
        • Panel - Lower Rear - Center Console (Remove and Replace)
        • Phone Dock Bar - Center Console (Remove and Replace)
        • Phone Tray - Center Console (Remove and Replace)
        • Puddle Lamp - Center Console (Remove and Replace)
        • Rail - Lower - Center Console - LH (Structural Pack) (Remove and Replace)
        • Side Panel - Center Console - LH (Remove and Replace)
        • Side Panel - Center Console - LH (RHD) (Remove and Replace)
        • Sliding Lid - Center Console (Remove and Replace)
        • Switch - Light - Center Console (Remove and Replace)
      • 1520 - Headliner
        • Coat Hook - Rear - LH (Remove and Replace)
        • Headliner - Rear (Remove and Replace)
        • Headliner - Front (Remove and Replace)
        • Headliner Assembly (Remove and Install)
        • Headliner Assembly (Remove and Replace)
        • Overhead Console - Front (Remove and Replace)
      • 1524 - Luggage Compartment Trim
        • Access Panel - Underhood Storage Unit (Remove and Replace)
        • Bracket - Trunk Load Floor - LH (Remove and Replace)
        • Bracket - Trunk Pocket - LH (Remove and Replace)
        • Folding Parcel Shelf - Rear Trunk (Remove and Replace)
        • Tie Down - Front - LH (Remove and Replace)
        • Tie Down - Rear - LH (Remove and Replace)
        • Trim - Side - Trunk - LH (Remove and Replace)
        • Trim - Sill - Trunk (Remove and Replace)
        • Trunk Assembly - Lower (Remove and Replace)
        • Trunk Load Floor - Front (Remove and Replace)
        • Trunk Load Floor - Rear (Remove and Replace)
        • Tub - Rear Trunk (Remove and Replace)
        • Underhood Storage Unit (Remove and Replace)
      • 1530 - Carpeting and Mats
        • Bracket - Rucket - LH (Remove and Replace)
        • Carpet - 2nd Row (7-Seat) (Remove and Replace)
        • Carpet - 3rd Row (Remove and Replace)
        • Carpet - Front - LH (7-Seat) (Remove and Replace)
        • Carpet - Front - LH (Remove and Replace)
        • Carpet - Front - LH (Structural Pack) (Remove and Replace)
        • Carpet - Front - RH (7-Seat) (Remove and Replace)
        • Carpet - Front - RH (Structural Pack) (Remove and Replace)
        • Carpet - Interior Complete (Remove and Replace)
        • Carpet - Rear (Remove and Replace)
        • Floor Mat Set (Remove & Replace)
        • Front Carpet - Rear Trunk (Remove and Replace)
        • Front Wheelhouse NVH Absorber - LH (Remove and Replace)
        • Insulator - Dash (Remove and Replace)
        • Insulator - Wheelhouse - LH (Remove and Replace)
        • Insulator - Wheelhouse - Set (Remove & Replace)
        • Mat - Front Bin - Center Console (Remove and Replace)
        • NVH Insulator - 3rd Row Seat (Remove and Replace)
        • NVH Insulator - Center Underbody (Remove and Replace)
        • NVH Stuffer - Quarter Cavity - LH (Remove and Replace)
        • NVH Stuffer - Quarter Cavity - RH (Remove and Replace)
        • Support - Carpet - LH (Structural Pack) (Remove and Replace)
        • Support - Carpet - RH (Structural Pack) (Remove and Replace)
        • Wheelhouse Insulator - Rear - RH (Remove and Replace)
    • 16 - Battery System
      • Torque Specifications - Battery System
      • 1601 - HV Battery Assembly
        • HV Battery (AWD) (7-Seat) (Remove and Install)
        • HV Battery (AWD) (7-Seat) (Remove and Replace)
        • HV Battery (AWD) (Non-Structural Pack) (Remove and Install)
        • HV Battery (AWD) (Non-Structural Pack) (Remove and Replace)
        • HV Battery (AWD) (Structural Pack) (Remove and Install)
        • HV Battery (AWD) (Structural Pack) (Remove and Replace)
        • HV Battery (RWD) (Remove and Install)
        • HV Battery (RWD) (Remove and Replace)
        • HV Battery (RWD) (Structural Pack) (Remove and Replace)
        • HV Battery (RWD) (Structural Pack) (1-Phase to 3-Phase) (Retrofit)
      • 1610 - HV Battery Enclosure
        • Ancillary Bay Air Leak Test (Non-Structural Pack) (Inspection)
        • Ancillary Bay Air Leak Test (Structural Pack)
        • Bracket - Skid Plate - Front - HV Battery (Remove and Replace)
        • Cover - Ancillary Bay (Remove and Install)
        • Cover - Ancillary Bay (Remove and Replace)
        • Cover - Ancillary Bay (7-Seat) (Remove and Replace)
        • Cover - Ancillary Bay (7-Seat) (Remove and Install)
        • Cover - Ancillary Bay (Structural Pack) (Remove and Replace)
        • Cover - Ancillary Bay (Structural Pack) (3-Phase) (Remove and Replace)
        • Cover - HV Probe - HV Battery (Remove and Replace)
        • Flood Ports - 2nd Generation (Remove and Replace)
        • Flood Port - Rear (Structural Pack) (Remove and Replace)
        • HV Battery Air Leak Test
        • HV Battery Air Leak Test (Structural Pack)
        • NVH Pads - HV Battery (Install)
        • Platter Enclosure Air Leak Test
        • Platter Enclosure Air Leak Test (Structural Pack)
        • Retainer - Flood Port - LH (Remove and Replace)
        • Seal - Perimeter - HV Battery (Remove and Replace)
        • Ski - Center Rail - HV Battery (Dual Motor) (Remove and Replace)
        • Skid Plate - HV Battery - Front (Remove and Replace)
        • Skid Plate - HV Battery - Rear (Remove and Replace)
        • Snap-In Vent - HV Battery - LH (Remove and Replace)
        • Thermal Vent (Structural Pack) (Remove and Replace)
        • Vent Assembly - HV Battery - LH (Remove and Replace)
        • Wade Seal - HV Battery (Structural Pack) (Remove and Replace)
        • Wade Seal - HV Battery (Structural Pack) (Rework)
      • 1620 - HV Battery Cooling System
        • Ancillary Bay Coolant (Drain and Refill)
        • Ancillary Bay Coolant Leak Test
        • Platter Enclosure Coolant (Drain and Refill)
        • Platter Enclosure Coolant Leak Test
        • Tube - Input - Coolant - Power Conversion System (Remove and Replace)
        • Tube - Input - Coolant - Power Conversion System (Structural Pack) (Remove and Replace)
        • Tube - Output - Coolant - Power Conversion System (Remove and Replace)
        • Tube - Output - Coolant - Power Conversion System (Structural Pack) (Remove and Replace)
      • 1630 - HV Battery Electrical Components
        • Busbar - Auxiliary Fuse - HV Battery (Structural Pack) (Remove and Replace)
        • Busbar - Inlet - Negative - Fast Charge - HV Battery (Structural Pack) (Remove and Replace)
        • Busbar - Inlet - Positive - Fast Charge - HV Battery (Structural Pack) (Remove and Replace)
        • Busbar - Outlet - Negative - Fast Charge - HV Battery (Structural Pack) (Remove and Replace)
        • Busbar - Outlet - Positive - Fast Charge - HV Battery (Structural Pack) (Remove and Replace)
        • Contactor - Fast Charge - HV Battery (3-Phase) (Structural Pack) (Remove and Replace)
        • Contactor - Fast Charge - HV Battery (Remove and Replace)
        • Contactor - Fast Charge - HV Battery (Structural Pack) (Remove and Replace)
        • Contactor - Fast Charge - HV Battery (7-Seat) (Remove and Replace)
        • Contactor - Negative - HV Battery (Non-Structural Pack) (Remove and Replace)
        • Contactor - Negative - HV Battery (Structural Pack) (Remove and Replace)
        • Contactor - Positive - HV Battery (Non-Structural Pack) (Remove and Replace)
        • Contactor - Positive - HV Battery (Structural Pack) (Remove and Replace)
        • Controller - High Voltage (Backup and Restore)
        • Controller - High Voltage (Non-Structural Pack) (Remove and Replace)
        • Controller - High Voltage (Structural Pack) (Remove and Replace)
        • Controller - High Voltage (7-Seat) (Remove and Replace)
        • Cover - Busbar - Shunt - HV Battery (Remove and Replace)
        • Cover - Pyrotechnic - HV Battery (Remove and Replace)
        • DC Input Assembly - HV Battery (Busbar Type) (Remove and Replace)
        • Ferrite - Shunt Harness - Ancillary Bay - HV Battery (Structural Pack) (Retrofit)
        • Fuse - Ancillary Bay (Remove and Replace)
        • Fuse - Heat Pump - HV Battery (Structural Pack) (Remove and Replace)
        • Guide - Probing - HV Battery (Remove and Replace)
        • Guide - Probing - HV Battery (Retrofit)
        • Harness - AC Filter - HV Battery (Non-Structural Pack) (Remove and Replace)
        • Harness - AC Filter - HV Battery (Structural Pack) (Remove and Replace)
        • Harness - AC Filter - HV Battery (3-Phase) (Structural Pack) (Remove and Replace)
        • Harness - Ancillary Bay - HV Battery (Non-Structural Pack) (Remove and Replace)
        • Harness - Ancillary Bay - HV Battery (Structural Pack) (Remove and Replace)
        • Hinge Tray - Controller - High Voltage (Remove and Replace)
        • HV Battery Contactor Seize Check
        • HV Harness - Heat Pump - HV Battery (Structural Pack) (Remove and Replace)
        • HV Header Doubler - DC Input - HV Battery (Structural Pack) (Remove and Replace)
        • HV Header - Rear Drive Unit - HV Battery (Remove and Replace)
        • Insulator - Shunt - HV Battery (Remove and Replace)
        • Insulators - HV Battery (Install and Remove)
        • Passthrough - DCDC - 12V (Busbar Type) (Remove and Replace)
        • Passthrough - DCDC - 12V (Cable Type) (Remove and Replace)
        • Power Conversion System (Non-Structural Pack) (Remove and Install)
        • Power Conversion System (Non-Structural Pack) (Remove and Replace)
        • Power Conversion System (Structural Pack) (Remove and Replace)
        • Pyrotechnic Battery Disconnect (Remove and Replace)
        • Pyrotechnic Battery Disconnect (Structural Pack) (Remove and Install)
        • Pyrotechnic Battery Disconnect (Structural Pack) (Remove and Replace)
        • Resistance Meter (Zero Adjust)
        • Seal - Probe Lid - HV Battery (Remove and Replace)
        • Shunt - HV Battery (Non-Structural Pack) (Remove and Replace)
        • Shunt - HV Battery (Structural Pack) (Remove and Replace)
        • Support Hinge - Controller - High Voltage (Remove and Replace)
        • Switch - Pack Contactors - Ancillary Bay - HV Battery (Remove and Replace)
      • HV Battery Replacement - Add-On Procedures
        • Center Underbody (Rework) (Battery Removed)
        • Controller - High Voltage (Rework) (Battery On Table)
        • Cover - Ancillary Bay (Rework) (Battery On Table)
        • Cover - Ancillary Bay (Swap) (Battery On Table)
        • HV Battery (Non-Structural Pack) (1-Phase to 3-Phase) (Retrofit) (Battery On Table)
        • Pyrotechnic Battery Disconnect (Remove and Install) (Battery On Table)
    • 17 - Electrical
      • Torque Specifications - Electrical
      • 1701 - 12V Battery and Fuses
        • 12V/LV Power (Disconnect and Connect)
        • 12V/LV Battery (Remove and Replace)
        • Fuse - Positive - 12V Battery (Remove and Replace)
        • Fuse Holder - Positive Terminal - 12V Battery (Remove and Replace)
        • LV Battery - Recover (Restore)
        • LV Maintainer (Connect and Disconnect)
        • Strap - 12V Battery (Remove and Replace)
        • Vehicle HV Disablement Procedure
        • Vehicle HV Disablement Procedure (7-Seater)
        • Vehicle HV Disablement Procedure (Structural Pack)
      • 1710 - Harnesses
        • Wiring Harness Repair
        • Busbar - DCDC Ground (Remove and Replace)
        • Elastic Strap - Harness - 2nd Row Seat - Center (Remove and Replace)
        • Coax Cable - Side Repeater - Front - LH (Overlay) (Remove and Replace)
        • Coax Cable - Side Repeater - Front - LH and RH (Overlay) (Remove and Replace)
        • Coax Cable - Side Repeater - Front - RH (Overlay) (Remove and Replace)
        • Connector - Pedestrian Warning Speaker (CN) (Remove and Replace)
        • Harness - 12V Battery Ground (Remove and Replace)
        • Harness - 2nd Row Seat - LH (Remove and Replace)
        • Harness - 2nd Row Seat - RH (Remove and Replace)
        • Harness - Backrest - 2nd Row Seat - Center (Remove and Replace)
        • Harness - Backrest - 2nd Row Seat - RH (7-Seat) (Remove and Replace)
        • Harness - Body - LH (LHD) (7-Seat) (Remove and Replace)
        • Harness - Body - LH (LHD) (Remove and Replace)
        • Harness - Body - RH (Remove and Replace)
        • Harness - Cushion - 2nd Row Seat - LH (7-Seat) (Remove and Replace)
        • Harness - Door - Front - LH (Remove and Replace)
        • Harness - Door - Rear - LH (Remove and Replace)
        • Harness - Fascia - Front (Remove and Replace)
        • Harness - Fascia - Rear (Remove and Replace)
        • Harness - Frame - Seat Back - 3rd Row (Remove and Replace)
        • Harness - Front End Module (Remove and Replace)
        • Harness - Heat Pad - Seat Cushion - 2nd Row (Remove and Replace)
        • Harness - HVAC Assembly (Remove and Replace)
        • Harness - Instrument Panel (Remove and Replace)
        • Harness - Jumper for Ethernet - Car Computer (AP4) (Remove and Replace)
        • Harness - Main Front (Non-Structural Pack) (RHD) (Remove and Replace)
        • Harness - Main Front (Non-Structural Pack) (LHD) (Remove and Replace)
        • Harness - Main Front (Structural Pack) (Remove and Replace)
        • Harness - Seat Cushion - 3rd Row (Remove and Replace)
        • Harness - Seat - Driver (Remove and Replace)
        • Harness - Seat - Front Passenger (Remove and Replace)
        • Harness - Steering Wheel (Remove and Replace)
        • Harness - Front Subframe (Remove and Replace)
        • Harness - Subframe - Rear (Remove and Replace)
        • Harness - Thermal Beam (Remove and Replace)
        • Harness - Liftgate (Remove and Replace)
        • Harness - USB - Car Computer to Glove Box (12V) (Remove and Replace)
        • Harness - USB - Car Computer to Glove Box (16V) (Remove and Replace)
        • Harness - USB -Car Computer to Glove Box - NA (Remove and Replace)
        • Harness - Windshield (Remove and Replace)
        • Jumper Harness - Trailer Hitch (Remove and Replace)
        • Jumper Harness - Windshield (Retrofit)
      • 1715 - Electronic Control Modules
        • Module - Body Controller - Front (Remove and Replace)
        • Module - Body Controller - LH (Remove and Replace)
        • Module - Body Controller - RH (Remove and Replace)
        • Module - HomeLink Transmitter (Remove and Replace)
        • Steering Controller (Remove and Replace)
      • 1720 - Radar Sensor
        • Bracket - Radar - Front (Remove and Replace)
        • Sensor - Radar - Front (Calibration)
        • Sensor - Radar - Front (Remove and Replace)
        • Radar - Cabin (Remove and Replace)
        • Heater - Radar - Front (Remove and Replace)
      • 1723 - Front Cameras
        • Camera - Bi - Forward Facing (Remove and Replace)
        • Camera - B-Pillar - LH (AP4) (Remove & Replace)
        • Camera - Forward Facing (Pitch Verification)
        • Camera - Triple - Forward Facing (Remove and Replace)
        • Side Repeater Camera - Front - LH (HW4) (Remove and Replace)
        • Fan - Camera - Forward Facing (Remove & Replace)
      • 1724 - Interior Camera
        • Camera - Interior (Remove and Replace)
      • 1725 - Rear Cameras
        • Camera - Rear Facing (Remove and Replace)
      • 1727 - Parking Sensors
        • Retainer - Sensor - Parking Distance (Remove and Replace)
        • Sensor - Parking Distance - Inner - Front (Remove and Replace)
        • Sensor - Parking Distance - Outer - Front (Remove and Replace)
        • Sensor - Parking Distance - Inner - Rear (Remove and Replace)
        • Sensor - Parking Distance - Outer - Rear (Remove and Replace)
      • 1730 - Interior Switches
        • Power Socket 12V - Center Console (Remove and Replace)
        • Power Socket 12V - Rear Trunk (Remove and Replace)
        • Switch - Steering Wheel - LH (Remove and Replace)
      • 1735 - Interior Lighting
        • Ambient Light Module - Front Door Trim - LH (Remove and Replace)
        • Puddle Light - Front Door - LH (Remove and Replace)
        • Puddle Light - Rear Door - LH (Remove and Replace)
        • Task Light - Footwell Cover - LH (Remove and Replace)
      • 1740 - Exterior Lights
        • Bracket - Headlight - LH (Remove and Replace)
        • Coax Cable - Side Repeater - Front - LH and RH (Overlay) (Remove and Replace)
        • ECU - Headlight - LH (Remove and Replace)
        • Headlamps (SAE-to-Global) - Headlamp Assembly - Pair (Retrofit)
        • Headlights - Adjust - Global (Wall Method)
        • Headlights - Adjust - Global (Tool Method)
        • Headlights - Global - Adjust (EMEA with LET Tool)
        • Headlights - Adjust - NA (Tool Method)
        • Headlights - Adjust - NA (Wall Method)
        • Headlights (Check Aiming) (Inspection)
        • Headlights and Fog Lights (Check Aiming using Beisbarth Tool) (Inspection)
        • Headlights and Fog Lights (Check Aiming using LET Tool) (Inspection)
        • Headlight - LH (Remove and Install)
        • Headlight - LH (Remove and Replace)
        • Headlight - LH (Remove and Replace) (RHD)
        • Headlight - Pair - (Remove and Replace)
        • Light - Brake - Center High Mounted (Remove and Replace)
        • Light - Fog - Front (Adjust)
        • Lights - Fog - Front - Adjust (EMEA with LET Tool)
        • Light - Fog / Reverse - Rear - LH (Remove and Install)
        • Light - Fog / Reverse - Rear - LH (Remove and Replace)
        • Light - License Plate (Remove and Replace)
        • Light - Side Repeater - Front - LH (Remove and Replace)
        • Light - Turn Signal / Fog - Front - LH (Remove and Replace)
        • Reflex Lens - Rear - RH (Remove and Replace)
        • Reflector - Fascia - Rear - LH (Install)
        • Reflector - Fascia - Rear - LH (Remove and Replace)
        • Taillight - LH (Remove and Install)
        • Taillight - LH (Remove and Replace)
        • Trim - Light - Side Repeater - Front - LH (Remove and Replace)
      • 1745 - Keyless Entry and Security
        • Antenna - Bluetooth Passive Entry - Rear (Remove and Replace)
        • Module - Body Controller - Security (Remove and Replace)
        • Module - Body Controller - Security (2nd Generation) (Remove and Replace)
        • Siren - Battery Backed (Remove and Replace)
        • Additional Key - Program (Existing Key Present)
        • Replacement Keys - Program (No Keys Present)
      • 1750 - Wipers and Washers
        • Reservoir - Windshield Washer (Remove and Replace)
        • Wiper Module (Remove and Replace)
        • Wiper Module (RHD) (Remove and Replace)
        • Wiper Arm - RH (Remove and Replace)
        • Wiper Arm - RH (RHD) (Remove and Replace)
        • Wiper Arms (Remove and Replace)
        • Wiper Blades (Adjust)
        • Wiper Blades (Remove and Replace)
        • Wiper Blades (Remove and Replace) (Pair) (RHD)
        • System - Windshield Washer (Remove and Replace)
        • Sensor - Level - Windshield Washer (Remove and Replace)
        • Pump - Windshield Washer (Remove and Replace)
        • Hose - Washer - Reservoir (LHD) (Remove and Replace)
        • Hose - Washer - Reservoir (RHD) (Remove and Replace)
        • Filler Neck - Reservoir - Windshield Washer (LHD) (Remove and Replace)
        • O-ring - Filler Neck - Reservoir - Windshield Washer (LHD) (Remove and Replace)
        • Cap - Reservoir - Windshield Washer (Remove and Replace)
        • Washer Nozzles (Adjust)
      • 1753 - Horns
        • Horn - High Tone (Remove and Replace)(LV Battery)
        • Horn - Low Tone (Remove and Replace)
        • Horn Assembly (Remove and Replace)
      • 1754 - Pedestrian Warning Speaker
        • Speaker - Pedestrian Warning (Remove and Replace)
        • Speaker - Pedestrian Warning (Retrofit)
      • 1755 - Accelerator Pedal
        • Accelerator (Remove and Replace)
    • 18 - Thermal Management
      • Torque Specifications - Thermal Management
      • 1810 - Cabin HVAC
        • Actuator - Bleed - LH (Remove and Replace)
        • Actuator - Intake (Remove and Replace)
        • Actuator - Lower Mode (Remove and Replace)
        • Actuator - Upper Mode (Remove and Replace)
        • Adapter - Bleeder Duct - Instrument Panel (Remove and Replace)
        • Air Extractor - LH (Remove and Replace)
        • Assembly - Filter - HEPA (Remove and Install)
        • Assembly - Filter - HEPA (Remove and Replace)
        • Blower Motor - HVAC (Remove and Replace)
        • Clean the Blower Motor
        • Cover - Filter - HEPA (Remove and Replace)
        • Duct - Air Wave - LH (Remove and Replace)
        • Duct - Air Wave - RH (Remove and Replace)
        • Duct - Floor - 2nd Row - Main (Non-Structural Pack) (Remove and Replace)
        • Duct - Floor - 2nd Row - Main (Structural Pack) (Remove and Replace)
        • Duct - Floor - 2nd Row - RH (Non-Structural Pack) (Remove and Replace)
        • Duct - Floor - 2nd Row - RH (Structural Pack) (Remove and Replace)
        • Duct - Footwell - LH (Remove and Replace)
        • Duct - Footwell - RH (Remove and Replace)
        • Duct - Fresh Intake (Remove and Replace)
        • Duct - HEPA (Remove and Replace)
        • Filter - Cabin (Remove and Replace)
        • Filters – Carbon and HEPA (Remove and Replace)
        • Housing - Filter - HEPA (Remove and Replace)
        • HVAC Assembly (Remove and Replace)
        • Sensor - Ambient Air Temperature (Remove and Replace)
        • Sensor - Cabin Temperature (Remove and Replace)
        • Thermistor - Airwave Duct - LH (Remove and Replace)
        • Thermistor - Airwave Duct - RH (Remove and Replace)
        • Thermistor - Duct - Lower - LH (Remove and Replace)
        • Thermistor - Duct - Upper - LH (Remove and Replace)
        • Thermistor - Duct - Lower - RH (Remove and Replace)
        • Thermistor - Duct - Upper - RH (Remove and Replace)
        • Thermistor - Evaporator (Remove and Replace)
        • Vehicle Sanitation - Evaporator - Tunap 994 (EMEA)
      • 1820 - Refrigerant System
        • A/C Compressor and Supermanifold (Remove and Replace)
        • A/C Compressor, Supermanifold and Compressor to Supermanifold A/C Line (Remove and Replace)
        • A/C Line - Supermanifold to Compressor (Remove and Replace)
        • A/C Line - Supermanifold to HVAC (Remove and Replace)
        • Use Evaporator Foam Cleaner, Replace Cabin Filters
        • A/C Refrigerant (Recovery and Recharge)
        • A/C Refrigerant (Unknown Oil Quantity or System Flush)
        • Acoustic Blanket - Compressor (Retrofit)
        • Bracket - Ancillary Connector Dash Mount (Remove and Replace)
        • Bracket - Compressor (Remove and Replace)
        • Compressor (Remove and Replace)
        • Desiccant (Remove and Replace)
        • Desiccant (Add-On) (Remove and Replace)
        • Fan- Radiator (Remove and Replace)
        • Module - Cooling Fan (Remove and Install)
        • Module - Cooling Fan (Remove and Replace)
        • Sensor - Pressure and Temperature (PT) - Low Pressure (Remove and Replace)
        • Stone Guard (Remove and Replace)
      • 1830 - Cooling System
        • Clean Radiator
        • Clean Radiator (Pressure Washer Kit) (Maintenance)
        • Remove and Clean Radiator (Maintenance)
        • Coolant Pump - HV Battery (RWD) (Remove and Replace)
        • Coolant Pump - HV Battery (Dual Motor) (Remove and Replace)
        • Coolant Pump - Powertrain (Remove and Replace)
        • Cooling System (Check and Fill)
        • Cooling System (Non-Structural Pack) (Drain and Refill)
        • Cooling System (Structural Pack) (Drain and Refill)
        • Cooling System (Partial Refill and Bleed)
        • Cooling System (Vacuum Refill)
        • Hose - Chiller to HV Battery (LHD) (Dual Motor) (Remove and Replace)
        • Hose - Chiller to HV Battery (RWD) (Remove and Replace)
        • Hose - Chiller to HV Battery (RHD) (RWD) (Remove and Replace)
        • Hose - Chiller to HV Battery (Structural Pack) (Remove and Replace)
        • Hose - Front Drive Unit Powertrain Bypass (RWD) (Remove and Replace)
        • Hose - Front Manifold - LH (Remove and Replace)
        • Hose - Front Manifold - RH (Remove and Replace)
        • Hose - Inlet - Inverter - Rear Drive Unit (4DU) (Remove and Replace)
        • Hose - Inlet - Inverter - Rear Drive Unit (3DU) (Remove and Replace)
        • Hose - Inverter Inlet - Front Drive Unit (Non-Heat Pump) (Remove and Replace)
        • Hose - Inlet - Radiator (Remove and Replace)
        • Hose - Inverter Inlet - Front Drive Unit (Remove and Replace)
        • Hose - Inverter to Heat Exchanger - Rear Drive Unit (3DU) (Remove and Replace)
        • Hose - Inverter to Heat Exchanger - Rear Drive Unit (4DU) (Remove and Replace)
        • Hose - Outlet - Radiator (Remove and Replace)
        • Hose - Outlet - Rear Drive Unit (4DU) (Remove and Replace)
        • Hose - Outlet - Rear Drive Unit (3DU) (Remove and Replace)
        • Hose - Passthrough - Front Manifold - HV Battery (Male Coupler) (Retrofit)
        • Hose - Powertrain Supply - Supermanifold (Remove and Replace)
        • Hose - Return - HV Battery (Remove and Replace)
        • Hose - Return - HV Battery (RWD) (Remove and Replace)
        • Hose - Return - HV Battery - Front (Remove and Replace)
        • Hose - Return - Powertrain (Non-Structural Pack) (Remove and Replace)
        • Hose - Return - Powertrain (Structural Pack) (Remove and Replace)
        • Hose - Return - Powertrain - Front Drive Unit (Remove and Replace)
        • Hose - Supply - Powertrain (Non-Structural Pack) (Remove and Replace)
        • Hose - Supply - Powertrain (Structural Pack) (Remove and Replace)
        • Powertrain Coolant (Drain and Refill)
        • Radiator (Remove and Replace)
        • Tube - Jumper - Front Manifold - LH (Structural Pack) (Remove and Replace)
      • 1840 - Supermanifold
        • Check Valve - Cabin Condenser (Remove and Replace)
        • Check Valves - Supermanifold (Remove and Replace)
        • Chiller (Remove and Replace)
        • Coil - Recirculation Expansion Valve (Remove and Replace)
        • Coolant Bottle (Remove and Replace)
        • Liquid Cooled Condenser (Remove and Replace)
        • Octovalve (Remove and Replace)
        • Sensor - Pressure and Temperature (PT) - High Pressure (Remove and Replace)
        • Sensor - Pressure and Temperature (PT) - Low Pressure (Remove and Replace)
        • Sensor - Subcool - Pressure and Temperature (PT) - High Pressure (Remove and Replace)
        • Shut Off Valve - Liquid Cooled Condenser (Remove and Replace)
        • Supermanifold (Remove and Replace)
        • Valve Body - EXV - Supermanifold (Remove and Replace)
      • 1850 - Air Distribution
        • Active Grille Shutter (Remove and Replace)
    • 20 - Safety and Restraint
      • Airbag and Supplementary Restraint System (SRS) Precautions
      • Torque Specifications - Safety and Restraint
      • 2001 - Airbags
        • Airbag - Curtain - LH (Remove and Replace)
        • Airbag - Driver (Remove and Replace)
        • Airbag - Front Passenger (Remove and Install)
        • Airbag - Front Passenger (Remove and Replace)
        • Airbag - Knee - Driver (Remove and Install)
        • Airbag - Knee - Driver (Remove and Replace)
        • Airbag - Knee - Front Passenger (Remove and Replace)
        • Harness - Airbag - Driver (Remove and Replace)
        • Module - Restraint Control (Non-Structural Pack) (Remove and Install)
        • Module - Restraint Control (Non-Structural Pack) (Remove and Replace)
        • Module - Restraint Control (Structural Pack) (Remove and Install)
        • Module - Restraint Control (Structural Pack) (Remove and Replace)
        • Remove the Front Seat Airbag and Discard
      • 2005 - Seatbelts
        • Adjustable Top Loop (Remove and Replace)
        • Box Clip - Seat Belt Reminder - 1st Row - LH (Remove and Replace)
        • Buckle - 1st Row - LH (Remove and Replace)
        • Buckle - 2nd Row - Center (5 Seat) (Remove and Replace)
        • Buckle - 2nd Row - Center (7 Seat) (Remove and Replace)
        • Buckle - 2nd Row - LH (5 Seat) (Remove and Replace)
        • Buckle - 2nd Row - LH (7 Seat) (Remove and Replace)
        • Buckle - 2nd Row - RH (5 Seat) (Remove & Replace)
        • Buckle - 3rd Row - LH (Remove and Replace)
        • Escutcheon - 2nd Row - LH (Remove and Replace)
        • Escutcheon - Seat Belt - 3rd Row - LH (Remove and Replace)
        • Retractor - Seatbelt - 1st Row - LH (Remove and Replace)
        • Retractor - Seatbelt - 3rd Row - LH (Remove and Replace)
        • Seatbelt - 2nd Row - Center (5 Seat) (Remove and Replace)
        • Seatbelt - 2nd Row - Center (7 Seat) (Remove and Replace)
        • Seatbelt - 2nd Row - LH (5 Seat) (Remove and Replace)
        • Seatbelt - 2nd Row - LH (7 Seat) (Remove and Replace)
        • Sensor - Resistive Occupancy - 2nd Row Seat - LH (Remove and Replace)
        • Webbing Guide Bar - Seatbelt - 1st Row - LH (Remove and Replace)
      • 2010 - Pretensioners
        • Pretensioner - Outboard Lap - 1st Row - LH (Remove and Replace)
      • 2020 - Sensors
        • Sensor - Impact Accelerometer - B-Pillar - LH (Remove and Replace)
        • Sensor - Impact Accelerometer - Front Bumper - LH (Remove and Replace)
        • Sensor - Pressure - Door - Front - LH (Remove and Replace)
        • Sensor - Pressure - Door - Rear - LH (Remove and Replace)
        • Sensor - Resistive Occupancy - Front Seat - LH (Remove and Replace)
        • Sensor - Resistive Occupancy - Front Seat - RH (Remove and Replace)
        • Sensor - Shotgun Accelerometer - LH (Remove and Replace)
    • 21 - Infotainment
      • Torque Specifications - Infotainment
      • 2105 - Touchscreen
        • Service Panel - Instrument Panel (Remove and Replace)
        • Touchscreen (Remove and Replace)
      • 2115 - Car Computer
        • Car Computer (Dispose)
        • Car Computer (Remove and Replace)
        • Car Computer (Info-Ryzen) (Remove and Install)
        • Car Computer (HW4) (Remove and Install)
        • Connectivity Board - Car Computer (HW3) (Remove and Replace)
        • Connectivity Board - Car Computer (Info-Ryzen) (Remove and Replace)
        • Drip Guard - Car Computer (HW4) (Remove and Replace)
        • SD Card - Car Computer (Remove and Replace)
        • SIM Card - Car Computer (Info-Ryzen) (Retrofit)
        • SIM Card - Car Computer (Remove and Replace)
        • USB Drive (Dispose)
      • 2121 - Audio System - Speakers Subwoofer Amplifier
        • Amplifier - Audio - External (Remove and Replace)
        • Speaker - Dash - Center (Remove and Replace)
        • Speaker - Dash - LH (Remove and Replace)
        • Speaker - Front Door - LH (Remove and Replace)
        • Speaker - Headliner - LH (Remove and Replace)
        • Speaker - Liftgate - LH (Remove and Replace)
        • Speaker - Rear Door - LH (Remove and Replace)
        • Subwoofer (Remove and Replace)
        • Tweeter Assembly - Front Door - LH (with Tether) (Remove and Replace)
        • Tweeter - Dash (Remove and Replace)
        • Tweeter - Front Door - LH (Remove and Replace)
        • Tweeter - Front Door - LH (with Tether) (Remove and Replace)
      • 2123 - Audio System - AM, FM and HD Radio
        • Tuner - FM / HD / DAB (Remove and Replace)
      • 2126 - Audio System - USB Media Port
        • USB Cable - Center Console (Remove and Replace)
        • USB Hub - Center Console - Front (Remove and Replace)
        • USB Hub - Center Console - Front (2.0) (Remove and Replace)
        • USB Hub - Center Console - Rear (Remove and Replace)
      • 2130 - Antenna - FM HD Radio
        • Antenna - Ground Noise Filter - LH (Remove and Replace)
        • Antenna Amplifier - FM2 (Remove and Replace)
        • Noise Filter - 12V - Antenna (Remove and Replace)
      • 2132 - Antenna - GPS
        • Antenna - GPS/GNSS (Remove and Replace)
      • 2133 - Antenna - Wi-Fi
        • Antenna - MIMO (Remove and Replace)
    • 30 - Chassis
      • Torque Specifications - Chassis
      • 3001 - Chassis and Subframes
        • Insert - Subframe - Rear (Remove and Replace)
        • Isolator - Motor Mount - Front - LH (Remove and Replace)
        • Isolator - Motor Mount - Front - RH (Remove and Replace)
        • Shear Plate - Rear Subframe - Front - LH (Remove and Replace)
        • Subframe Assembly - Front (Dual Motor) (Remove and Install)
        • Subframe Assembly - Front (Dual Motor) (Remove and Replace)
        • Subframe Assembly - Front (RWD) (Remove and Install)
        • Subframe Assembly - Front (RWD) (Remove and Replace)
        • Subframe Assembly - Rear (Remove and Install)
        • Subframe Assembly - Rear (Remove and Replace)
    • 31 - Suspension
      • Alignment Requirement - Suspension
      • Replacing Additional Suspension Components (Access Already Performed)
      • Torque Specifications - Suspension
      • 3100 - Adjustment
        • EPAS Alignment Check
        • Four Wheel Alignment Check
        • Four Wheel Alignment Check and Adjust
      • 3101 - Front Suspension (Including Hubs)
        • Bushing Bracket - Stabilizer Bar - Front - Set (Remove and Replace)
        • Bushing Bracket - Stabilizer Bar - Front - LH (Remove and Replace)
        • Front Upper Control Arm (FUCA) Mount - LH (Remove and Replace)
        • Control Arm - Upper - Front - LH (Non-Structural Pack) (Remove and Replace)
        • Control Arm - Upper - Front - LH (Structural Pack) (Remove and Replace)
        • Hub - Front - LH (Dual Motor) (Remove and Replace)
        • Hub - Front - LH (RWD) (Remove and Replace)
        • Knuckle - Suspension - Front - LH (Dual Motor) (Remove and Replace)
        • Knuckle - Suspension - Front - LH (RWD) (Remove and Replace)
        • Link - Compliance - Lower - Front - LH (Remove and Replace)
        • Links - Compliance - Lower - Front - Pair (Remove and Replace)
        • Link - Lateral - Lower - Front - LH (Remove and Replace)
        • Link - Stabilizer Bar - Front - LH (Remove and Replace)
        • Links - Lateral - Lower - Front - Pair (Remove & Replace)
        • Stabilizer Bar - Front (Remove and Replace)
        • Suspension - Front (Check Torque)
      • 3103 - Rear Suspension (Including Hubs)
        • Ball Joint - Rear - Upper - Rear Knuckle - LH (Remove and Replace)
        • Cover - Rear Suspension - LH (Remove and Replace)
        • Drop Link - Stabilizer Bar - Rear - LH (Remove and Replace)
        • Hub - Rear - LH (Remove and Replace)
        • Isolator - Lower Spring - Rear - LH (Remove and Replace)
        • Isolator - Upper Spring - Rear - LH (Remove and Replace)
        • Knuckle - Suspension - Rear - LH (Remove and Replace)
        • Ball Joint - Knuckle - Rear Upper - LH (Inspect) (Test/Adjust)
        • Link - Aft - Lower - Rear - LH (Remove and Replace)
        • Link - Aft - Upper - Rear - LH (Remove and Replace)
        • Link - Fore - Lower - Rear - LH (Remove and Replace)
        • Link - Fore - Upper - Rear - LH (Remove and Replace)
        • Stabilizer Bar - Rear (Remove and Replace)
        • Suspension - Rear (Check Torque)
        • Toe Link - Rear - LH (Remove and Replace)
      • 3115 - Coil Suspension System
        • Damper Assembly - Front - LH (Dual Motor) (Remove and Replace)
        • Damper Assembly - Front - LH (RWD) (Remove and Replace)
        • Damper Assembly - Front - Pair (RWD) (Remove and Replace)
        • Damper - Rear - LH (Remove and Replace)
        • Isolator - Front Upper Control Arm (FUCA) Mount - LH (Remove and Replace)
        • Spring - Rear Suspension - LH (Remove and Replace)
    • 32 - Steering
      • Torque Specifications - Steering
      • 3201 - Steering Rack and Lower Column
        • Module - Steering Column Control (Remove and Replace)
        • Steering Rack (Remove and Replace)
        • Tie Rod End - LH (Remove and Replace)
        • Tie Rod - Inner - LH (Remove and Replace)
      • 3205 - Upper Column, Steering Wheel
        • Bolt - Steering Wheel to Upper Column (Remove and Replace)
        • Grub Screws - Upper Steering Column (Inspect)
        • Grub Screws - Upper Steering Column (Rework)
        • Horn - Steering Wheel (Remove and Replace)
        • Rim - Steering Wheel (Remove and Replace)
        • Shroud - Lower - Steering Column (Remove and Replace)
        • Spoke Cover - Steering Wheel - Lower (Remove and Replace)
        • Steering Column (Pre September 20, 2021) (Remove and Replace)
        • Steering Column (LHD) (Post September 20, 2021) (Remove and Replace)
        • Steering Column (RHD) (Remove and Replace)
        • Steering Wheel (Remove and Install)
        • Steering Wheel (Remove and Replace)
        • Surround - Steering Wheel (Remove and Replace)
    • 33 - Brakes
      • Torque Specifications - Brakes
      • 3301 - Brake Discs and Calipers
        • Boot Kit - Brake Caliper - Front (Remove and Replace)
        • Boot Kit - Brake Caliper - Rear (Remove and Replace)
        • Bracket - Brake Caliper - Rear - LH (Remove and Replace)
        • Brake Pad Kit - Front - Hitachi (Remove and Replace)
        • Brake Caliper - Front - LH (Remove and Replace)
        • Brake Caliper - Rear - LH (Remove and Replace)
        • Brake Caliper - Rear - Pair (Remove and Replace)
        • Brake Pads - Burnishing
        • Brake Pad Kit - Front (Remove and Replace)
        • Brake Pad Kit - Rear (Base Brakes) (Remove and Replace)
        • Brake Pad Kit - Rear (Sport Brakes) (Remove and Replace)
        • Brake Rotor - Front - LH (Measure Runout)
        • Brake Rotor - Front - LH (Remove and Replace)
        • Brake Rotor - Rear - LH (Measure Runout)
        • Brake Rotor - Rear - LH (Remove and Replace)
        • Clean and Lubricate Brake Calipers (Non-Performance Brakes)
        • Clean and Lubricate Brake Calipers - Set - Wheels Removed (Hitachi Front Brakes) (Maintenance)
        • Clean and Lubricate Brake Calipers (Performance Brakes)
        • Corroded Brake Pad Retention Pins - LH - Extract
        • Corroded Brake Pad Retention Pins - LH & RH - Extract
        • EPB Harness - Rear - LH (Remove and Replace)
        • NVH Tape - Brake Pads - Front (EMEA) (Retrofit)
        • Shield - Dust - Brake - Front - LH (Dual Motor) (Remove and Replace)
        • Shield - Dust - Brake - Front - LH (RWD) (Remove and Replace)
        • Shield - Dust - Brake - Rear - LH (Remove and Replace)
      • 3303 - Brake Pipes and Hoses
        • Brake Fluid Bleed - One Caliper
        • Brake Fluid Bleed/Flush
        • Brake Fluid Check
        • Brake Hose - Flexible - Front - LH (Remove and Replace)
        • Brake Hose - Flexible - Rear - LH (Remove and Replace)
        • Brake Lines - 2 Tube Bundle - Rear (Remove and Replace)
        • Brake Lines - Front Bundle (Remove and Replace)
        • Brake Lines - Front Bundle (Structural Pack) (Remove and Replace)
        • Brake Lines - LH Sill (RWD) (Remove and Replace)
        • Brake Lines - LH Sill (Structural Pack) (Remove and Replace)
        • Brake Lines - Master Cylinder to ABS (Non-Structural Pack) LHD) (Remove and Replace)
        • Brake Lines - Master Cylinder to ABS (Structural Pack) (LHD) (Remove and Replace)
        • Brake Lines - Master Cylinder to ABS (Non-Structural Pack) (RHD) (Remove and Replace)
        • Pipe - Brake - Rear - LH (Remove and Replace)
        • Brake Lines - Rear - RH to Sill (Non-Structural Pack) (Remove and Replace)
        • Brake Lines - Rear - RH to Sill (Structural Pack) (Remove and Replace)
      • 3305 - Parking Brake
        • Motor - Brake Caliper - Rear - LH (Remove and Replace)
        • Parking Brake - Caliper - Rear - LH (Release)
      • 3310 - ABS Traction and Stability Control
        • ABS Modulator (Remove and Replace)
        • ECU - ABS (Non-Structural Pack) (Remove and Replace)
        • ECU - ABS (Structural Pack) (Remove and Replace)
        • Hydraulic Control Unit (HCU) - Brake (Non-Structural Pack) (Remove and Replace)
        • Hydraulic Control Unit (HCU) - Brake (Structural Pack) (Remove and Replace)
        • Sensor - Wheel Speed - ABS - Front - LH (Remove and Replace)
        • Sensor - Wheel Speed - ABS - Rear - LH (Remove and Replace)
      • 3320 - Brake Booster
        • Electromechanical Brake Booster Assembly (Non-Structural Pack) (LHD) (Remove & Replace)
        • Electromechanical Brake Booster Assembly (Non-Structural Pack) (RHD) (Remove and Replace)
        • Electromechanical Brake Booster Assembly (Structural Pack) (Remove and Replace)
        • Master Cylinder and Reservoir Assembly (Remove and Replace)
        • Sensor - Brake Fluid Reservoir Level (Remove and Replace)
      • 3325 - Brake Pedal
        • Brake Pedal (Non-Structural Pack) (Remove and Replace)
        • Brake Pedal (Structural Pack) (Remove and Replace)
        • Clevis Pin - Brake (Remove and Replace)
        • Pedal Pad - Brake (Remove and Replace)
        • Switch - Brake Light (Remove and Replace)
    • 34 - Wheel and Tires
      • Torque Specifications - Wheels and Tires
      • 3401 - Wheels
        • Cap - Wheel (Remove and Replace)
        • Wheel Assembly (Remove and Install)
        • Wheel (Remove and Replace)
        • Wheels - Set (Remove and Replace)
      • 3402 - Tires
        • Replacement Tire Information
        • Tire - Front - LH (Tire Purchase)
        • Tire - Front - LH (Balance)
        • Tire - Front - LH (Road Force) (Balance)
        • Tire - Front - LH (Repair)
        • Tire Rotation
        • Tire Rotation (Mobile Only)
      • 3404 - Tire Pressure Monitoring System (TPMS)
        • BLE TPMS (Retrofit)
        • BLE TPMS (Update Configuration)
        • Sensor - TPMS (Remove and Replace)
        • TPMS (Sensor ID Drive Learn)
        • TPMS (Sensor ID Tool Learn)
    • 39 - Front Drive Unit
      • Torque Specifications - Front Drive Unit
      • 3901 - Front Drive Unit Assembly
        • Bushing – Front Drive Unit – RH (Remove and Replace)
        • Bushing - Gearbox - Front Drive Unit (Remove and Replace)
        • Drive Unit - Front (Remove and Replace)
        • Fluid Coupling (90 Degrees) - Front Drive Unit (Remove and Replace)
        • Fluid Coupling (Straight) - Front Drive Unit (Remove and Replace)
        • Ground Strap - Front Drive Unit (Remove and Replace)
        • Mount - Front Drive Unit - LH (Remove and Replace)
      • 3920 - Front Drive Inverter
        • Inverter - Front Drive Unit (Remove and Replace)
      • 3930 - Front Gearbox and Halfshafts
        • Bushing - Gearbox - Front Drive Unit (Remove and Replace)
        • Filter - Oil - Front Drive Unit (Remove and Replace)
        • Gearbox Fluid - Front Drive Unit (Drain and Refill)
        • Gearbox Fluid - Front Drive Unit (3DU) (Drain and Refill) (Machine Only)
        • Halfshaft - Front Drive Unit - LH (Remove and Replace)
        • Heat Exchanger - Front Drive Unit (Remove and Replace)
        • Oil Pump - Front Drive Unit (Remove and Replace)
        • Seal - Axle - Front Drive Unit - LH (Remove and Replace)
    • 40 - Rear Drive Unit
      • Torque Specifications - Rear Drive Unit
      • 4001 - Rear Drive Unit Assembly
        • Assembly - Bulkhead Resolver Connector - Rear Drive Unit (4DU) (Remove and Replace)
        • Bushing - Rear Drive Unit - Rear (3DU) (Remove and Replace)
        • Bushing - Rear Drive Unit - Rear (4DU) (Remove and Replace)
        • Bushing - Rear Drive Unit - RH (3DU) (Remove and Replace)
        • Bushing - Rear Drive Unit - RH (4DU) (Remove and Replace)
        • Drive Unit - Rear (3DU) (Remove and Install)
        • Drive Unit - Rear (3DU) (Remove and Replace)
        • Drive Unit - Rear (4DU) (Remove and Install)
        • Drive Unit - Rear (4DU) (Remove and Replace)
        • Drive Unit - Rear (4DU) (Update ETD)
        • Drive Unit - Rear (4DU) (Structural Pack) (Remove and Install)
        • Drive Unit - Rear (4DU) (Structural Pack) (Remove and Replace)
        • Fluid Coupling (55 Degrees) - Rear Drive Unit (Remove and Replace)
        • Ground Strap - Rear Drive Unit (Remove and Replace)
        • Mount - Rear Drive Unit - LH (3DU) (Remove and Replace)
        • Mount - Rear Drive Unit - LH (4DU) (Remove and Replace)
        • Mount and Bushings Set - Rear Drive Unit (3DU) (Remove and Replace)
        • Mount and Bushings Set - Rear Drive Unit (4DU) (Remove and Replace)
      • 4020 - Rear Drive Inverter
        • Fluid Coupling (55 Degrees) - Rear Drive Unit (Remove and Replace)
        • Fluid Coupling (Straight) - Rear Drive Unit (Remove and Replace)
        • Inverter Air Leak Test
        • Inverter - Rear Drive Unit (4DU) (Remove and Replace)
        • Inverter - Rear Drive Unit (3DU) (Remove and Replace)
      • 4030 - Rear Gearbox and Halfshafts
        • Breather - Rear Drive Unit (Remove and Replace)
        • Filter - Oil - Rear Drive Unit (Remove and Replace)
        • Gearbox Fluid - Rear Drive Unit (3DU) (Drain and Refill)
        • Gearbox Fluid - Rear Drive Unit (4DU) (Drain and Refill)
        • Gearbox Fluid - Rear Drive Unit (3DU) (Drain and Refill) (Machine Only)
        • Halfshaft - Rear Drive Unit - LH (Lubricate at Hub)
        • Halfshaft - Rear Drive Unit - LH (Remove and Replace)
        • Heat Exchanger - Rear Drive Unit (4DU) (Remove and Replace)
        • Heat Exchanger - Rear Drive Unit (3DU) (Remove and Replace)
        • Oil Pump - Rear Drive Unit (4DU) (Remove and Replace)
        • Oil Pump - Rear Drive Unit (3DU) (Remove and Replace)
        • Seal - Axle - Rear Drive Unit - LH (Remove and Replace)
    • 44 - High Voltage System
      • Torque Specifications - High Voltage System
      • 4400 - High Voltage Testing
        • Isolation/Insulation Test
        • Vehicle HV Disablement Procedure
        • Vehicle HV Disablement Procedure (Structural Pack)
        • Vehicle HV Disablement Procedure (7-Seater)
      • 4401 - Charge System Inlet
        • Bracket - Busbar - Charge Port to HV Battery (3-Phase) (Remove and Replace)
        • Busbars - Charge Port to HV Battery (Remove and Replace)
        • Busbars - Charge Port to HV Battery (CCS) (Remove and Replace)
        • Charge Port - Manual Release of Cable
        • Charge Port (GB) (Remove and Replace)
        • Charge Port (CCS) (Remove and Replace)
        • Charge Port (NACS) (Remove and Replace)
        • Charge Port Voltage Check
        • ECU - Charge Port (7-Seat) (Remove and Replace)
        • ECU - Charge Port (Combo Adapter) (Retrofit)
        • Connector - DC Input - Busbar - Charge Port to HV Battery (Remove and Replace)
        • Deadfronts - Pin - Charge Port (NA) (Damaged) (Remove and Replace)
        • Deadfronts - Pin - Charge Port (NA) (Undamaged) (Remove and Replace)
        • Door and Hinge Cover - Charge Port (Remove and Replace)
        • Door Assembly - Charge Port (China) (Remove and Replace)
        • Door Assembly - Charge Port (EMEA) (Remove and Replace)
        • Door Assembly - Charge Port (NA) (Remove and Replace)
        • ECU - Charge Port (Remove and Replace)
        • Latch Actuator - Charge Port (3 Phase) (Remove and Replace)
        • Latch Pin - AC - Charge Port (China) (Remove and Replace)
        • Latch Pin - DC - Charge Port (China) (Remove and Replace)
        • Release Cable - Charge Port (NA) (Remove and Replace)
        • Release Cable - Charge Port (3-Phase) (Remove and Replace)
        • Safety Cap - Busbar - Charge Port to HV Battery (3-Phase) (Remove and Replace)
        • Safety Cap - Busbar - Charge Port to HV Battery (Remove and Replace)
        • Sensor Target - Door - Charge Port (Remove and Replace)
      • 4450 - HV Harnesses
        • AC Cable - Charge Port to HV Battery (3-Phase) (Remove and Replace)
        • AC Cable - Charge Port to HV Battery (3-Phase) (Retrofit)
        • HV Harness - Center Ski to A/C Compressor (Remove and Replace)
        • HV Harness - Front Drive Unit (Remove and Replace)
        • HV Harness - HV Battery To A/C Compressor (Structural Pack) (Remove and Replace)
        • HV Harness - HV Battery to Front Drive Unit (Structural Pack) (Remove and Replace)
        • HV Harness - HV Battery to HVAC (AWD) (Remove and Replace)
        • HV Harness - HV Battery to Rear Drive Unit (Non-Structural Pack) (4DU) (Remove and Replace)
        • HV Harness - HV Battery to Rear Drive Unit (Structural Pack) (Remove and Replace)
        • Low Internal Isolation Diagnostics - HV System (Test)
    • 50 - External Charging Connectors
      • 5001 - Mobile Connector
        • Cleaning - Universal Mobile Connector
        • Firmware Update - Mobile Connector
        • Remove Stuck Deadfront - Charge Handle
      • 5003 - Charging Adapters
        • Firmware Update - CHAdeMO Charging Adapter
    Send Procedure Feedback
    Jump to:
    • Related links
    • © Tesla 2026

    You will be redirected to your default email client to provide feedback.

    Crowsfoot or Offset Wrench Extension Calculator

    Torque Calculator Values
    Note
    1. If the angle from the extension to the torque wrench is greater than 90° (Figure 2), input E as a positive number.
    2. If the angle from the extension to the torque wrench is less than 90° (Figure 3), input E as a negative number.
    3. If the angle from the extension to the torque wrench is exactly 90°, this calculator is not needed. Torque the fastener to T1.
    Figure 1
    Figure 2
    Figure 3