Model Y Service Manual

    17 - Electrical

    Related links

    • Torque Specifications - Electrical
    • 1701 - 12V Battery and Fuses
    • 1710 - Harnesses
    • 1715 - Electronic Control Modules
    • 1720 - Radar Sensor
    • 1723 - Front Cameras
    • 1724 - Interior Camera
    • 1725 - Rear Cameras
    • 1727 - Parking Sensors
    • 1730 - Interior Switches
    • 1735 - Interior Lighting
    • 1740 - Exterior Lights
    • 1745 - Keyless Entry and Security
    • 1750 - Wipers and Washers
    • 1753 - Horns
    • 1754 - Pedestrian Warning Speaker
    • 1755 - Accelerator Pedal
    • Model Y Service Manual
    • Release Notes
      • Current Release Notes
      • Release Notes Archive
        • Release Notes June-September 2022
        • Release Notes October-December 2022
        • Release Notes January-March 2023
        • Release Notes April-June 2023
        • Release Notes July-September 2023
        • Release Notes October-December 2023
        • Release Notes January-March 2024
        • Release Notes April-June 2024
        • Release Notes July-September 2024
    • General Information
      • Introduction
        • How to Use this Manual
        • Repairs and Replacements
        • Flat Rate Times
        • Warranty Service Regions
        • Abbreviations and Symbols
      • Best Practices
        • Airbag and Supplementary Restraint System (SRS) Component Replacement Policy
        • Airbag and Supplementary Restraint System (SRS) Precautions
        • Air Conditioning System Precautions
        • Diagnostic Connector Location
        • Electrical Precautions
        • Environmental Precautions
        • Event Data Recorder Retrieval
        • Flexible Pipes and Hoses
        • General Fitting Instructions
        • General Precautions
        • Locking Devices
        • Multimeter (LoZ Setting)
        • Oil Seals
        • Personal Protection
        • Pre-Installation Glass Inspection
        • Vehicle Cameras and Autopilot
        • Wheels and Tires
          • Wheel Disposal (Rework)
      • Charging
        • General
      • Technical Data
        • Brakes
        • Electrical
        • Fuse Locations
        • Suspension
        • Tire Pressures
        • Wheel Alignment
        • Wheels
      • Identification Numbers
        • Vehicle Identification Number (VIN)
        • Serial Numbers
        • Drive Unit Number
        • Manufacturing Certification Label
        • Vehicle and Wheel Paint Codes
        • Type Approval (EU)
      • Fluids and Capacities
    • 00 - Inspection and Service
      • 0001 - Maintenance Service
        • Maintenance Service and Intervals
      • 0002 - Firmware Service
        • Software Reinstall - Touchscreen
        • Software Reinstall - Toolbox
        • Software Update
        • User Data (Factory Reset)
      • 0005 - Service Modes
        • OBD Connector (Retrofit)
        • Gateway Configuration (Display and Change)
        • Gateway (Unlock)
        • Service Mode
        • Service Mode Plus
        • Toolbox 3 (Connect and Disconnect)
    • 10 - Body
      • Torque Specifications - Body
      • 1000 - Vehicle Lifting
        • Raise Vehicle - 2 Post Lift
        • Raise Vehicle - 4 Post Lift
        • Raise Vehicle - Floor Jack (Mobile Service)
      • 1001 - Bumper / Fascia
        • Ankle Catcher (Remove and Replace)
        • Bracket - Fascia Center To Fender - LH (Remove and Replace)
        • Bracket - Fascia Side to Fender - LH (Remove and Replace)
        • Bracket - Rear - Center (Remove and Replace)
        • Bracket - Rear Wing - LH (Remove and Replace)
        • Bracket - Taillight - LH (Remove and Replace)
        • Bumper Beam - Front (Remove and Replace)
        • Bumper Beam - Rear (Remove and Replace)
        • Cover - Tow Hook - Front (Remove and Install)
        • Cover - Tow Hook - Rear (Remove and Install)
        • Crush Can - Upper - Front - LH (Remove and Replace)
        • Crush Can - Upper - Front - LH (Structural Pack) (Remove and Replace)
        • Fascia - Front (Remove and Install)
        • Fascia - Front (Remove and Replace)
        • Fascia - Rear (Remove and Install)
        • Fascia - Rear - Lower (Remove and Replace)
        • Fascia - Rear - Upper (Remove and Replace)
        • Foam - Bumper Beam - Front (Remove and Replace)
        • Grille - Fascia - Front (Remove and Replace)
        • Upper Leg Support - Bumper Carrier - Front (Remove and Replace)
        • Valance - Front Fascia (Remove and Replace)
      • 1010 - Body Panels
        • Body Reinforcement - Floor - 2nd Row (Remove and Replace)
        • Brace - Dash Pencil (Remove and Replace
        • Brace - Shock Tower (Remove and Replace)
        • Bracket - Front End Module (FEM) - LH (Remove and Replace)
        • Carrier - Front End (Remove and Replace)
        • Carrier - Front End (Heat Pump) (Remove and Replace)
        • Crush Can - Front Subframe - LH (Remove and Replace)
        • Door - Front - LH (Remove and Install)
        • Door - Front - LH (Remove and Replace)
        • Check Strap - Door - Front - LH (Remove and Replace)
        • Check Strap - Door - Rear - LH (Remove and Replace)
        • Door - Rear - LH (Remove and Install)
        • Door - Rear - LH (Remove and Replace)
        • Fender Assembly - Front - LH (Remove and Install)
        • Fender Assembly - Front - LH (Remove and Replace)
        • Hood (Remove and Install)
        • Hood (Remove and Replace)
        • Liftgate Assembly (Remove and Install)
        • Liftgate Assembly (Remove and Replace)
        • Panel Assembly - Rear (Remove and Replace)
      • 1020 - Windshield and Body Glass
        • Clear Forward Camera View (Precision Cleaning Of Inboard Windshield)
        • Glass - Backlight (Remove and Install)
        • Glass - Backlight (Remove and Replace)
        • Glass - Body - Rear Quarter - LH (Remove and Install)
        • Glass - Body - Rear Quarter - LH (Remove and Replace)
        • Glass - Roof - Fixed (Remove and Replace)
        • Sensor - Relative Humidity and Temperature (HW3) (Remove and Install)
        • Sensor - Relative Humidity and Temperature (Remove and Replace)
        • VIN Label - Windshield (Remove and Replace)
        • Windshield and Roof Glass Repair and Replacement Guidelines
        • Windshield Chip Repair
        • Windshield Chip Repair (EMEA)
        • Windshield Scratch Repair
        • Windshield (HW4) (Remove and Replace)
        • Windshield (Non-Structural Pack) (Remove and Replace)
        • Windshield (Reuse Humidity and Temperature Sensor) (HW3) (Remove and Replace)
      • 1030 - Paint
        • Paint Defect Rectification
      • Panel Alignment
        • Fender Alignment
        • Front Door Alignment
        • Hood Alignment
        • Panel Alignment Specifications
    • 11 - Closures
      • Torque Specifications - Closures
      • 1133 - Closure Assist Mechanisms and Hinges
        • Ball Stud - Liftgate - LH (Remove and Replace)
        • Bump Stop - Liftgate - LH (Remove and Replace)
        • Gas Strut - Hood - LH (Remove and Replace)
        • Hinge - Door - Front - Lower - LH (Remove and Replace)
        • Hinge - Door - Front - Lower - LH (Structural Pack) (Rework)
        • Hinge - Door - Front - Upper - LH (Remove and Replace)
        • Hinge - Door - Rear - Lower - LH (Remove and Replace)
        • Hinge - Door - Rear - Upper - LH (Remove and Replace)
        • Hinge - Door - Rear - Upper - LH (Structural Pack) (Rework)
        • Hinge - Hood - LH (Remove and Replace)
        • Hinge - Liftgate - LH (Remove and Replace)
        • Power Strut - Liftgate (Remove and Replace)
        • Strut Assist - Liftgate (Remove and Replace)
      • 1135 - Latches Strikers and Pinch Sensors
        • Actuator - Latch - Hood (Single Actuator System) (Remove and Replace)
        • Latch - Door - Front - LH (Remove and Replace)
        • Latch - Door - Rear - LH (Remove and Replace)
        • Latch - Hood (Remove and Replace)
        • Latch - Liftgate (Remove and Replace)
        • Manual Release - Door - Rear - LH (Actuate)
        • Striker - Door - Front - LH (Remove and Replace)
        • Striker - Door - Rear - LH (Remove and Replace)
        • Striker - Hood (Remove and Replace)
        • Striker - Liftgate (Remove and Replace)
        • Switch - Exterior Release - Liftgate (Remove and Replce)
        • Switch - Closure - Liftgate (Remove and Replace)
      • 1145 - Exterior Door Handles
        • Handle - Exterior Release - Door - Front - LH (Adjust)
        • Handle - Exterior Release - Door - Front - LH (Remove and Replace)
        • Handle - Exterior Release - Door - Rear - LH (Adjust)
        • Handle - Exterior Release - Door - Rear - LH (Remove and Replace)
      • 1150 - Door Glass and Regulators
        • Glass - Door - LH - Front (Remove and Replace)
        • Glass - Door - LH - Rear (Adjust)
        • Glass - Door - LH - Rear (Remove and Replace)
        • Switch - Window - Driver (Remove and Replace)
        • Switch - Window - Driver (Remove and Replace) (RHD)
        • Switch - Window - Front Passenger (Remove and Replace)
        • Switch - Window - Rear (Remove and Replace)
        • Window Regulator Motor - Front - LH (Remove and Replace)
        • Window Regulator Motor - Rear - LH (Remove and Replace)
        • Window Regulator - Front - LH (Remove and Replace)
        • Window Motor / Regulator Assembly - Rear - LH (Remove and Replace)
        • Window Regulator (Recalibrate)
      • 1170 - Seals Body Closures
        • Closeout Panel - Door - Front - LH (Remove and Install)
        • Closeout Panel - Door - Rear - LH (Remove and Install)
        • Closeout Panel - Door - Rear - LH (Remove and Replace)
        • Seal - B-Pillar Applique - LH (Remove and Replace)
        • Seal - Body - Side - Front - Primary - LH (Remove and Replace)
        • Seal - Body - Side - Rear - Primary - LH (Remove and Replace)
        • Seal - Glass Run - Front Door - LH (Remove and Replace)
        • Seal - Header - LH (Remove and Replace)
        • Seal - Hood (Remove and Replace)
        • Seal - Inner Belt - Front Door - LH (Remove and Replace)
        • Seal - Inner Belt - Rear Door - LH (Remove and Replace)
        • Seal - Liftgate - Side - LH （Remove and Replace)
        • Seal - Outer Belt - Front Door - LH (Remove and Replace)
        • Seal - Outer Belt - Rear Door - LH (Remove and Replace)
        • Seal - Secondary - Front Door - LH (Remove and Replace)
        • Seal - Secondary - Rear Door - LH (Remove and Replace)
        • Seal - Trunk (Remove and Replace)
    • 12 - Exterior Fittings
      • Torque Specifications - Exterior Fittings
      • 1201 - Wheel Arch Liners
        • Noise Absorber - Motor Bay - Front (Remove and Replace)
        • Noise Absorber - Motor Bay - Rear (Remove and Replace)
        • Wheel Arch Liner - Front - LH (Non-Structural Pack) (Remove and Replace)
        • Wheel Arch Liner - Front - LH (Structural Pack) (Remove and Replace)
        • Wheel Arch Liner - Rear - LH (Non-Structural Pack) (Remove and Replace)
        • Wheel Arch Liner - Rear - LH (Structural Pack) (Remove and Replace)
      • 1203 - Undertray and Diffuser
        • Diffuser - Rear Fascia (Remove and Replace)
        • Panel - Aero Shield - Front (Non-Structural Pack) (Remove and Replace)
        • Panel - Aero Shield - Front (Structural Pack) (Remove and Replace)
        • Panel - Aero Shield - Mid (Remove and Replace)
      • 1205 - Badges and Films
        • Paint Protection Film - Rear Doors (Retrofit)
        • Sill Plate - Front - LH (Remove and Replace)
        • Tesla Badge - Front (Remove and Replace)
        • Tesla Badge - Rear (Remove and Replace)
        • Badge - Rear - LH (Remove and Replace) (China)
        • Vehicle Configuration Badge (Remove and Replace)
      • 1207 - License Plate Mountings
        • Bracket - License Plate - Front (EMEA) (Retrofit using Jig)
        • Bracket - License Plate - Front (Remove and Replace)
        • Bracket - License Plate - Front (Retrofit)
        • Bracket - License Plate - Rear (Retrofit)
        • Bracket - License Plate - Rear (EMEA and APAC) (Remove and Replace)
        • Bracket - License Plate - Rear (NA) (Remove and Replace)
      • 1209 - Exterior Mirrors
        • Door Mirror Assembly - LH (Remove and Install)
        • Glass - Door Mirror - LH (Remove and Replace)
        • Mirror - Door - LH (Remove and Replace)
        • Skull Cap - Door Mirror - LH (Remove and Replace)
      • 1220 - Exterior Trim
        • Applique - A-Pillar - Mirror - Door - LH (Remove and Replace)
        • Applique - B-Pillar - LH (Remove and Replace)
        • Brightwork - Upper - LH (Remove and Replace)
        • Carrier - Rocker Panel - LH (Remove and Replace)
        • Carrier - Rocker Panel - LH (Structural Pack) (Remove and Replace)
        • Cover - Applique - B-Pillar - LH (Remove and Replace)
        • Cover - Rocker Panel - Lower - LH (Remove and Replace)
        • Garnish - Fender - Rear - LH (Remove and Replace)
        • Garnish - Fender - Front - LH (Remove and Replace)
        • Mud Flaps (Retrofit)
        • Mud Flap - LH (Remove and Replace)
      • 1222 - Spoiler
        • Spoiler - Rear (Remove and Install)
        • Spoiler - Rear (Remove and Replace)
        • Spoiler - Rear (Retrofit using Jig)
      • 1225 - Underhood Trim
        • Baffle - Hood (Remove and Replace)
        • Bracket - Center - Cowl Screen (Remove and Replace)
        • Cover - Shock Tower - LH (Remove and Replace)
        • Panel - Cowl Screen (Remove and Replace)
        • Panel - Cowl Screen (Remove and Replace) (RHD)
        • Underhood Apron - Rear (Remove and Replace)
      • 1230 - Trailer Hitch
        • Assembly - Trailer Hitch (Remove and Replace)
        • Cover – Tow Hitch (Remove and Replace)
      • 1240 - Roof Rack
        • Roof Rack (Install)
    • 13 - Seats
      • Torque Specifications - Seats
      • 1301 - Front Seat Tracks and Motors
        • Button - Cushion Adjust - Driver Seat (Remove and Replace)
        • Cover - Front - Seat Track - 1st Row Seat (Remove and Replace)
        • Cover - Rear - Seat Track - 1st Row Seat (Remove and Replace)
        • Frame - Seat Cushion - Driver Seat (Remove and Replace)
        • Frame - Seat Cushion - Front Passenger Seat (Remove and Replace)
        • Module - ECU - Occupant Classification System (OCS) - Front Passenger (Remove and Replace)
        • Motor - Recliner - Backrest - Driver Seat (Remove and Replace)
        • Motor - Recliner - Back Rest - Front Passenger Seat (Remove and Replace)
        • Motor - Seat Height - Driver Seat (Remove and Replace)
        • Motor - Seat Track - Driver Seat (Remove and Replace)
        • Motor - Seat Track - Front Passenger Seat (Remove and Replace)
        • Motor - Seat Tilt - Driver Seat (Remove and Replace)
        • Plastic Insulator - Suspension - Driver Seat (Remove and Replace)
        • Podium - Seat - Driver (Remove and Replace)
        • Recline Button - Switch - Driver Seat (Remove and Replace)
        • Riser - Driver Seat - LH (Remove and Replace)
        • Sensor - Position - Track - 1st Row Seat - RH (Remove and Replace)
        • Switch - Back Rest and Cushion Adjust - Front Passenger Seat (Rework)
        • Switch - Back Rest and Cushion Adjust - Driver Seat (Remove and Replace)
        • Track - Inner - Front Passenger Seat (Remove and Replace)
        • Track - Outer - Front Passenger Seat (Remove and Replace)
      • 1302 - 2nd Row Seat Tracks and Motors
        • Actuator - Floor Latch - 2nd Row Seat - LH (7-Seat) (Remove and Replace)
        • Actuator - Floor Latch - 2nd Row Seat - RH (7-Seat) (Remove and Replace)
        • Actuator - EZ Entry - 60 Track - 2nd Row Seat (7-Seat) (Remove and Replace)
        • Actuator - EZ Entry - 40 Track - 2nd Row Seat (7-Seat) (Remove and Replace)
        • Casting - Podium - 2nd Row Seat - LH (7-Seat) (Remove and Replace)
        • Cover - Seat Track - 2nd Row Seat - Center (7-Seat) (Remove and Replace)
        • Cover - Seat Track - 2nd Row Seat - LH (7-Seat) (Remove and Replace)
        • Cover - Seat Track - 2nd Row Seat - RH (7-Seat) (Remove and Replace)
        • Podium - 2nd Row Seat - RH (7-Seat) (Remove and Replace)
        • Seat Track - Inner - 2nd Row Seat - LH (7-Seat) (Remove and Replace)
        • Seat Track - Inner - 2nd Row Seat - RH (7-Seat) (Remove and Replace)
        • Seat Track - Outer - 2nd Row Seat - LH (7-Seat) (Remove and Replace)
        • Seat Track - Outer - 2nd Row Seat - RH (7-Seat) (Remove and Replace)
        • Sensor - Position - Seat Track - 2nd Row Seat - RH (Remove and Replace)
        • Towel Bar - 2nd Row Seat - LH (7-Seat) (Remove and Replace)
      • 1304 - Front Seat Assemblies and Hardware
        • Frame - Seat Back Rest - Front Passenger's Seat (Remove and Replace)
        • Lumbar Support - Backrest - Driver Seat (Remove and Replace)
        • Lumbar Support - Back Rest - Front Passenger Seat (Remove and Replace)
        • Post Guide - Headrest - Driver Seat (Remove and Replace)
        • Post Guide - Headrest - Front Passenger Seat (Remove and Replace)
        • Shell - Seat Back - Driver (Remove and Replace)
        • Seat Assembly - 1st Row - LH (Remove and Replace)
        • Seat Assembly - 1st Row - LH (Structural Pack) (Retrofit)
        • Trim - Headrest - Driver (Remove and Replace)
      • 1305 - 2nd Row Seat Assemblies and Hardware
        • 1305 - 2nd Row Seat Assemblies and Hardware (7-Seat)
          • Adjustment Guide - Headrest - 2nd Row (Remove and Replace)
          • Armrest - 2nd Row (Remove and Replace)
          • Backrest Switch – Seat Back – 2nd Row – Center (Remove and Replace)
          • Cushion Pan - 2nd Row Seat - LH (7-Seat) (Remove and Replace)
          • Cushion Pan - 2nd Row Seat - RH (7-Seat) (Remove and Replace)
          • Headrest - 2nd Row - Center (Remove and Replace)
          • Headrest - 2nd Row - Outer - LH (Remove and Replace)
          • Lumbar Bun - 2nd Row - Center/20 (Remove and Replace)
          • Seat Assembly - 2nd Row - LH (7-Seat) (Remove and Replace)
          • Seat Assembly - 2nd Row - RH (7-Seat) (Remove and Replace)
          • Switch Box - Actuator - 2nd Row Seat - LH (7-Seat) (Remove and Replace)
          • Switch Box - Actuator - 2nd Row Seat - RH (7-Seat) (Remove and Replace)
        • 1305 - 2nd Row Seat Assemblies and Hardware (5-Seat)
          • Actuator - Recliner - 2nd Row - 20 (Remove & Replace)
          • Adjustment Guide - Headrest - 2nd Row (Remove and Replace)
          • Backrest Switch – Seat Back – 2nd Row – Center (Remove and Replace)
          • Closeout - Armrest - 2nd Row (Remove and Replace)
          • Guide Lock - Headrest - 2nd Row (Remove and Replace)
          • Headrest - 2nd Row - Center (Remove and Replace)
          • Headrest - 2nd Row - Outer - LH (Remove and Replace)
          • Latch - Seat Back - 2nd Row - Center (Remove and Replace)
          • Lumbar Bun - 2nd Row - Center/20 (Remove and Replace)
          • Pivot Clamps - Seat Back - 2nd Row - Center/20 (Remove and Replace)
          • Pivot Bushing - Seat back - 2nd Row - Center (Remove and Replace)
          • Recliner Actuator - Seat Back - 2nd Row - RH (Remove and Replace)
          • Recliner Actuator - Seat Back - 2nd Row - LH (Remove and Replace)
          • Seat Back - 2nd Row - LH (Remove and Replace)
          • Seat Back - 2nd Row - RH (Remove and Replace)
          • Seat Cushion - Lower - 2nd Row (Remove and Replace)
          • Shoulder Switch – Seat Back – 2nd Row – LH (Remove and Replace)
          • Switch - Seat Fold (Remove and Replace)
      • 1306 - 3rd Row Seat Assemblies and Hardware
        • Actuator - Recliner - 3rd Row Seat - LH (Remove and Replace)
        • Back Panel - 3rd Row Seat - LH (Remove and Replace)
        • Bolster - Seat Cushion - 3rd Row - LH (Remove and Replace)
        • Headrest - 3rd Row - LH (Remove and Replace)
        • Seat Backs - 3rd Row (Remove and Replace)
        • Cushion - Seat - 3rd Row (Remove and Replace)
        • Shoulder Switch – Seat Back – 3rd Row – LH (Remove and Replace)
        • Substrate - Seat Back - 3rd Row - LH (Remove and Replace)
        • USB Hub - Seat - 3rd Row (Remove and Replace)
      • 1307 - Front Seat Covers Pads and Trims
        • Cover - Back Rest - Driver (With Inboard Airbag) (Remove and Replace)
        • Diamond Cover - Seat Side - 1st Row - LH (Remove and Replace)
        • Diamond Cover - Seat Side - 1st Row - RH (Remove and Replace)
        • Side Shield - Outboard - Driver Seat (Remove and Replace)
        • Foam - Backrest - Driver Seat (Remove and Replace)
        • Foam - Backrest - Driver Seat (With Inboard Airbag) (Remove and Replace)
        • Foam - Cushion - Driver Seat (Remove and Replace)
        • Foam - Cushion - Front Passenger Seat (Remove and Replace)
        • Foam - Seat Back - Front Passenger Seat (Remove and Replace)
        • Side Shield - Inboard - Driver Seat (Remove and Replace)
        • Suspension - Seat Cushion - Driver Seat (Remove and Replace)
        • Trim - Cushion - Driver Seat (Remove and Replace)
        • Trim - Cushion - Front Passenger Seat (Remove and Replace)
        • Trim - Seat Back - Driver Seat (Remove and Replace)
      • 1308 - 2nd Row Seat Covers Pads and Trims
        • 1308 - 2nd Row Seat Covers Pads and Trims (5-Seat)
          • Cover - Seat Back - 2nd Row - LH (5-Seat) (Remove and Replace)
          • Cover - Seat Back - 2nd Row Seat - RH (Remove and Replace)
          • Cup Holder - 2nd Row (Remove and Replace)
          • B-Cover - Inner - 2nd Row - Center (Remove and Replace)
          • B-Cover - Inner - 2nd Row - LH (Remove and Replace)
          • B-Cover - Inner - 2nd Row - RH (Remove and Replace)
          • B-Cover - Outer - 2nd Row - LH (Remove and Replace)
          • B-Cover - Outer - 2nd Row - RH (Remove and Replace)
          • B-Cover - Outer - 2nd Row - Center (Remove and Replace)
          • Back Panel – 2nd Row Seat – Center/20 (5-Seat) (Remove and Replace)
          • Back Panel – 2nd Row Seat – LH (Remove and Replace)
          • Back Panel – 2nd Row Seat – RH (Remove and Replace)
        • 1308 - 2nd Row Seat Covers Pads and Trims (7-Seat)
          • B-Cover - 2nd Row - Inner - LH (7-Seat) (Remove and Replace)
          • B-Cover - Outer - 2nd Row - RH (7-Seat) (Remove and Replace)
          • Back Panel – 2nd Row Seat – Center/20 (7-Seat) (Remove and Replace)
          • Cover - Seat Back - 2nd Row - LH (7-Seat) (Remove and Replace)
          • Cover - Seat Back - 2nd Row - RH (7-Seat) (Remove and Replace)
          • Cover - Toe Kick - 2nd Row Seat - RH (7-Seat) (Remove and Replace)
          • Cover - Toe Kick - 2nd Row Seat - LH (7-Seat) (Remove and Replace)
          • Foam - Cushion - 2nd Row Seat - LH (7-Seat) (Remove and Replace)
          • Shell - Backrest - 2nd Row - LH (7-Seat) (Remove and Replace)
          • Side Shield Sub-Assembly - 2nd Row Seat (7-Seat) (Remove and Replace)
          • Trim - Cushion - 2nd Row Seat - LH (7-Seat) (Remove and Replace)
          • Trim - Cushion - 2nd Row Seat - RH (7-Seat) (Remove and Replace)
      • 1309 - 3rd Row Seat Covers Pads and Trims
        • B-Cover - Inner - 3rd Row - Center (Remove and Replace)
        • B-Cover - Inner - 3rd Row - LH (Remove and Replace)
        • B-Cover - Outer - 3rd Row - Center (Remove and Replace)
        • B-Cover - Outer - 3rd Row - LH (Remove and Replace)
        • Closeout - Cup Holder - Seat - 3rd Row (Remove and Replace)
        • Headrest Closeout - 3rd Row Seat - LH (Remove and Replace)
        • Cover - Seat Back - 3rd Row - LH (Remove and Replace)
        • Liner - Cup Holder - Seat - 3rd Row (Remove and Replace)
    • 14 - Instrument Panel
      • Torque Specifications - Instrument Panel
      • 1405 - Instrument Panel
        • Beam - Cross Car (Remove and Replace)
        • Cover - Footwell - Driver (Remove and Replace)
        • Cover - Footwell - Passenger (LHD) (Remove and Replace)
        • Cover - Footwell - Passenger (RHD) (Remove and Replace)
        • Decor Trim - Instrument Panel - Main (Remove and Replace)
        • Decor Trim - Instrument Panel - Main (Remove and Replace) (RHD)
        • Decor Trim - Instrument Panel - Main (Rework)
        • Defrost Cover - Instrument Panel - LH (Remove and Replace)
        • End Cap - Air Wave - LH (Remove and Replace)
        • End Cap - Instrument Panel - LH (Remove and Replace)
        • Finisher - Vent (Remove and Replace)
        • Gap Hider - Steering Column - Lower (Remove and Replace)
        • Gap Hider - Steering Column - Upper (Remove and Replace)
        • Glove Box - With Knee Airbags (Remove and Replace)
        • Glove Box - Without Knee Airbags (Remove and Replace)
        • Grille - Speaker - Instrument Panel (Remove and Replace)
        • Housing - Center Display (Remove and Replace)
        • IP Carrier (Remove and Install)
        • IP Carrier (Remove and Replace)
        • NVH Pad - Glove Box (Remove and Replace)
        • NVH Pad - Instrument Panel - Upper (Remove and Replace)
        • Vent - Front - LH (Remove and Replace)
        • Vent - Front - RH (Remove and Replace)
        • Riser - Instrument Panel (Remove and Replace)
        • Shroud - Upper - Steering Column (Remove and Replace)
    • 15 - Interior Trim
      • Torque Specifications - Interior Trim
      • 1505 - Interior Mirror and Sun Visors
        • Check Base - Sun Visor - LH (Remove and Replace)
        • Check Base - Magnetic - Sun Visor - LH (Remove and Replace)
        • Bezel - Rear View Mirror (Remove and Replace)
        • Sun Visor - LH (Remove and Replace)
        • Mirror - Rear View (Remove and Replace)
        • Hood - Triple Camera (Remove and Replace)
        • Quad Camera Cover - Lower (Remove and Replace)
        • Quad Camera Cover - Upper (Remove and Replace)
        • Quad Camera Cover - Upper (Remove and Replace) (RHD)
      • 1511 - Liftgate Trim
        • Bracket - Side Trim - Liftgate - LH (Remove and Replace)
        • Cover - Latch - Liftgate (Remove and Replace)
        • Grille - Speaker - Liftgate - LH (Remove and Replace)
        • Trim - Liftgate - Lower (Remove and Replace)
        • Trim - Upper - Liftgate (Remove and Replace)
      • 1513 - Door Trim
        • NVH Pad - Door - Front - LH (Remove and Replace)
        • NVH Pad - Door - Rear - LH (Remove and Replace)
        • Panel - Door Trim - Front - LH (Remove and Install)
        • Panel - Door Trim - Front - LH (Remove and Replace)
        • Panel - Door Trim - Rear - LH (Remove and Install)
        • Panel - Door Trim - Rear - LH (Remove and Replace)
        • Decor - Trim - Front Door - LH (Remove and Replace)
        • Reflector - Door - Front - LH (Remove and Replace)
        • Switch - Interior Door Release - Front - LH (Remove and Replace)
        • Switch - Interior Door Release - Rear - LH (Remove and Replace)
      • 1518 - Pillar and Sill Trim
        • Bezel - Seatbelt - C-Pillar - LH (Remove and Replace)
        • Bracket - C-Pillar - LH (Remove and Replace)
        • Bracket - Harness - Sill Panel - Front - LH (Remove and Replace)
        • Ramp - Airbag - B-Pillar - LH (Remove and Replace)
        • Trim - A-Pillar - Lower - LH (Remove and Replace)
        • Trim - A-Pillar - Middle - LH (Remove and Replace)
        • Trim - A-Pillar - Upper - LH (Remove and Replace)
        • Trim - B-Pillar - Lower - LH (Non-Structural Pack) (Remove and Replace)
        • Trim - B-Pillar - Lower - LH (Structural Pack) (Remove and Replace)
        • Trim - B-Pillar - Mid - LH (Structural Pack) (Remove and Replace)
        • Trim - B-Pillar - Upper - LH (Remove and Replace)
        • Trim - C-Pillar - Lower - LH (Remove and Replace)
        • Trim - C-Pillar - Lower - LH (7 Seat) (Remove and Replace)
        • Trim - C-Pillar - Upper - LH (Remove and Replace)
      • 1519 - Center Console
        • Armrest - Center Console (Remove and Replace)
        • Assembly - Rear Vent - Center Console (Remove and Replace)
        • Bright Strip - Center Console - LH (Remove and Replace)
        • Brightwork - Center Console (2.0) (Remove and Replace)
        • Center Console (Remove and Install)
        • Center Console (2.0) (Structural Pack) (Remove and Install)
        • Center Console (Remove and Replace)
        • Center Console (2.0) (Structural Pack) (Remove and Replace)
        • Cup Holder (Remove and Replace)
        • Liner - Cup Holder - Center Console (2.0) (Remove and Replace)
        • Decor Trim - Center Console - LH (Remove and Replace)
        • Decor Trim - Cup Holder - Center Console (Remove and Replace)
        • End Panel - Center Console (Remove and Replace)
        • H-Decor Trim - Center Console (2.0) (Remove and Replace)
        • Insert - Front Bin - Center Console (Remove and Replace)
        • Module - Inductive Charger - Center Console (2.0) (Remove and Replace)
        • Panel - Lower Rear - Center Console (Remove and Replace)
        • Phone Dock Bar - Center Console (Remove and Replace)
        • Phone Tray - Center Console (Remove and Replace)
        • Rail - Lower - Center Console - LH (Structural Pack) (Remove and Replace)
        • Side Panel - Center Console - LH (Remove and Replace)
        • Side Panel - Center Console - LH (RHD) (Remove and Replace)
        • Sliding Lid - Center Console (Remove and Replace)
        • Switch - Light - Center Console (Remove and Replace)
      • 1520 - Headliner
        • Coat Hook - Rear - LH (Remove and Replace)
        • Headliner - Rear (Remove and Replace)
        • Headliner - Front (Remove and Replace)
        • Headliner Assembly (Remove and Install)
        • Headliner Assembly (Remove and Replace)
        • Overhead Console - Front (Remove and Replace)
      • 1524 - Luggage Compartment Trim
        • Access Panel - Underhood Storage Unit (Remove and Replace)
        • Bracket - Trunk Load Floor - LH (Remove and Replace)
        • Bracket - Trunk Pocket - LH (Remove and Replace)
        • Folding Parcel Shelf - Rear Trunk (Remove and Replace)
        • Tie Down - Front - LH (Remove and Replace)
        • Tie Down - Rear - LH (Remove and Replace)
        • Trim - Side - Trunk - LH (Remove and Replace)
        • Trim - Sill - Trunk (Remove and Replace)
        • Trunk Assembly - Lower (Remove and Replace)
        • Trunk Load Floor - Front (Remove and Replace)
        • Trunk Load Floor - Rear (Remove and Replace)
        • Tub - Rear Trunk (Remove and Replace)
        • Underhood Storage Unit (Remove and Replace)
      • 1530 - Carpeting and Mats
        • Bracket - Rucket - LH (Remove and Replace)
        • Carpet - 2nd Row (7-Seat) (Remove and Replace)
        • Carpet - 3rd Row (Remove and Replace)
        • Carpet - Front - LH (7-Seat) (Remove and Replace)
        • Carpet - Front - LH (Remove and Replace)
        • Carpet - Front - LH (Structural Pack) (Remove and Replace)
        • Carpet - Front - RH (7-Seat) (Remove and Replace)
        • Carpet - Front - RH (Remove and Replace)
        • Carpet - Front - RH (Structural Pack) (Remove and Replace)
        • Carpet - Interior Complete (Remove and Replace)
        • Carpet - Rear (Remove and Replace)
        • Front Carpet - Rear Trunk (Remove and Replace)
        • Front Wheelhouse NVH Absorber - LH (Remove and Replace)
        • Insulator - Dash (Remove and Replace)
        • Insulator - Wheelhouse - Set (Remove & Replace)
        • Mat - Front Bin - Center Console (Remove and Replace)
        • NVH Insulator - 3rd Row Seat (Remove and Replace)
        • NVH Stuffer - Quarter Cavity - LH (Remove and Replace)
        • NVH Stuffer - Quarter Cavity - RH (Remove and Replace)
        • Support - Carpet - LH (Structural Pack) (Remove and Replace)
        • Support - Carpet - RH (Structural Pack) (Remove and Replace)
    • 16 - Battery System
      • Torque Specifications - Battery System
      • 1601 - HV Battery Assembly
        • HV Battery (AWD) (7-Seat) \(Remove and Install\)
        • HV Battery (AWD) (Non-Structural Pack) (Remove and Install)
        • HV Battery (AWD) (Non-Structural Pack) (Remove and Replace)
        • HV Battery (AWD) (Structural Pack) (Remove and Install)
        • HV Battery (AWD) (Structural Pack) (Remove and Replace)
        • HV Battery (RWD) (Remove and Install)
        • HV Battery (RWD) (Remove and Replace)
      • 1610 - HV Battery Enclosure
        • Cover - HV Probe - HV Battery (Remove and Replace)
        • Cover - Ancillary Bay (Remove and Replace)
        • Cover - Ancillary Bay (7-Seat) (Remove and Replace)
        • Cover - Ancillary Bay (Structural Pack) (Remove and Replace)
        • Cover - Ancillary Bay (Structural Pack) (3-Phase) (Remove and Replace)
        • Flood Ports - 2nd Generation (Remove and Replace)
        • Flood Port - Rear (Structural Pack) (Remove and Replace)
        • Retainer - Flood Port - LH (Remove and Replace)
        • Seal - Perimeter - HV Battery (Remove and Replace)
        • HV Battery Air Leak Test
        • HV Battery Air Leak Test (Structural Pack)
        • NVH Pads - HV Battery (Install)
        • Ancillary Bay Air Leak Test
        • Ancillary Bay Air Leak Test (Structural Pack)
        • Platter Enclosure Air Leak Test
        • Platter Enclosure Air Leak Test (Structural Pack)
        • Ski - Center Rail - HV Battery (Dual Motor) (Remove and Replace)
        • Skid Plate - HV Battery - Front (Remove and Replace)
        • Skid Plate - HV Battery - Rear (Remove and Replace)
        • Thermal Vent (Structural Pack) (Remove and Replace)
        • Vent Assembly - HV Battery - LH (Remove and Replace)
        • Wade Seal - HV Battery (Structural Pack) (Remove and Replace)
        • Wade Seal - HV Battery (Structural Pack) (Rework)
      • 1620 - HV Battery Cooling System
        • Tube - Output - Coolant - Power Conversion System (Structural Pack) (Remove and Replace)
        • Tube - Input - Coolant - Power Conversion System (Structural Pack) (Remove and Replace)
        • Ancillary Bay Coolant (Drain and Refill)
        • Ancillary Bay Coolant Leak Test
        • Platter Enclosure Coolant (Drain and Refill)
        • Platter Enclosure Coolant Leak Test
        • Tube - Input - Coolant - Power Conversion System (Remove and Replace)
        • Tube - Output - Coolant - Power Conversion System (Remove and Replace)
      • 1630 - HV Battery Electrical Components
        • Busbar - Auxiliary Fuse - HV Battery (Structural Pack) (Remove and Replace)
        • Busbar - Inlet - Negative - Fast Charge - HV Battery (Structural Pack) (Remove and Replace)
        • Busbar - Inlet - Positive - Fast Charge - HV Battery (Structural Pack) (Remove and Replace)
        • Busbar - Outlet - Negative - Fast Charge - HV Battery (Structural Pack) (Remove and Replace)
        • Busbar - Outlet - Positive - Fast Charge - HV Battery (Structural Pack) (Remove and Replace)
        • Contactor - Fast Charge - HV Battery (3-Phase) (Structural Pack) (Remove and Replace)
        • Contactor - Fast Charge - HV Battery (Remove and Replace)
        • Contactor - Fast Charge - HV Battery (Structural Pack) (Remove and Replace)
        • Contactor - Negative - HV Battery (Non-Structural Pack) (Remove and Replace)
        • Contactor - Negative - HV Battery (Structural Pack) (Remove and Replace)
        • Contactor - Positive - HV Battery (Non-Structural Pack) (Remove and Replace)
        • Contactor - Positive - HV Battery (Structural Pack) (Remove and Replace)
        • Controller - High Voltage (Backup and Restore)
        • Controller - High Voltage (Non-Structural Pack) (Remove and Replace)
        • Controller - High Voltage (Structural Pack) (Remove and Replace)
        • Cover - Busbar - Shunt - HV Battery (Remove and Replace)
        • Cover - Pyrotechnic - HV Battery (Remove and Replace)
        • DC Input Assembly - HV Battery (Busbar Type) (Remove and Replace)
        • Ferrite - Shunt Harness - Ancillary Bay - HV Battery (Structural Pack) (Retrofit)
        • Fuse - Heat Pump - HV Battery (Structural Pack) (Remove and Replace)
        • Fuse - Power Conversion System - HV Battery (Remove and Replace)
        • Guide - Probing - HV Battery (Remove and Replace)
        • Guide - Probing - HV Battery (Retrofit)
        • Harness - AC Filter - HV Battery (Non-Structural Pack) (Remove and Replace)
        • Harness - AC Filter - HV Battery (Structural Pack) (Remove and Replace)
        • Harness - AC Filter - HV Battery (3-Phase) (Structural Pack) (Remove and Replace)
        • Harness - Ancillary Bay - HV Battery (Non-Structural Pack) (Remove and Replace)
        • Harness - Ancillary Bay - HV Battery (Structural Pack) (Remove and Replace)
        • Hinge Tray - Controller - High Voltage (Remove and Replace)
        • HV Battery Contactor Seize Check
        • HV Harness - Heat Pump - HV Battery (Structural Pack) (Remove and Replace)
        • HV Header Doubler - DC Input - HV Battery (Structural Pack) (Remove and Replace)
        • HV Header - Rear Drive Unit - HV Battery (Remove and Replace)
        • Insulator - Shunt - HV Battery (Remove and Replace)
        • Insulators - HV Battery (Install and Remove)
        • Passthrough - DCDC - 12V (Busbar Type) (Remove and Replace)
        • Passthrough - DCDC - 12V (Cable Type) (Remove and Replace)
        • Power Conversion System (Non-Structural Pack) (Remove and Install)
        • Power Conversion System (Non-Structural Pack) (Remove and Replace)
        • Power Conversion System (Structural Pack) (Remove and Replace)
        • Pyrotechnic Battery Disconnect (Remove and Replace)
        • Pyrotechnic Battery Disconnect (Structural Pack) (Remove and Install)
        • Pyrotechnic Battery Disconnect (Structural Pack) (Remove and Replace)
        • Resistance Meter (Zero Adjust)
        • Seal - Probe Lid - HV Battery (Remove and Replace)
        • Shunt - HV Battery (Non-Structural Pack) (Remove and Replace)
        • Shunt - HV Battery (Structural Pack) (Remove and Replace)
        • Support Hinge - Controller - High Voltage (Remove and Replace)
        • Switch - Pack Contactors - Ancillary Bay - HV Battery (Remove and Replace)
    • 17 - Electrical
      • Torque Specifications - Electrical
      • 1701 - 12V Battery and Fuses
        • 12V/LV Power (Disconnect and Connect)
        • 12V/LV Battery (Remove and Replace)
        • Fuse Holder - Positive Terminal - 12V Battery (Remove and Replace)
        • LV Battery - Recover
        • LV Maintainer (Connect and Disconnect)
        • Strap - 12V Battery (Remove and Replace)
        • Vehicle HV Disablement Procedure
        • Vehicle HV Disablement Procedure (7-Seater)
        • Vehicle HV Disablement Procedure (Structural Pack)
      • 1710 - Harnesses
        • Busbar - DCDC Ground (Remove and Replace)
        • Elastic Strap - Harness - 2nd Row Seat - Center (Remove and Replace)
        • Harness - 2nd Row Seat - LH (Remove and Replace)
        • Harness - 2nd Row Seat - RH (Remove and Replace)
        • Harness - Backrest - 2nd Row Seat - Center (Remove and Replace)
        • Harness - Backrest - 2nd Row Seat - RH (7-Seat) (Remove and Replace)
        • Harness - Body - LH (LHD) (Remove and Replace)
        • Harness - Body - RH (Remove and Replace)
        • Harness - Cushion - 2nd Row Seat - LH (7-Seat) (Remove and Replace)
        • Harness - Door - Front - LH (Remove and Replace)
        • Harness - Door - Rear - LH (Remove and Replace)
        • Harness - Electronic Parking Brake (EPB) - LH (Remove and Replace)
        • Harness - Fascia - Front (Remove and Replace)
        • Harness - Fascia - Rear (Remove and Replace)
        • Harness - Frame - Seat Back - 3rd Row (Remove and Replace)
        • Harness - Front End Module (Remove and Replace)
        • Harness - Heat Pad - Seat Cushion - 2nd Row (Remove and Replace)
        • Harness - HVAC Assembly (Remove and Replace)
        • Harness - Instrument Panel (Remove and Replace)
        • Harness - Jumper for Ethernet - Car Computer (AP4) (Remove and Replace)
        • Harness - Main Front (Non-Structural Pack) (RHD) (Remove and Replace)
        • Harness - Main Front (Non-Structural Pack) (LHD) (Remove and Replace)
        • Harness - Main Front (Structural Pack) (Remove and Replace)
        • Harness - Seat Cushion - 3rd Row (Remove and Replace)
        • Harness - Seat - Driver (Remove and Replace)
        • Harness - Seat - Front Passenger (Remove and Replace)
        • Harness - Steering Wheel (Remove and Replace)
        • Harness - Front Subframe (Remove and Replace)
        • Harness - Subframe - Rear (Remove and Replace)
        • Harness - Thermal Beam (Remove and Replace)
        • Harness - Liftgate (Remove and Replace)
        • Harness - USB - Car Computer to Glove Box (Heat Pump) (LHD) (Remove and Replace)
        • Harness - Windshield (Remove and Replace)
        • Jumper Harness - Trailer Hitch (Remove and Replace)
        • Jumper Harness - Windshield (Retrofit)
      • 1715 - Electronic Control Modules
        • Module - Body Controller - Front (Remove and Replace)
        • Module - Body Controller - LH (LHD) (Remove and Replace)
        • Module - Body Controller - RH (Remove and Replace)
        • Module - HomeLink Transmitter (Remove and Replace)
        • Steering Controller (Remove and Replace)
      • 1720 - Radar Sensor
        • Bracket - Radar - Front (Remove and Replace)
        • Sensor - Radar - Front (Calibration)
        • Sensor - Radar - Front (Remove and Replace)
        • Radar - Cabin (Remove and Replace)
        • Heater - Radar - Front (Remove and Replace)
      • 1723 - Front Cameras
        • Camera - Bi - Forward Facing (Remove and Replace)
        • Camera - B-Pillar - LH (AP4) (Remove & Replace)
        • Camera - Forward Facing (Pitch Verification)
        • Camera - Triple - Forward Facing (Remove and Replace)
        • Side Repeater Camera - Front - LH (HW4) (Remove and Replace)
        • Fan - Camera - Forward Facing (Remove & Replace)
      • 1724 - Interior Camera
        • Camera - Interior (Remove and Replace)
      • 1725 - Rear Cameras
        • Camera - Rear Facing (Remove and Replace)
      • 1727 - Parking Sensors
        • Retainer - Sensor - Parking Distance (Remove and Replace)
        • Sensor - Parking Distance - Inner - Front (Remove and Replace)
        • Sensor - Parking Distance - Outer - Front (Remove and Replace)
        • Sensor - Parking Distance - Inner - Rear (Remove and Replace)
        • Sensor - Parking Distance - Outer - Rear (Remove and Replace)
      • 1730 - Interior Switches
        • Power Socket 12V - Rear Trunk (Remove and Replace)
        • Switch - Steering Wheel - LH (Remove and Replace)
      • 1735 - Interior Lighting
        • Ambient Light Module - Front Door Trim - LH (Remove and Replace)
        • Puddle Light - Front Door - LH (Remove and Replace)
        • Puddle Light - Rear Door - LH (Remove and Replace)
        • Task Light - Footwell Cover - LH (Remove and Replace)
      • 1740 - Exterior Lights
        • Bracket - Headlight - LH (Remove and Replace)
        • ECU - Headlight - LH (Remove and Replace)
        • Headlamps (SAE-to-Global) - Headlamp Assembly - Pair (Retrofit)
        • Headlights - Adjust - Global (Wall Method)
        • Headlights - Adjust - Global (Tool Method)
        • Headlights - Adjust - NA (Tool Method)
        • Headlights - Adjust - NA (Wall Method)
        • Headlight - LH (Remove and Install)
        • Headlight - LH (Remove and Replace)
        • Headlight - LH (Remove and Replace) (RHD)
        • Headlight - Pair - (Remove and Replace)
        • Light - Brake - Center High Mounted (Remove and Replace)
        • Light - Fog - Front (Adjust)
        • Light - Fog / Reverse - Rear - LH (Remove and Install)
        • Light - Fog / Reverse - Rear - LH (Remove and Replace)
        • Light - License Plate (Remove and Replace)
        • Light - Side Repeater - Front - LH (Remove and Replace)
        • Light - Turn Signal / Fog - Front - LH (Remove and Replace)
        • Reflex Lens - Rear - RH (Remove and Replace)
        • Reflector - Fascia - Rear - LH (Remove and Replace)
        • Taillight - LH (Remove and Install)
        • Taillight - LH (Remove and Replace)
        • Trim - Light - Side Repeater - Front - LH (Remove and Replace)
      • 1745 - Keyless Entry and Security
        • Antenna - Bluetooth Passive Entry - Rear (Remove and Replace)
        • Module - Body Controller - Security (Remove and Replace)
        • Module - Body Controller - Security (2nd Generation) (Remove and Replace)
        • Siren - Battery Backed (Remove and Replace)
        • Additional Key - Program (Existing Key Present)
        • Replacement Keys - Program (No Keys Present)
      • 1750 - Wipers and Washers
        • Reservoir - Windshield Washer (Remove and Replace)
        • Wiper Module (Remove and Replace)
        • Wiper Module (RHD) (Remove and Replace)
        • Wiper Arm - RH (Remove and Replace)
        • Wiper Arm - RH (RHD) (Remove and Replace)
        • Wiper Arms (Remove and Replace)
        • Wiper Blades (Adjust)
        • Wiper Blades (Remove and Replace)
        • Wiper Blades (Remove and Replace) (Pair) (RHD)
        • System - Windshield Washer (Remove and Replace)
        • Sensor - Level - Windshield Washer (Remove and Replace)
        • Pump - Windshield Washer (Remove and Replace)
        • Hose - Washer - Reservoir (LHD) (Remove and Replace)
        • Hose - Washer - Reservoir (RHD) (Remove and Replace)
        • Filler Neck - Reservoir - Windshield Washer (LHD) (Remove and Replace)
        • O-ring - Filler Neck - Reservoir - Windshield Washer (LHD) (Remove and Replace)
        • Cap - Reservoir - Windshield Washer (Remove and Replace)
        • Washer Nozzles (Adjust)
      • 1753 - Horns
        • Horn - High Tone (Remove and Replace)
        • Horn - Low Tone (Remove and Replace)(LV Battery)
        • Horn Assembly (Remove and Replace)
      • 1754 - Pedestrian Warning Speaker
        • Speaker - Pedestrian Warning (Remove and Replace)
      • 1755 - Accelerator Pedal
        • Accelerator (Remove and Replace)
    • 18 - Thermal Management
      • Torque Specifications - Thermal Management
      • 1810 - Cabin HVAC
        • Actuator - Bleed - LH (Remove and Replace)
        • Actuator - Intake (Remove and Replace)
        • Actuator - Lower Mode (Remove and Replace)
        • Actuator - Upper Mode (Remove and Replace)
        • Adapter - Bleeder Duct - Instrument Panel (Remove and Replace)
        • Air Extractor - LH (Remove and Replace)
        • Assembly - Filter - HEPA (Remove and Install)
        • Assembly - Filter - HEPA (Remove and Replace)
        • Blower Motor - HVAC (Remove and Replace)
        • Clean the Blower Motor
        • Cover - Filter - HEPA (Remove and Replace)
        • Duct - Air Wave - LH (Remove and Replace)
        • Duct - Air Wave - RH (Remove and Replace)
        • Duct - Floor - 2nd Row - Main (Non-Structural Pack) (Remove and Replace)
        • Duct - Floor - 2nd Row - Main (Structural Pack) (Remove and Replace)
        • Duct - Floor - 2nd Row - RH (Non-Structural Pack) (Remove and Replace)
        • Duct - Floor - 2nd Row - RH (Structural Pack) (Remove and Replace)
        • Duct - Footwell - LH (Remove and Replace)
        • Duct - Footwell - RH (Remove and Replace)
        • Duct - Fresh Intake (Remove and Replace)
        • Duct - HEPA (Remove and Replace)
        • Filter - Cabin (Remove and Replace)
        • Filters – Carbon and HEPA (Remove and Replace)
        • Housing - Filter - HEPA (Remove and Replace)
        • HVAC Assembly (Remove and Replace)
        • Sensor - Ambient Air Temperature (Remove and Replace)
        • Sensor - Cabin Temperature (Remove and Replace)
        • Thermistor - Airwave Duct - LH (Remove and Replace)
        • Thermistor - Airwave Duct - RH (Remove and Replace)
        • Thermistor - Duct - Lower - LH (Remove and Replace)
        • Thermistor - Duct - Upper - LH (Remove and Replace)
        • Thermistor - Duct - Lower - RH (Remove and Replace)
        • Thermistor - Duct - Upper - RH (Remove and Replace)
        • Thermistor - Evaporator (Remove and Replace)
        • Vehicle Sanitation - Interior Air - Tunap 589 (EMEA)
        • Vehicle Sanitation - Evaporator - Tunap 994 (EMEA)
      • 1820 - Refrigerant System
        • A/C Compressor, Supermanifold and A/C Lines (Remove & Replace)
        • A/C Line - Supermanifold to Compressor (Remove and Replace)
        • A/C Line - Supermanifold to HVAC (Remove and Replace)
        • Use Evaporator Foam Cleaner, Replace Cabin Filters
        • A/C Refrigerant (Recovery and Recharge)
        • A/C Refrigerant (Unknown Oil Quantity) (Recovery, Flush, and Recharge)
        • Acoustic Blanket - Compressor (Retrofit)
        • Bracket - Ancillary Connector Dash Mount (Remove and Replace)
        • Bracket - Compressor (Remove and Replace)
        • Compressor (Remove and Replace)
        • Compressor - Unknown Oil Quantity (EMEA) (Remove and Replace)
        • Desiccant (Remove and Replace)
        • Fan - Condenser (Remove and Replace)
        • Module - Cooling Fan (Remove and Install)
        • Module - Cooling Fan (Remove and Replace)
        • Sensor - Pressure and Temperature (PT) - Low Pressure (Remove and Replace)
      • 1830 - Cooling System
        • Clean Radiator
        • Coolant Pump - HV Battery (RWD) (Remove and Replace)
        • Coolant Pump - HV Battery (Dual Motor) (Remove and Replace)
        • Coolant Pump - Powertrain (Remove and Replace)
        • Cooling System (Check and Fill)
        • Cooling System (Non-Structural Pack) (Drain and Refill)
        • Cooling System (Structural Pack) (Drain and Refill)
        • Cooling System (Partial Refill and Bleed)
        • Cooling System (Vacuum Refill)
        • Hose - Chiller to HV Battery (LHD) (Dual Motor) (Remove and Replace)
        • Hose - Chiller to HV Battery (RWD) (Remove and Replace)
        • Hose - Chiller to HV Battery (RHD) (RWD) (Remove and Replace)
        • Hose - Front Drive Unit Powertrain Bypass (RWD) (Remove and Replace)
        • Hose - Front Manifold - LH (Remove and Replace)
        • Hose - Front Manifold - RH (Remove and Replace)
        • Hose - Inlet - Inverter - Rear Drive Unit (4DU) (Remove and Replace)
        • Hose - Inlet - Inverter - Rear Drive Unit (3DU) (Remove and Replace)
        • Hose - Inlet - Radiator (Remove and Replace)
        • Hose - Inverter Inlet - Front Drive Unit (Remove and Replace)
        • Hose - Inverter Inlet - Front Drive Unit (Non-Heat Pump) (Remove and Replace)
        • Hose - Inverter to Heat Exchanger - Rear Drive Unit (3DU) (Remove and Replace)
        • Hose - Inverter to Heat Exchanger - Rear Drive Unit (4DU) (Remove and Replace)
        • Hose - Outlet - Radiator (Remove and Replace)
        • Hose - Outlet - Rear Drive Unit (4DU) (Remove and Replace)
        • Hose - Outlet - Rear Drive Unit (3DU) (Remove and Replace)
        • Hose - Powertrain Supply - Supermanifold (Remove and Replace)
        • Hose - Return - HV Battery (Remove and Replace)
        • Hose - Return - HV Battery (RWD) (Remove and Replace)
        • Hose - Return - HV Battery - Front (Remove and Replace)
        • Hose - Return - Powertrain (Non-Structural Pack) (Remove and Replace)
        • Hose - Return - Powertrain (Structural Pack) (Remove and Replace)
        • Hose - Return - Powertrain - Front Drive Unit (Remove and Replace)
        • Hose - Supply - Powertrain (Non-Structural Pack) (Remove and Replace)
        • Hose - Supply - Powertrain (Structural Pack) (Remove and Replace)
        • Powertrain Coolant (Drain and Refill)
        • Radiator (Remove and Replace)
        • Tube - Jumper - Front Manifold - LH (Structural Pack) (Remove and Replace)
      • 1840 - Supermanifold
        • Check Valve - Cabin Condenser (Remove and Replace)
        • Check Valve - Evaporator (Remove and Replace)
        • Check Valve - Liquid Cooled Condenser (Remove and Replace)
        • Check Valves - Supermanifold (Remove and Replace)
        • Chiller (Remove and Replace)
        • Coil - Recirculation Expansion Valve (Remove and Replace)
        • Coolant Bottle (Remove and Replace)
        • Liquid Cooled Condenser (Remove and Replace)
        • Octovalve (Remove and Replace)
        • Pump - Coolant - Battery - Supermanifold (Remove and Replace)
        • Sensor - Pressure and Temperature (PT) - High Pressure (Remove and Replace)
        • Sensor - Pressure and Temperature (PT) - Low Pressure (Remove and Replace)
        • Sensor - Subcool - Pressure and Temperature (PT) - High Pressure (Remove and Replace)
        • Shut Off Valve - Liquid Cooled Condenser (Remove and Replace)
        • Supermanifold (Remove and Replace)
        • Supermanifold 1.1 (Retrofit)
        • Valve Body - EXV - Supermanifold (Remove and Replace)
      • 1850 - Air Distribution
        • Active Grille Shutter (Remove and Replace)
    • 20 - Safety and Restraint
      • Airbag and Supplementary Restraint System (SRS) Precautions
      • Torque Specifications - Safety and Restraint
      • 2001 - Airbags
        • Airbag - Curtain - LH (Remove and Replace)
        • Airbag - Driver (Remove and Replace)
        • Airbag - Front Passenger (Remove and Install)
        • Airbag - Front Passenger (Remove and Replace)
        • Airbag - Knee - Driver (Remove and Install)
        • Airbag - Knee - Driver (Remove and Replace)
        • Airbag - Knee - Front Passenger (Remove and Replace)
        • Harness - Airbag - Driver (Remove and Replace)
        • Module - Restraint Control (Non-Structural Pack) (Remove and Replace)
        • Module - Restraint Control (Structural Pack) (Remove and Replace)
        • Remove the Front Seat Airbag and Discard
      • 2005 - Seatbelts
        • Adjustable Top Loop (Remove and Replace)
        • Box Clip - Seat Belt Reminder - 1st Row - LH (Remove and Replace)
        • Buckle - 1st Row - LH (Remove and Replace)
        • Buckle - 2nd Row - Center (5 Seat) (Remove and Replace)
        • Buckle - 2nd Row - Center (7 Seat) (Remove and Replace)
        • Buckle - 2nd Row - LH (5 Seat) (Remove and Replace)
        • Buckle - 2nd Row - LH (7 Seat) (Remove and Replace)
        • Buckle - 3rd Row - LH (Remove and Replace)
        • Escutcheon - 2nd Row - LH (Remove and Replace)
        • Escutcheon - Seat Belt - 3rd Row - LH (Remove and Replace)
        • Retractor - Seatbelt - 1st Row - LH (Remove and Replace)
        • Retractor - Seatbelt - 3rd Row - LH (Remove and Replace)
        • Seatbelt - 2nd Row - Center (5 Seat) (Remove and Replace)
        • Seatbelt - 2nd Row - Center (7 Seat) (Remove and Replace)
        • Seatbelt - 2nd Row - LH (5 Seat) (Remove and Replace)
        • Seatbelt - 2nd Row - LH (7 Seat) (Remove and Replace)
        • Sensor - Resistive Occupancy - 2nd Row Seat - LH (Remove and Replace)
        • Webbing Guide Bar - Seatbelt - 1st Row - LH (Remove and Replace)
      • 2010 - Pretensioners
        • Pretensioner - Outboard Lap - 1st Row - LH (Remove and Replace)
      • 2020 - Sensors
        • Sensor - Impact Accelerometer - B-Pillar - LH (Remove and Replace)
        • Sensor - Impact Accelerometer - Front Bumper - LH (Remove and Replace)
        • Sensor - Pressure - Door - Front - LH (Remove and Replace)
        • Sensor - Pressure - Door - Rear - LH (Remove and Replace)
        • Sensor - Resistive Occupancy - Front Seat - LH (Remove and Replace)
        • Sensor - Resistive Occupancy - Front Seat - RH (Remove and Replace)
        • Sensor - Shotgun Accelerometer - LH (Remove and Replace)
    • 21 - Infotainment
      • Torque Specifications - Infotainment
      • 2105 - Touchscreen
        • Service Panel - Instrument Panel (Remove and Replace)
        • Touchscreen (Remove and Replace)
      • 2115 - Car Computer
        • Car Computer (Dispose)
        • Car Computer (Remove and Replace)
        • Car Computer (Info-Ryzen) (Remove and Install)
        • Car Computer (HW4) (Remove and Install)
        • Connectivity Board - Car Computer (HW3) (Remove and Replace)
        • Connectivity Board - Car Computer (Info-Ryzen) (Remove and Replace)
        • Drip Guard - Car Computer (HW4) (Remove and Replace)
        • SD Card - Car Computer (Remove and Replace)
        • SIM Card - Car Computer (Info-Ryzen) (Retrofit)
        • SIM Card - Car Computer (Remove and Replace)
      • 2121 - Audio System - Speakers Subwoofer Amplifier
        • Amplifier - Audio - External (Remove and Replace)
        • Speaker - Dash - Center (Remove and Replace)
        • Speaker - Dash - LH (Remove and Replace)
        • Speaker - Front Door - LH (Remove and Replace)
        • Speaker - Headliner - LH (Remove and Replace)
        • Speaker - Liftgate - LH (Remove and Replace)
        • Speaker - Rear Door - LH (Remove and Replace)
        • Subwoofer (Remove and Replace)
        • Tweeter Assembly - Front Door - LH (with Tether) (Remove and Replace)
        • Tweeter - Dash (Remove and Replace)
        • Tweeter - Front Door - LH (Remove and Replace)
        • Tweeter - Front Door - LH (with Tether) (Remove and Replace)
      • 2123 - Audio System - AM, FM and HD Radio
        • Tuner - FM / HD / DAB (Remove and Replace)
      • 2126 - Audio System - USB Media Port
        • USB Cable - Center Console (Remove and Replace)
        • USB Hub - Center Console - Front (Remove and Replace)
        • USB Hub - Center Console - Front (2.0) (Remove and Replace)
      • 2130 - Antenna - FM HD Radio
        • Antenna - Ground Noise Filter - LH (Remove and Replace)
        • Antenna Amplifier - FM2 (Remove and Replace)
        • Noise Filter - 12V - Antenna (Remove and Replace)
      • 2132 - Antenna - GPS
        • Antenna - GPS/GNSS (Remove and Replace)
      • 2133 - Antenna - Wi-Fi
        • Antenna - MIMO (Remove and Replace)
    • 30 - Chassis
      • Torque Specifications - Chassis
      • 3001 - Chassis and Subframes
        • Insert - Subframe - Rear (Remove and Replace)
        • Isolator - Motor Mount - Front - LH (Remove and Replace)
        • Isolator - Motor Mount - Front - RH (Remove and Replace)
        • Shear Plate - Rear Subframe - Front - LH (Remove and Replace)
        • Subframe Assembly - Front (Dual Motor) (Remove and Install)
        • Subframe Assembly - Front (Dual Motor) (Remove and Replace)
        • Subframe Assembly - Front (RWD) (Remove and Install)
        • Subframe Assembly - Front (RWD) (Remove and Replace)
        • Subframe Assembly - Rear (Remove and Install)
        • Subframe Assembly - Rear (Remove and Replace)
    • 31 - Suspension
      • Alignment Requirement - Suspension
      • Torque Specifications - Suspension
      • 3100 - Adjustment
        • EPAS Alignment Check
        • Four Wheel Alignment Check
        • Four Wheel Alignment Check and Adjust
      • 3101 - Front Suspension (Including Hubs)
        • Bushing Bracket - Stabilizer Bar - Front - LH (Remove and Replace)
        • Front Upper Control Arm (FUCA) Mount - LH (Remove and Replace)
        • Control Arm - Upper - Front - LH (Non-Structural Pack) (Remove and Replace)
        • Control Arm - Upper - Front - LH (Structural Pack) (Remove and Replace)
        • Hub - Front - LH (Dual Motor) (Remove and Replace)
        • Hub - Front - LH (RWD) (Remove and Replace)
        • Knuckle - Suspension - Front - LH (Dual Motor) (Remove and Replace)
        • Knuckle - Suspension - Front - LH (RWD) (Remove and Replace)
        • Link - Compliance - Lower - Front - LH (Remove and Replace)
        • Link - Lateral - Lower - Front - LH (Remove and Replace)
        • Links - Lateral - Lower - Front - Pair (Remove & Replace)
        • Stabilizer Bar - Front (Remove and Replace)
        • Suspension - Front (Check Torque)
      • 3103 - Rear Suspension (Including Hubs)
        • Cover - Rear Suspension - LH (Remove and Replace)
        • Drop Link - Stabilizer Bar - Rear - LH (Remove and Replace)
        • Hub - Rear - LH (Remove and Replace)
        • Isolator - Lower Spring - Rear - LH (Remove and Replace)
        • Isolator - Upper Spring - Rear - LH (Remove and Replace)
        • Knuckle - Suspension - Rear - LH (Remove and Replace)
        • Link - Aft - Lower - Rear - LH (Remove and Replace)
        • Link - Aft - Upper - Rear - LH (Remove and Replace)
        • Link - Fore - Lower - Rear - LH (Remove and Replace)
        • Link - Fore - Upper - Rear - LH (Remove and Replace)
        • Stabilizer Bar - Rear (Remove and Replace)
        • Suspension - Rear (Check Torque)
        • Toe Link - Rear - LH (Remove and Replace)
      • 3115 - Coil Suspension System
        • Damper - Rear - LH (Remove and Replace)
        • Isolator - Front Upper Control Arm (FUCA) Mount - LH (Remove and Replace)
        • Spring - Rear Suspension - LH (Remove and Replace)
        • Damper Assembly - Front - LH (Remove and Replace)
        • Damper Assembly - Front - Pair (Remove and Replace)
    • 32 - Steering
      • Torque Specifications - Steering
      • 3201 - Steering Rack and Lower Column
        • Module - Steering Column Control (Remove and Replace)
        • Steering Rack (Dual Motor) (Remove and Replace)
        • Steering Rack (RWD) (Remove and Replace)
        • Tie Rod End - LH (Remove and Replace)
      • 3205 - Upper Column Steering Wheel Steering Lock
        • Horn - Steering Wheel (Remove and Replace)
        • Rim - Steering Wheel (Remove and Replace)
        • Shroud - Lower - Steering Column (Remove and Replace)
        • Spoke Cover - Steering Wheel - Lower (Remove and Replace)
        • Steering Column (LHD) (Remove and Replace)
        • Steering Column (LHD) (Structural Pack) (Remove and Replace)
        • Steering Column (RHD) (Remove and Replace)
        • Steering Wheel (Remove and Install)
        • Steering Wheel (Remove and Replace)
        • Surround - Steering Wheel (Remove and Replace)
    • 33 - Brakes
      • Torque Specifications - Brakes
      • 3301 - Brake Discs and Calipers
        • Boot Kit - Brake Caliper - Front (Remove and Replace)
        • Boot Kit - Brake Caliper - Rear (Remove and Replace)
        • Bracket - Brake Caliper - Rear - LH (Remove and Replace)
        • Brake Pad Kit - Front - Hitachi (Remove and Replace)
        • Brake Caliper - Front - LH (Remove and Replace)
        • Brake Caliper - Rear - LH (Remove and Replace)
        • Brake Caliper - Rear - Pair (Remove and Replace)
        • Brake Pads - Burnishing
        • Brake Pad Kit - Front (Remove and Replace)
        • Brake Pad Kit - Rear (Base Brakes) (Remove and Replace)
        • Brake Pad Kit - Rear (Sport Brakes) (Remove and Replace)
        • Brake Rotor - Front - LH (Measure Runout)
        • Brake Rotor - Front - LH (Remove and Replace)
        • Brake Rotor - Rear - LH (Measure Runout)
        • Brake Rotor - Rear - LH (Remove and Replace)
        • Clean and Lubricate Brake Calipers (Non-Performance Brakes)
        • Clean and Lubricate Brake Calipers (Performance Brakes)
        • NVH Tape - Brake Pads - Front (EMEA) (Retrofit)
        • NVH Tape - Brake Pads - Rear (EMEA) (Retrofit)
        • Shield - Dust - Brake - Front - LH (Dual Motor) (Remove and Replace)
        • Shield - Dust - Brake - Front - LH (RWD) (Remove and Replace)
        • Shield - Dust - Brake - Rear - LH (Remove and Replace)
      • 3303 - Brake Pipes and Hoses
        • Brake Fluid Bleed - One Caliper
        • Brake Fluid Bleed/Flush
        • Brake Fluid Check
        • Brake Hose - Flexible - Front - LH (Remove and Replace)
        • Brake Hose - Flexible - Rear - LH (Remove and Replace)
        • Brake Lines - 2 Tube Bundle - Rear (Remove and Replace)
        • Brake Lines - Front Bundle (Remove and Replace)
        • Brake Lines - Front Bundle (Structural Pack) (Remove and Replace)
        • Brake Lines - LH Sill (RWD) (Remove and Replace)
        • Brake Lines - LH Sill (Structural Pack) (Remove and Replace)
        • Brake Lines - Master Cylinder to ABS (Non-Structural Pack) LHD) (Remove and Replace)
        • Brake Lines - Master Cylinder to ABS (Structural Pack) (LHD) (Remove and Replace)
        • Brake Lines - Master Cylinder to ABS (Non-Structural Pack) (RHD) (Remove and Replace)
        • Brake Lines - Rear - RH to Sill (Structural Pack) (Remove and Replace)
        • Pipe - Brake - Rear - LH (Remove and Replace)
      • 3305 - Parking Brake
        • Motor - Brake Caliper - Rear - LH (Remove and Replace)
        • Parking Brake - Caliper - Rear - LH (Release)
      • 3310 - ABS Traction and Stability Control
        • ABS Modulator (Remove and Replace)
        • ECU - ABS (Non-Structural Pack) (Remove and Replace)
        • ECU - ABS (Structural Pack) (Remove and Replace)
        • Hydraulic Control Unit (HCU) - Brake (Non-Structural Pack) (Remove and Replace)
        • Hydraulic Control Unit (HCU) - Brake (Structural Pack) (Remove and Replace)
        • Sensor - Wheel Speed - ABS - Front - LH (Remove and Replace)
        • Sensor - Wheel Speed - ABS - Rear - LH (Remove and Replace)
      • 3320 - Brake Booster
        • Electromechanical Brake Booster Assembly (Non-Structural Pack) (LHD) (Remove & Replace)
        • Electromechanical Brake Booster Assembly (Non-Structural Pack) (RHD) (Remove and Replace)
        • Electromechanical Brake Booster Assembly (Structural Pack) (Remove and Replace)
        • Master Cylinder and Reservoir Assembly (Remove and Replace)
        • Sensor - Brake Fluid Reservoir Level (Remove and Replace)
      • 3325 - Brake Pedal
        • Brake Pedal (Non-Structural Pack) (Remove and Replace)
        • Brake Pedal (Structural Pack) (Remove and Replace)
        • Clevis Pin - Brake (Remove and Replace)
        • Pedal Pad - Brake (Remove and Replace)
        • Switch - Brake Light (Remove and Replace)
    • 34 - Wheel and Tires
      • Torque Specifications - Wheels and Tires
      • 3401 - Wheels
        • Cap - Wheel (Remove and Replace)
        • Wheel Assembly (Remove and Install)
        • Wheel (Remove and Replace)
        • Wheels - Set (Remove and Replace)
      • 3402 - Tires
        • Replacement Tire Information
        • Tire - Front - LH (Dismount and Mount)
        • Tire - Front - LH (Balance)
        • Tire - Front - LH (Road Force) (Balance)
        • Tire - Front - LH (Repair)
        • Tire Rotation
      • 3404 - Tire Pressure Monitoring System (TPMS)
        • BLE TPMS (Retrofit)
        • BLE TPMS (Update Configuration)
        • Sensor - TPMS (Remove and Replace)
        • TPMS (Sensor ID Drive Learn)
        • TPMS (Sensor ID Tool Learn)
    • 39 - Front Drive Unit
      • Torque Specifications - Front Drive Unit
      • 3901 - Front Drive Unit Assembly
        • Bushing – Front Drive Unit – RH (Remove and Replace)
        • Bushing - Gearbox - Front Drive Unit (Remove and Replace)
        • Drive Unit - Front (Remove and Replace)
        • Fluid Coupling (90 Degrees) - Front Drive Unit (Remove and Replace)
        • Fluid Coupling (Straight) - Front Drive Unit (Remove and Replace)
        • Ground Strap - Front Drive Unit (Remove and Replace)
        • Mount - Front Drive Unit - LH (Remove and Replace)
      • 3920 - Front Drive Inverter
        • Inverter - Front Drive Unit (Remove and Replace)
      • 3930 - Front Gearbox and Halfshafts
        • Bushing - Gearbox - Front Drive Unit (Remove and Replace)
        • Filter - Oil - Front Drive Unit (Remove and Replace)
        • Gearbox Fluid - Front Drive Unit (Drain and Refill)
        • Halfshaft - Front Drive Unit - LH (Remove and Replace)
        • Heat Exchanger - Front Drive Unit (Remove and Replace)
        • Oil Pump - Front Drive Unit (Remove and Replace)
        • Seal - Axle - Front Drive Unit - LH (Remove and Replace)
    • 40 - Rear Drive Unit
      • Torque Specifications - Rear Drive Unit
      • 4001 - Rear Drive Unit Assembly
        • Bushing - Rear Drive Unit - Rear (3DU) (Remove and Replace)
        • Bushing - Rear Drive Unit - Rear (4DU) (Remove and Replace)
        • Bushing - Rear Drive Unit - RH (Remove and Replace)
        • Drive Unit - Rear (3DU) (Remove and Install)
        • Drive Unit - Rear (3DU) (Remove and Replace)
        • Drive Unit - Rear (4DU) (Remove and Install)
        • Drive Unit - Rear (4DU) (Remove and Replace)
        • Fluid Coupling (55 Degrees) - Rear Drive Unit (Remove and Replace)
        • Ground Strap - Rear Drive Unit (Remove and Replace)
        • Mount - Rear Drive Unit - LH (3DU) (Remove and Replace)
        • Mount - Rear Drive Unit - LH (4DU) (Remove and Replace)
      • 4020 - Rear Drive Inverter
        • Fluid Coupling (55 Degrees) - Rear Drive Unit (Remove and Replace)
        • Fluid Coupling (Straight) - Rear Drive Unit (Remove and Replace)
        • Inverter Air Leak Test
        • Inverter - Rear Drive Unit (4DU) (Remove and Replace)
        • Inverter - Rear Drive Unit (3DU) (Remove and Replace)
      • 4030 - Rear Gearbox and Halfshafts
        • Breather - Rear Drive Unit (Remove and Replace)
        • Filter - Oil - Rear Drive Unit (Remove and Replace)
        • Gearbox Fluid - Rear Drive Unit (4DU) (Drain and Refill)
        • Gearbox Fluid - Rear Drive Unit (3DU) (Drain and Refill)
        • Halfshaft - Rear Drive Unit - LH (Remove and Replace)
        • Heat Exchanger - Rear Drive Unit (4DU) (Remove and Replace)
        • Heat Exchanger - Rear Drive Unit (3DU) (Remove and Replace)
        • Oil Pump - Rear Drive Unit (4DU) (Remove and Replace)
        • Oil Pump - Rear Drive Unit (3DU) (Remove and Replace)
        • Seal - Axle - Rear Drive Unit - LH (Remove and Replace)
    • 44 - High Voltage System
      • Torque Specifications - High Voltage System
      • 4400 - High Voltage Testing
        • Isolation/Insulation Test
        • Vehicle HV Disablement Procedure
        • Vehicle HV Disablement Procedure (Structural Pack)
        • Vehicle HV Disablement Procedure (7-Seater)
      • 4401 - Charge System Inlet
        • Bracket - Busbar - Charge Port to HV Battery (3-Phase) (Remove and Replace)
        • Busbars - Charge Port to HV Battery (Remove and Replace)
        • Busbars - Charge Port to HV Battery (3-Phase) (Remove and Replace)
        • Charge Port - Manual Release of Cable
        • Charge Port (China) (Busbar Type) (Remove and Replace)
        • Charge Port (3-Phase) (Remove and Replace)
        • Charge Port (NA) (Remove and Replace)
        • Charge Port Voltage Check
        • ECU - Charge Port (7-Seat) (Remove and Replace)
        • ECU - Charge Port (Combo Adapter) (Retrofit)
        • Connector - DC Input - Busbar - Charge Port to HV Battery (Remove and Replace)
        • Deadfronts - Pin - Charge Port (NA) (Damaged) (Remove and Replace)
        • Deadfronts - Pin - Charge Port (NA) (Undamaged) (Remove and Replace)
        • Door and Hinge Cover - Charge Port (Remove and Replace)
        • Door Assembly - Charge Port (China) (Remove and Replace)
        • Door Assembly - Charge Port (EMEA) (Remove and Replace)
        • Door Assembly - Charge Port (NA) (Remove and Replace)
        • ECU - Charge Port (Remove and Replace)
        • Latch Actuator - Charge Port (3 Phase) (Remove and Replace)
        • Latch Pin - AC - Charge Port (China) (Remove and Replace)
        • Latch Pin - DC - Charge Port (China) (Remove and Replace)
        • Release Cable - Charge Port (NA) (Remove and Replace)
        • Release Cable - Charge Port (3-Phase) (Remove and Replace)
        • Safety Cap - Busbar - Charge Port to HV Battery (3-Phase) (Remove and Replace)
        • Safety Cap - Busbar - Charge Port to HV Battery (Remove and Replace)
        • Sensor Target - Door - Charge Port (Remove and Replace)
      • 4450 - HV Harnesses
        • AC Cable - Charge Port to HV Battery (3-Phase) (Remove and Replace)
        • AC Cable - Charge Port to HV Battery (3-Phase) (Retrofit)
        • HV Harness - Center Ski to A/C Compressor (Remove and Replace)
        • HV Harness - HV Battery To A/C Compressor (Structural Pack) (Remove and Replace)
        • HV Harness - HV Battery to Front Drive Unit (Structural Pack) (Remove and Replace)
        • HV Harness - HV Battery to Rear Drive Unit (Non-Structural Pack) (4DU) (Remove and Replace)
        • HV Harness - HV Battery to Rear Drive Unit (Structural Pack) (Remove and Replace)
    • 50 - External Charging Connectors
      • 5001 - Mobile Connector
        • Firmware Update - Mobile Connector
        • Remove Stuck Deadfront - Charge Handle
      • 5003 - Charging Adapters
        • Firmware Update - CHAdeMO Charging Adapter
    • © Tesla 2024
    • Procedure Feedback
    • Site Feedback

    Crowsfoot or Offset Wrench Extension Calculator

    Torque Calculator Values
    Note
    1. If the angle from the extension to the torque wrench is greater than 90° (Figure 2), input E as a positive number.
    2. If the angle from the extension to the torque wrench is less than 90° (Figure 3), input E as a negative number.
    3. If the angle from the extension to the torque wrench is exactly 90°, this calculator is not needed. Torque the fastener to T1.
    Figure 1
    Figure 2
    Figure 3