Model X Service Manual

    16 - BATTERY SYSTEM

    • 1601 - HV Battery Assembly
    • 1610 - HV Battery Enclosure
    • 1620 - HV Battery Cooling System
    • 1630 - HV Battery Electrical Components
    • Model X Service Manual (2021+)
    • Release Notes
      • Current Release Notes
      • Release Notes Archive
        • Release Notes June-September 2022
        • Release Notes October-December 2022
        • Release Notes January-March 2023
        • Release Notes April-June 2023
        • Release Notes July-September 2023
        • Release Notes October-December 2023
        • Release Notes January-March 2024
        • Release Notes April-June 2024
        • Release Notes July-September 2024
    • GENERAL INFORMATION
      • INTRODUCTION
        • Abbreviations and Symbols
        • Flat Rate Times
        • Global Refresh for 2021+ Model X
        • How To Use This Manual
        • Repairs and Replacements
        • Warranty Service Regions
      • BEST PRACTICES
        • Air Bag and Supplementary Restraint System (SRS) Precautions
        • Multimeter (LoZ Setting)
        • Air Conditioning System Precautions
        • Diagnostic Port Location
        • Electrical Precautions
        • Environmental Precautions
        • Event Data Recorder Retrieval
        • Flexible Pipes and Hoses
        • General Fitting Instructions
        • General Precautions
        • Locking Devices
        • Oil Seals
        • Personal Protection
        • SRS Component Replacement Policy
        • Vehicle Cameras and Autopilot
        • Wheel Disposal (Rework)
      • CHARGING
        • Charging Precautions
        • General
      • FLUIDS AND CAPACITIES
        • Fluids
        • Fluid Capacities
      • IDENTIFICATION NUMBERS
        • Vehicle and Wheel Paint Codes
        • Vehicle Identification Number (VIN)
      • TECHNICAL DATA
        • Brakes
        • Fuse Locations
        • Suspension
        • Tire Pressures
        • Wheel Alignment
        • Wheels
    • 00 - INSPECTION AND SERVICE
      • 0001 - Scheduled Service
        • Maintenance Service and Intervals
      • 0002 - Firmware Service
        • Firmware Reinstall - Toolbox
        • Firmware Reinstall - Touchscreen
        • Firmware Update
        • User Data (Factory Reset)
      • 0005 - Service Modes
        • OBD Connector (Retrofit)
        • Gateway Configuration (Display and Change)
        • Gateway (Unlock)
        • Service Mode (Enable and Disable)
        • Service Mode Plus
        • Toolbox 3 (Connect and Disconnect)
    • 10 - BODY
      • 1000 - Vehicle Lifting
        • Raise Vehicle - 2 Post Lift
        • Raise Vehicle - Floor Jack (Mobile Service)
      • 1001 - Bumper/Fascia
        • Air Extractor - Rear - Inner - LH (Remove and Replace)
        • Air Extractor - Rear - Outer - LH (Remove and Replace)
        • Bracket - Attachment - Fascia - Rear (Remove and Replace)
        • Bracket - Fascia to Fender - LH (Remove and Replace)
        • Bracket - Rear Wing - LH (Remove and Replace)
        • Bumper Beam - Front (Remove and Replace)
        • Cover - Trailer Hitch (Remove and Replace)
        • Fascia Assembly - Front (Remove and Install)
        • Fascia Assembly - Front (HW3) (Remove and Replace)
        • Fascia Assembly - Front (HW4) (Remove and Replace)
        • Fascia Assembly - Rear (Remove and Install)
        • Fascia Assembly - Rear (HW4) (Remove and Replace)
        • Fascia Assembly - Rear - Lower (Remove and Replace)
        • Fascia Assembly - Rear - Upper (Remove and Replace)
        • Grille - Fascia - Front (Remove and Replace)
        • Shroud - Air Extractor - Rear - Inner - LH (Remove and Replace)
        • T Badge Support - Fascia - Front (Remove and Replace)
        • V Bar - Fascia - Front (Remove and Replace)
        • Valance - Front Fascia (Remove and Replace)
      • 1010 - Body Panels
        • Bracket - Headlight - LH (Remove and Replace)
        • Carrier - Front End (Remove and Replace)
        • Door Assembly - Front - LH (Remove and Replace)
        • Door Assembly - Rear Lower - LH (Remove and Replace)
        • Door Assembly - Rear Upper - LH (Remove and Replace)
        • EPAS Grounding Points - Front Rails (Restore)
        • Fender Assembly - Front - LH (Remove and Replace)
        • Foam - Bumper Beam - Front (Remove and Replace)
        • Hood Assembly (Remove and Replace)
        • Liftgate (Remove and Replace)
        • Liftgate Drain - LH (Remove and Replace)
      • 1020 - Windshield, Liftgate Glass, and Body Glass
        • Backlight Glass (Remove and Install)
        • Backlight Glass (Remove and Replace)
        • Clear Forward Camera View (Precision Cleaning Of Inboard Windshield)
        • Glass - Rear Quarter - LH (Remove and Install)
        • Glass - Rear Quarter - LH (Remove and Replace)
        • Sensor - HVAC - Windshield (Remove and Replace)
        • Windshield Chip Repair
        • Windshield Scratch Repair
        • Windshield (Remove and Install)
        • Windshield (Remove and Replace)
        • Windshield (Reuse Humidity and Temperature Sensor) (Remove and Replace)
        • Windshield and Roof Glass Repair and Replacement Guidelines
      • 1030 - Paint
        • Paint Defect Rectification
      • 1040 - Spine
        • Applique - Spine - Center (Remove and Replace)
      • Panel Alignment
        • Panel Alignment Specifications
    • 11 - CLOSURE COMPONENTS
      • 1133 - Closure Assist Mechanisms and Hinges
        • Ball Stud Bracket - Front - Rear Door - LH (Remove and Replace)
        • Ball Stud - Liftgate - LH (Remove and Replace)
        • Bumper Bracket - Front - Rear Door - Upper - LH (Remove and Replace)
        • Bumper - Front - Rear Door - Upper - LH (Remove and Replace)
        • Bumper - Liftgate - LH (Remove and Replace)
        • Bump Stop - Rear Door - LH (Remove and Replace)
        • Bumper - Sprung - Hood (Remove and Replace)
        • Carrier - Sensor - Ultrasonic - Rear Door - LH (Remove and Replace)
        • Front Door Drive Unit - LH (Remove and Replace)
        • Gas Strut - Hood - LH (Remove and Replace)
        • Gas Strut - Liftgate (Remove and Replace)
        • Hinge - Door - Front - Lower - LH (Remove and Replace)
        • Hinge - Door - Front - Upper - LH (Remove and Replace)
        • Hinge - Liftgate - LH (Remove and Replace)
        • Module - Front Door Controller - LH (Remove and Replace)
        • Module - Rear Door Controller- LH (Remove and Replace)
        • Module - Rear Door Electromechanical Controller - LH (Remove and Replace)
        • Module - Ultrasonic Door Sensors - LH (Remove and Replace)
        • Pop Actuator - Front Door - LH (Remove and Replace)
        • Power Strut - Liftgate (Remove and Replace)
        • Rear Door Hinge - Primary - Front - LH (Remove and Replace)
        • Rear Door Hinge - Secondary - Front - LH (Remove and Replace
        • Rear Door Spring - Front - LH (Remove and Replace)
        • Rear Door Spring - Rear - LH (Remove and Replace)
        • Retainer - Switch - Rear Door - Door Mounted - LH (Remove and Replace)
        • Sensor - Ultrasonic - Rear Door - LH (Remove and Replace)
        • Sleeve - Rear Door Spring - Rear - LH (Remove and Replace)
        • Strut - Rear Door - Primary - LH - Forward (Remove and Replace)
        • Strut - Rear Door - Secondary - LH - Forward (Remove and Replace)
        • Switch - Rear Door - Door Mounted - LH (Remove and Replace)
        • Ultrasonic Sensor Holder - Butyl - Rear Door – LH (Remove and Replace)
      • 1135 - Latches, Strikers, and Pinch Sensors
        • Actuator - Cinching - Liftgate (Remove and Replace)
        • Actuator - E Release - Door - Front - LH (Remove and Replace)
        • Cable - Cinch - Liftgate (Remove and Replace)
        • Cinching Actuator - Door - Rear - LH (Remove and Replace)
        • Cover - Lower Latch - Door - Rear - LH (Remove and Replace)
        • Exterior Release Switch - Liftgate (Remove and Replace)
        • Latch - Door - Front - LH (Remove and Replace)
        • Latch - Door - Rear - LH (Remove and Replace)
        • Latch - Hood (Single Actuator) (Remove and Replace)
        • Latch - Liftgate (Remove and Replace)
        • Latch and Actuator Assembly - Door - Rear - LH (Remove and Replace)
        • Pinch Sensor - Front - 2nd Row - LH (Remove and Replace)
        • Pinch Sensor - Liftgate - LH (Remove and Replace)
        • Pinch Sensor - Rear - 2nd Row - LH (Remove and Replace)
        • Shroud - Cinching Actuator - Door - Rear - LH (Remove and Replace)
        • Shroud - Latch - Door - Rear - LH (Remove and Replace)
        • Striker - Door - Front - LH (Remove and Replace)
        • Striker - Door - Rear - LH (Remove and Replace)
        • Striker - Hood (Remove and Replace)
        • Striker - Liftgate (Remove and Replace)
        • Switch - Liftgate - Interior (Remove and Replace)
      • 1140 - Interior Door Handles
        • Handle - Emergency Release - Liftgate (Remove and Replace)
      • 1145 - Exterior Door Handles
        • Bezel - Exterior Door Handle - Front - LH (Remove and Replace)
        • Handle - Exterior Release - Door - Front - LH (Remove & Replace)
        • Handle - Exterior Release - Door - Rear - LH (Remove and Replace)
      • 1150 - Door Glass and Regulators
        • Door Glass - Front - LH (Adjust)
        • Door Glass - Front - LH (Remove and Replace)
        • Door Glass - Rear - LH (Adjust)
        • Door Glass - Rear - LH (Remove and Replace)
        • Door Glass Assembly - Rear - Upper - LH (Remove and Replace)
        • Fixed Glass - Front - LH (Remove and Replace)
        • Fixed Glass - Rear Door - LH (Remove and Replace)
        • Switch - Rear Window - LH (Remove and Replace)
        • Switch - Window - Front Passenger (Remove and Replace)
        • Window Motor/Regulator Assembly - Front - LH (Remove and Replace)
        • Window Regulator - Rear - LH (Remove and Replace)
        • Window Regulator (Recalibrate)
      • 1170 - Seals Body Enclosures
        • Aero Seal - Hood (Remove and Replace)
        • Catch Basin - Active Spoiler - LH (Remove and Replace)
        • Closeout Panel - Door - Front - LH (Remove and Replace)
        • Closeout Panel - Door - Rear - LH (Remove and Replace)
        • Cover - Catch Basin - Active Spoiler - LH (Remove and Replace)
        • Protector - Lower Edge - Rear Door - LH (Remove and Replace)
        • Seal - Body - Side - Front - Primary - LH (Remove and Replace)
        • Seal - Body - Side - Rear - Primary - LH (Remove and Replace)
        • Seal - B-Pillar Applique - LH (Remove and Replace)
        • Seal - Door - Rear - Upper - LH (Remove and Replace)
        • Seal - Door Glass - Lower - Rear - LH (Remove and Replace)
        • Seal - Hood (Remove and Replace)
        • Seal - Inner Belt - Front Door - LH (Remove and Replace)
        • Seal - Inner Belt - Rear Door - LH (Remove and Replace)
        • Seal - Liftgate - Margin (Remove and Replace)
        • Seal - Liftgate (Remove and Replace)
        • Seal - Lower NVH Extrusion - LH (Remove and Replace)
        • Seal - Outer Belt - Front Door - LH (Remove and Replace)
        • Seal - Outer Belt - Rear Door - LH (Remove and Replace)
        • Seal - Rear Door Cantrail - LH (Remove and Replace)
        • Seal - Secondary - Front Door - LH (Remove and Replace)
        • Seal - Upper Bright - Front - LH (Remove and Replace)
    • 12 - EXTERIOR FITTINGS
      • 1201 - Wheel Arch Liners
        • Baffle - Fender - LH (Remove and Replace)
        • Noise Absorber - Motor Bay - Front Bulkhead (Remove and Replace)
        • Noise Absorber - Motor Bay - Rear (Remove and Replace)
        • Wheel Arch Liner - Front - LH (Remove and Replace)
        • Wheel Arch Liner - Rear - LH (Remove and Replace)
      • 1203 - Undertray and Diffuser
        • Diffuser - Rear Fascia (Remove and Replace)
        • Panel - Aero Shield - Front (Remove and Replace)
        • Panel - Aero Shield - Mid (Remove and Replace)
      • 1205 - Badges and Films
        • Plaid Graphic Badge (Remove and Replace)
        • Plaid Letter Badge (Remove and Replace)
        • Tesla Badge - Front (Remove and Replace)
        • Tesla Badge - Rear (Remove and Replace)
      • 1207 - License Plate Mountings
        • Base Bracket - License Plate - Front (Remove and Replace)
        • Bracket - License Plate - Front (Rework)
      • 1209 - Exterior Mirrors
        • Door Mirror Assembly - LH (Remove and Replace)
        • Glass - Door Mirror - LH (Remove & Replace)
        • Skull Cap - Door Mirror - LH (Remove and Replace)
      • 1220 - Exterior Trim
        • Applique - B-Pillar - LH (Remove and Replace)
        • Applique - Liftgate (Remove and Replace)
        • Applique - Rear Door - Front - LH (Remove and Replace)
        • Applique - Roof - Front (Remove and Replace)
        • Applique - Roof - Rear (Remove and Replace)
        • Bracket - Applique - Liftgate (Remove and Replace)
        • Brightwork - Upper - Front - LH (Remove and Replace)
        • Brightwork - Upper - Rear - LH (Remove and Replace)
        • Carrier - Applique - Center Spine - LH (Remove and Replace)
        • Carrier - Rocker Panel - LH (Remove and Replace)
        • Cladding - Door - Front - LH (Remove & Replace)
        • Cladding - Door - Rear - LH (Remove & Replace)
        • Cladding - Door - Rear - Wheel Arch - LH (Remove and Replace)
        • Fairing - Rocker Panel - Rear - LH (Remove and Replace)
        • Fairing - Wheel - Front - LH (Remove & Install)
        • Fender Garnish and Wheel Fairing Assembly - Front - LH (Remove and Replace)
        • Garnish - Fender - Rear - LH (Remove and Replace)
        • Mud Flaps (Retrofit)
        • Molding - Rocker Panel - LH (Remove and Replace)
        • Mud Flaps (Retrofit)
        • Pad - Lifting - Each (Remove and Replace)
      • 1222 - Spoiler
        • Applique - Spoiler (Remove and Install)
        • Applique - Spoiler (Remove and Replace)
        • Carrier - Stanchion - Passive Spoiler - LH (Remove and Replace)
      • 1225 - Underhood Trim
        • Cover - Shock Tower - LH (Remove and Replace)
        • Hose - Drain - Cowl Screen (Remove and Replace)
        • Panel - Cowl Screen (Remove and Replace)
        • Underhood Apron - Front (Remove and Replace)
        • Underhood Apron - LH (Remove and Replace)
        • Underhood Apron - Rear (Remove and Replace)
      • 1227 - Liftgate Trough Trim
        • Garnish - Liftgate Trough - Rear Fascia (Remove and Replace)
        • Stop - Liftgate - LH (Remove and Replace)
        • Trim - Liftgate Trough - Center (Remove and Replace)
        • Trim - Liftgate Trough - LH (Remove and Replace)
      • 1230 - Trailer Hitch
        • Assembly - Trailer Hitch (Remove and Replace)
        • ECU - Trailer Hitch (Remove and Replace)
    • 13 - SEATS
      • 1301 - Front Seat Tracks and Motors
        • Button - Cushion Adjust - Driver Seat (Remove and Replace)
        • Button - Recliner Adjust - Driver Seat (Remove and Replace)
        • Controller - Driver Seat (Remove and Replace)
        • Cover - Front - Seat Track - 1st Row Seat (Remove and Replace)
        • Cover - Inner - Podium - Driver (Remove and Replace)
        • Cover - LH - Riser - Front Seat (Remove and Replace)
        • Cover - Outer - Podium - Driver (Remove and Replace)
        • Cover - RH - Riser - Front Seat (Remove and Replace)
        • Fan - Backrest - Driver Seat (Remove and Replace)
        • Fan - Cushion - Driver Seat (Remove and Replace)
        • Light - Under Seat - Driver (Remove and Replace)
        • Module - ECU - Occupant Classification System (OCS) - Front Passenger (Remove and Replace)
        • Motor - Recliner - Back Rest - Driver Seat (Remove and Replace)
        • Motor - Seat Height - Driver Seat (Remove and Replace)
        • Motor - Seat Tilt - Driver Seat (Remove and Replace)
        • Motor - Seat Track - Driver Seat (Remove and Replace)
        • Podium - 1st Row (Remove and Replace)
        • Recliner Tube - Driver Seat (Remove and Replace)
        • Riser - Outer - Driver Seat (Remove and Replace)
        • Seat - 1st Row (Calibration)
        • Sensor - Position - Seat Track - 1st Row Seat - LH (Remove and Replace)
      • 1302 - 2nd Row Seat Tracks and Motors
        • 60/40 Seat Switch - 2nd Row - LH (Remove and Replace)
        • 60/40 Seat Switch - 2nd Row - RH (Remove and Replace)
        • Actuator - 60 Track - 2nd Row Seat (7 Seat) (Remove and Replace)
        • Actuator Assembly - Release - EZ Entry - 2nd Row - LH (7 Seat) (Remove and Replace)
        • Actuator Assembly - Release - EZ Entry - 2nd Row - RH (7 Seat) (Remove and Replace)
        • Actuator - EZ Entry - 40 Track - 2nd Row Seat (7 Seat) (Remove and Replace)
        • Actuator - EZ Entry - 60 Track - 2nd Row Seat (7 Seat) (Remove and Replace)
        • Actuator - Pitch Latch - 2nd Row Seat - LH (6 Seat) (Remove and Replace)
        • Bracket - Catcher - 2nd Row Seat - LH (6 Seat) (Remove and Replace)
        • Cap - Switch - 2nd Row - LH (6 Seat) (Remove and Replace)
        • Drive Shaft - 2nd Row Seat Motor - LH (6 Seat) (Remove and Replace)
        • Front Support - Seat Base - 2nd Row - LH (6 Seat) (Remove and Replace)
        • Microswitch - EZ Entry - 2nd Row - LH (7 Seat) (Remove and Replace)
        • Microswitch - EZ Entry - 2nd Row - RH (7 Seat) (Remove and Replace)
        • Module - 2nd Row Seat Controller - LH (5 Seat) (Remove and Replace)
        • Module - 2nd Row Seat Controller - LH (6 Seat) (Remove and Replace)
        • Motor - Pitch - 2nd Row - LH (6 Seat) (Remove and Replace)
        • Motor - Seat Track - 2nd Row - LH (6 Seat) (Remove and Replace)
        • Release Cable - EZ Entry - 2nd Row - RH (7 Seat) (Remove and Replace)
        • Shaft - Inboard - Seat Track Motor - 2nd Row - LH (6 Seat) (Remove and Replace)
        • Slider - Actuator - 2nd Row (5/7 Seat) (Remove and Replace)
        • Slider - Seat - 2nd Row - LH (6 Seat) (Remove and Replace)
        • Strut Rod Assembly - Pitch - 2nd Row - LH (6 Seat) (Remove and Replace)
        • Switch - 2nd Row - LH (6 Seat) (Remove and Replace)
        • Switch - Easy Entry - 2nd Row Seat - LH (6 Seat) (Remove and Replace)
        • Track - Outer - 2nd Row Seat - LH (6 Seat) (Remove and Replace)
        • Track - Inner - 2nd Row Seat - LH (6 Seat) (Remove and Replace)
      • 1303 - 3rd Row Seat Tracks and Motors
        • Actuator Pulley - Recliner - 3rd Row Seat (Remove and Replace)
        • Actuator - Headrest - 3rd Row - LH (Remove and Replace)
        • Actuator - Recliner - 3rd Row Seat - LH (Remove and Replace)
        • Cable - Recliner - 3rd Row Seat - LH (Remove and Replace)
        • Switch - Recliner - 3rd Row Seat - LH (Remove and Replace)
      • 1304 - Front Seat Assemblies and Hardware
        • Back Rest - Driver (Remove and Replace)
        • Back Rest - Front Passenger (Remove and Replace)
        • Frame - Seat Cushion - Driver Seat (Remove and Replace)
        • Lumbar Support - Backrest - Driver Seat (Remove and Replace)
        • Microphone - Seat - Driver (Remove and Replace)
        • Post Guide - Headrest - Driver Seat (Remove and Replace)
        • Seat Assembly - 1st Row - LH (Remove and Install)
        • Seat Assembly - 1st Row - LH (Remove and Replace)
        • Seat Assembly - 1st Row - RH (Remove and Install)
        • Seat Assembly - 1st Row - RH (Remove and Replace)
        • Shell - Seat Back - Driver (Remove and Replace)
        • Trim - Headrest - Driver (Remove and Replace)
      • 1305 - 2nd Row Seat Assemblies and Hardware
        • Cable - Recliner - 2nd Row - LH (7 Seat) (Remove and Replace)
        • Cable - Recliner - 2nd Row - RH (5 Seat) (Remove and Replace)
        • Cable - Recliner - 2nd Row - RH (7 Seat) (Remove and Replace)
        • Cushion Sub-assembly - 2nd Row Seat - LH (5 Seat) (Remove and Replace)
        • Cushion Sub-assembly - 2nd Row Seat - RH (5 Seat) (Remove and Replace)
        • Seat Assembly - 2nd Row - LH (5 Seat) (Remove and Replace)
        • Seat Assembly - 2nd Row - LH (7 Seat) (Remove and Replace)
        • Seat Assembly - 2nd Row - LH (Without 2nd Row Bench Seats) (Remove and Replace)
        • Seat Assembly - 2nd Row - RH (5 Seat) (Remove and Replace)
        • Seat Assembly - 2nd Row - RH (7 Seat) (Remove and Replace)
        • Seat Back Sub-Assembly - 2nd Row Seat - LH (5 Seat) (Remove and Replace)
        • Seat Back Sub-Assembly - 2nd Row Seat - RH (5 Seat) (Remove and Replace)
        • Seat Back Sub-Assembly - 2nd Row Seat - LH (7 Seat) (Remove and Replace)
        • Seat Back Sub-assembly - 2nd Row Seat - RH (7 Seat) (Remove and Replace)
        • Switch - Back Rest and Cushion Adjust - Driver Seat (Remove and Replace)
      • 1306 - 3rd Row Seat Assemblies and Hardware
        • Crush Plastic - Front - 3rd Row - LH (Remove and Replace)
        • Crush Plastic - Rear - 3rd Row - LH (Remove and Replace)
        • Cushion - Seat - 3rd Row - LH (Remove and Replace)
        • Cushion - Seat - 3rd Row (Remove and Replace)
        • Frame - Seat Cushion - 3rd Row (Remove and Replace)
        • Headrest - 3rd Row Seat - LH (Remove and Replace)
        • Luggage Hook Tie Down - 3rd Row Seat Back - LH (Remove and Replace)
        • Seat Assembly - 3rd Row (Remove and Replace)
        • Seat Back Carpet - 3rd Row - LH (Remove and Replace)
        • Tray Harness - 3rd Row - LH (Remove and Replace)
        • USB Hub - Seat - 3rd Row (Remove and Replace)
      • 1307 - Front Seat Covers, Pads, and Trims
        • Carrier - LH - Side Shield - Outboard - Front Seat (Remove and Replace)
        • Carrier - RH - Side Shield - Inboard - Front Seat (Remove and Replace)
        • Cover - Back Rest - Driver (Remove and Replace)
        • Cover - Cushion - Driver Seat (Remove and Replace)
        • Foam - Back Rest - Driver Seat (Remove and Replace)
        • Foam - Cushion - Driver Seat (Remove and Replace)
        • Side Shield - Inboard - Driver Seat (Remove and Replace)
        • Side Shield - Outboard - Driver Seat (Remove and Replace)
      • 1308 - 2nd Row Seat Covers Pads and Trims
        • Cover - Recliner - 2nd Row - LH (Remove and Replace)
        • Cover - Seat Back - 2nd Row Seat - LH (6 Seat) (Remove and Replace)
        • Lever - Recliner - 2nd Row - LH (Remove and Replace)
        • Side Shield - Inboard - 2nd Row Seat - LH (5 Seat) (Remove and Replace)
        • Side Shield - Inboard - 2nd Row Seat - RH (5 Seat) (Remove and Replace)
        • Side Shield - Outboard - 2nd Row Seat - RH (5 Seat) (Remove and Replace)
        • Trim - Backrest - Seat - 2nd Row - LH (6 Seat) (Remove and Replace)
        • Trim - Cushion and Backrest Bolster - Seat - 2nd Row - LH (6 Seat) (Remove and Replace)
        • Trim - Inner - Seat Post - 2nd Row - LH (Remove and Replace)
        • Trim - Outer - Seat Post - 2nd Row - LH (Remove and Replace)
        • Trim - Underbelly - 2nd Row Seat - LH (6 Seat) (Remove and Replace)
        • Trim Strip - Rear - 2nd Row Seat - LH (6 seat) (Remove and Replace)
      • 1309 - 3rd Row Seat Covers Pads and Trims
        • Back Panel - Headrest - 3rd Row - LH (Remove and Replace)
        • Closeout - Cup Holder - Seat - 3rd Row (Remove and Replace)
        • Cover - Bracket - 3rd Row - Center (Remove and Replace)
        • Cover - Bracket - 3rd Row - LH (Remove and Replace)
        • Cover - Cushion - 3rd Row (Remove and Replace)
        • Cover - Recliner - 3rd Row - Center (Remove and Replace)
        • Cover - Recliner - 3rd Row - LH (Remove and Replace)
        • Heater Pad - Cushion - 3rd Row - LH (Remove and Replace)
        • Rocket Clip - Seat Cushion - 3rd Row - LH (Remove & Replace)
        • Substrate - Cushion - 3rd Row (Remove and Replace)
    • 14 - INSTRUMENT PANELS AND PEDALS
      • 1405 - Instrument Panel
        • Aero Lens - Instrument Panel (Remove and Replace)
        • Bracket - Toeboard - Center (Remove and Replace)
        • Cover - Aero Lens - Instrument Panel - LH (Remove and Replace)
        • Cover - Footwell - Outboard - Driver (Remove and Replace)
        • Cover - Footwell - Inboard - Driver (Remove and Replace)
        • Cover - Footwell - Passenger (Remove and Replace)
        • Cover - Knee Airbag - Driver (Remove and Replace)
        • Cover - Knee Airbag - Front Passenger (Remove and Replace)
        • Cross Car Beam (Remove and Replace)
        • Decor - Instrument Panel - Main (Remove and Replace)
        • End Cap - Instrument Panel - LH (Remove and Replace)
        • Gap Hider - Steering Column - Upper (Remove and Replace)
        • Glove Box (Remove and Replace)
        • Instrument Panel - Lower (Remove and Replace)
        • Latch - Shape Memory Alloy (SMA) - Glove Box (Remove and Replace)
        • Shroud - Upper - Steering Column (Remove and Replace)
        • Sub Assembly - Instrument Panel (Remove and Install)
        • Sub Assembly - Instrument Panel (Remove and Replace)
        • Trim - Middle - Instrument Panel - LH (Remove and Replace)
        • Trim - Middle - Instrument Panel - RH (Remove and Replace)
    • 15 - INTERIOR TRIM
      • 1505 - Interior Mirror and Sun Visors
        • Cover - Harness - Rear View Mirror (Remove and Replace)
        • Glare Shield - Autopilot (Remove and Replace)
        • Mirror - Rear View (Remove and Replace)
        • Camera Cover - Lower (Remove and Replace)
        • Camera Cover - Upper (Remove and Replace)
        • Sun Visor - LH (Remove and Replace)
      • 1511 - Liftgate Trim
        • Bracket - Trim - Liftgate - Center (Remove and Replace)
        • Grille - Speaker - Liftgate (Remove and Replace)
        • Trim - Liftgate - Lower (Remove and Replace)
        • Trim - Upper - Liftgate (Remove and Replace)
      • 1513 - Door Trim
        • Bracket - Rear Door Trim - Center - LH (Remove and Replace)
        • Bracket - Rear Door Trim - Upper - Front - LH (Remove and Replace)
        • Bracket - Rear Door Trim - Upper - Rear - LH (Remove and Replace)
        • Decor - Trim - Front Door - LH (Remove and Replace)
        • Decor - Trim - Rear Door - LH (Remove and Replace)
        • Garnish - Lower - Door Trim - Rear - LH (Remove and Replace)
        • Gap Hider - Door Trim - LH - Rear - Mid (Remove and Replace)
        • Grille - Speaker - Rear - LH (Remove and Replace)
        • Panel - Door Trim - Front - LH (Remove and Replace)
        • Panel - Door Trim - Rear - LH (Remove and Replace)
        • Panel - Door Trim - Rear - Upper - LH (Remove & Replace)
        • Reflector - Door Trim - Front - LH (Remove and Replace)
        • Sensor - Ultrasonic - Interior - Rear Door - LH (Remove and Replace)
      • 1518 - Pillar and Sill Trim
        • Bezel - Striker - Racetrack - LH (Remove and Replace)
        • Bracket - A-Pillar - Upper - LH (Remove and Replace)
        • Bracket - Racetrack - B-Pillar - Lower - LH (Remove and Replace)
        • Bracket - Racetrack - B-Pillar - Mid - LH (Remove and Replace)
        • Bracket - Racetrack - B-Pillar - Upper - LH (Remove and Replace)
        • Bracket - Racetrack - C-Pillar - Lower - LH (Remove and Replace)
        • Bracket - Racetrack - C-Pillar - Upper - LH (Remove and Replace)
        • Bracket - Racetrack - Header - Front - LH (Remove and Replace)
        • Bracket - Racetrack - Header - Rear - LH (Remove and Replace)
        • Bracket - Racetrack - Sill - LH (Remove and Replace)
        • Bracket - Racetrack - Spine - LH (Remove and Replace)
        • Bracket - Zone - C-Pillar - Mid - LH (5 Seat) (Remove and Replace)
        • Bracket - Zone - C-Pillar - Mid - LH (6/7 Seat) (Remove and Replace)
        • Racetrack Trim - Front - LH (Remove and Replace)
        • Racetrack Trim - Lower - LH (Remove and Replace)
        • Racetrack Trim - Rear - LH (Remove and Replace)
        • Racetrack Trim - Upper - LH (Remove and Replace)
        • Reinforcement - Inner - LH (Remove and Replace)
        • Trim - A-Pillar - Lower - LH (Remove and Replace)
        • Trim - A-Pillar - Middle - LH (Remove and Replace)
        • Trim - A-Pillar - Upper - LH (Remove and Replace)
        • Trim - A-Pillar - Sun Visor Bezel - LH (Remove and Replace)
        • Trim - B-Pillar - Lower - LH (Remove and Replace)
        • Trim - B-Pillar - Upper - LH (Remove and Replace)
        • Trim - C-Pillar - Lower - LH (Remove and Replace)
        • Trim - C-Pillar - Mid - LH (Remove and Replace)
        • Trim - C-Pillar - Upper - LH (Remove and Replace)
        • Trim - Sill Panel - Front - LH (Remove and Replace)
        • Trim - Sill Panel - Rear - LH (Remove and Replace)
      • 1519 - Center Console - 1st Row
        • Armrest - Center Console (Remove and Replace)
        • Bright Strip - Center Console - Rear (Remove and Replace)
        • Carpet - Side Panel - Center Console - LH (Remove and Replace)
        • Center Console Assembly - 1st Row (Remove and Install)
        • Center Console Assembly (Remove and Replace)
        • Cup Holder - 2nd Row (Remove and Replace)
        • Decor - Center Console (Remove and Replace)
        • Inductive Charger - Center Console (Remove and Replace)
        • Lid - Cup Holder - 2nd Row (Remove and Replace)
        • Light - Armrest Bin - Center Console (Remove and Replace)
        • Panel - Lower Rear - Center Console (Remove and Replace)
        • Panel - Service - Center Console (Remove and Replace)
        • Phone Dock - Center Console (Remove and Replace)
        • Side Panel - Center Console - LH (Remove and Replace)
        • Switch - Lid - Center Console (Remove and Replace)
        • Trim - USB Port - Rear - Center Console (Remove and Replace)
      • 1520 - Headliner
        • Coat Hook - Rear - LH (Remove and Replace)
        • Headliner (Remove and Install)
        • Headliner (Remove and Replace)
      • 1524 - Luggage Compartment Trim
        • Bracket - Tie Down - Rear Trunk - LH (Remove and Replace)
        • Bracket - Tie Down - Rear Trunk - RH (Remove and Replace)
        • Bracket - Trim - Trunk - LH (Remove and Replace)
        • Bracket - Trim - Trunk - RH (Remove and Replace)
        • Carpet - Trim - Trunk - LH (Remove and Replace)
        • Carpet - Rear Trunk (5 Seat) (Remove and Replace)
        • Carpet - Rear Trunk (7 Seat) (Remove and Replace)
        • Garnish - Rear Trunk - Side - LH (Remove and Replace)
        • Tie Down - Rear Trunk - LH (Remove and Replace)
        • Trim - Side - Trunk - LH (5 Seat) (Remove and Replace)
        • Trim - Side - Trunk - LH (6/7 Seat) (Remove and Replace)
        • Trim - Side - Trunk - RH (Remove and Replace)
        • Trim - Sill - Trunk (Remove and Replace)
        • Underhood Storage Unit (Remove and Install)
        • Underhood Storage Unit (Remove and Replace)
        • Underhood Storage Unit Access Panel (Remove and Replace)
      • 1530 - Carpeting and Mats
        • Bracket - 2nd Row Floor Panel - Center (Without 2nd Row Bench Seats) (Remove and Replace)
        • Bracket - 2nd Row Floor Panel - LH (7 Seat) (Remove and Replace)
        • Bracket - 2nd Row Floor Panel - LH (Without 2nd Row Bench Seats) (Remove and Replace)
        • Bracket - 2nd Row Floor Panel - RH (7 Seat) (Remove and Replace)
        • Bracket - 2nd Row Floor Panel - RH (Without 2nd Row Bench Seats) (Remove and Replace)
        • Bracket - Center Console (Remove and Replace)
        • Bracket - Support - Outboard - RH (Remove and Replace)
        • Bracket - Trunk Load Floor - LH (Remove and Replace)
        • Bracket - Trunk Load Floor - RH (Remove and Replace)
        • Carpet - 1st Row (Remove and Replace)
        • Carpet - 3rd Row (Remove and Replace)
        • Carpet - Podium (Remove and Replace)
        • Carpet - Sliding - Seat - 2nd Row - LH (Remove and Replace)
        • Carpet - Surround - Seat - 2nd Row - LH (Remove and Replace)
        • Common Bracket - Mid Floor - 2nd Row - LH (Remove and Replace)
        • Cover - Bracket - Trunk Load Floor - LH (Remove and Replace)
        • Floor Mat - 2nd Row (Remove and Replace)
        • Floor Panel - Front - 2nd Row (5/7 Seat) (Remove and Replace)
        • Floor Panel - Front - 2nd Row (6 Seat) (Remove and Replace)
        • Floor Panel - Mid - 2nd Row (5 Seat) (Remove and Replace)
        • Floor Panel - Mid - 2nd Row (6 Seat) (Remove and Replace)
        • Floor Panel - Mid - 2nd Row (7 Seat) (Remove and Replace)
        • Floor Panel - Rear - 2nd Row (5 Seat) (Remove and Replace)
        • Floor Panel - Rear - 2nd Row (6 Seat) (Remove and Replace)
        • Floor Panel - Rear - 2nd Row (7 Seat) (Remove and Replace)
        • Floor Support - Front - 2nd Row - LH (Remove and Replace)
        • Floor Support - Front - 2nd Row - RH (Remove and Replace)
        • Floor Supports - Rear - 2nd Row - LH (Remove and Replace)
        • Floor Supports - Rear - 2nd Row - RH (Remove and Replace)
        • Front Floor Plate - Inboard - 2nd Row Seat - LH (7 Seat) (Remove and Replace)
        • Front Floor Plate - Outboard - 2nd Row Seat - LH (7 Seat) (Remove and Replace)
        • Gap Hider - Trunk (5 Seat) (Remove and Replace)
        • Harpoon Bracket - Gap Hider - Trunk - Center (5 Seat) (Remove and Replace)
        • Harpoon Bracket - Gap Hider - Trunk - LH (5 Seat) (Remove and Replace)
        • Insulator - Dash (Remove and Replace)
        • Insulator - Motor Bay - Rear (5 Seat) (Remove and Replace)
        • Insulator - Motor Bay - Rear (7 Seat) (Remove and Replace)
        • Insulator - Top Cowl (Remove and Replace)
        • Insulator - Wheelhouse - Rear - LH (Remove and Replace)
        • Insulator - Wheelhouse - Rear - RH (Remove and Replace)
        • NVH Insulator - Floor - 3rd Row (Remove and Replace)
        • NVH Insulator - Floor - Rear Trunk (Remove and Replace)
        • Panel - Footrest - Front Passenger (LHD) (Remove and Install)
        • Plate - Sliding - Seat - 2nd Row - LH (Remove and Replace)
        • Support - Carpet - Driver (Remove and Replace)
        • Support - Carpet - Front Passenger (Remove and Replace)
        • Trim - Crush Can - Rear Trunk - LH (Remove and Replace)
        • Trunk Load Floor - Front (Remove and Replace)
        • Trunk Load Floor - Rear (Remove and Replace)
        • Trunk Load Floor - Side (Remove and Replace)
      • 1535 - Center Console - 2nd Row
    • 16 - BATTERY SYSTEM
      • 1601 - HV Battery Assembly
        • HV Battery (AWD) (Remove and Install)
        • HV Battery (AWD) (Remove and Replace)
        • HV Battery Revision -F to Revision -H (5-Seat) (Retrofit)
        • HV Battery Revision -F to Revision -H (6-Seat) (Retrofit)
        • HV Battery Revision -F to Revision -H (7-Seat) (Retrofit)
      • 1610 - HV Battery Enclosure
        • Cover - Front Access - HV Battery (Remove and Install)
        • Cover - Front Access - HV Battery (Remove and Replace)
        • Cover - Pyrotechnic Fuse - HV Battery (Remove and Replace)
        • Cover - Rear Access - HV Battery (Remove and Replace)
        • Flood Port (Remove and Replace)
        • Ground Cable - HV Battery (Remove and Replace)
        • HV Battery Air Leak Test (In Vehicle)
        • HV Battery Air Leak Test (On Table)
      • 1620 - HV Battery Cooling System
        • Platter Enclosure Coolant (Drain)
        • Platter Enclosure Coolant (Drain) (On Table)
        • Platter Enclosure Coolant Leak Test (On Table)
        • Power Conversion System Coolant (Drain)
        • Power Conversion System Coolant (Drain) (On Table)
        • Power Conversion System Coolant Leak Test (On Table)
        • Tube - Inlet - Coolant - Power Conversion System (Remove and Replace)
        • Tube - Outlet - Coolant - Power Conversion System (Remove and Replace)
      • 1630 - HV Battery Electrical Components
        • Carrier - Connector - Front - HV Battery (Remove and Replace)
        • Contactor - Fast Charge - HV Battery (Remove and Replace)
        • Contactor - Negative - HV Battery (Remove and Replace)
        • Contactor - Positive - HV Battery (Remove and Replace)
        • Controller - High Voltage (Backup and Restore)
        • Controller - High Voltage (Remove and Replace)
        • Fuse - A/C Compressor - HV Battery (Remove and Replace)
        • Fuse - Power Conversion System - HV Battery (Remove and Replace)
        • Harness - A/C Compressor HV Header - HV Battery (Remove and Replace)
        • Harness - High Voltage Controller - HV Battery (Remove and Replace)
        • Harness - LV - Front - HV Battery (Remove and Replace)
        • Harness - Pyrotechnic - HV Battery (Remove and Replace)
        • HV Harness - Power Conversion System (Remove and Replace)
        • HV Header - 6 Pin - HV Battery (Remove and Replace)
        • HV Header - Front Drive Unit - HV Battery (Remove and Replace)
        • HV Header - Rear Drive Unit - HV Battery - LH (Remove and Replace)
        • Power Conversion System (Remove and Replace)
        • Pyrotechnic Battery Disconnect (Remove and Replace)
        • Resistance Meter (Zero Adjust)
        • Shunt - HV Battery (Remove and Replace)
    • 17 - ELECTRICAL
      • 1701 - LV Battery and Fuses
        • Battery - LV (Remove and Replace)
        • LV Battery - Recover
        • LV Maintainer (Connect and Disconnect)
        • LV Power (Disconnect and Connect)
        • Vehicle HV Disablement Procedure
      • 1710 - Harnesses
        • Harness - Body - LH (EMEA) (Remove and Replace)
        • Harness - Body - LH (Remove and Replace)
        • Harness - Body - RH (EMEA) (Remove and Replace)
        • Harness - Body - RH (Remove and Replace)
        • Harness - Center Console (Remove and Replace)
        • Harness - Chassis - Rear - LH (Remove and Replace)
        • Harness - Fascia - Front (Remove and Replace)
        • Harness - Fascia - Rear (HW3) (Remove and Replace)
        • Harness - Front Door - LH (Remove and Replace)
        • Harness - Front Drive Unit (Remove and Replace)
        • Harness - Headliner (Remove and Replace)
        • Harness - HVAC Assembly (Remove and Replace)
        • Harness - Instrument Panel (Remove and Replace)
        • Harness - Liftgate (Remove and Replace)
        • Harness - Main Front (Remove and Replace)
        • Harness - Power Strut - Rear Door - LH (Remove and Replace)
        • Harness - Rear Door - Lower - LH (Remove and Replace)
        • Harness - Rear Door - Upper - LH (Remove and Replace)
        • Harness - Rear View Mirror (Remove and Replace)
        • Harness - Seat Assembly - 2nd Row - LH (5 Seat) (Remove and Replace)
        • Harness - Seat Assembly - 2nd Row - RH (7 Seat) (Remove and Replace)
        • Harness - Seat - Driver (Remove and Replace)
        • Harness - Seat Assembly - 2nd Row - RH (5 Seat) (Remove and Replace)
        • Harness - Seat Assembly - 2nd Row - LH (7 Seat) (Remove and Replace)
        • Harness - Seat Back - 3rd Row - LH (Remove and Replace)
        • Harness - Sub-Assembly - Instrument Panel (Remove and Replace)
        • Harness - Subframe - Rear (Remove and Replace)
        • Harness - Subframe - Rear (Plaid) (Remove and Replace)
        • Harness - Thermal Bar (Remove and Replace)
        • Harness - USB - 3rd Row (Remove and Replace)
        • Harness - USB - Car Computer To Glove Box (Remove and Replace)
      • 1715 - Electronic Control Modules
        • Module - Battery Controller (Remove and Replace)
        • Module - Body Controller - Front (Remove and Replace)
        • Module - Body Controller - LH (Remove and Replace)
        • Module - Body Controller - RH (Remove and Replace)
        • Module - HomeLink Transmitter (Remove and Replace)
      • 1720 - Radar Sensor
        • Heater - Radar (Remove and Replace)
        • Radar - Interior (Remove and Replace)
        • Sensor - Radar - Front (Calibration)
        • Sensor - Radar - Front (Remove and Replace)
      • 1722 - Cameras
        • Camera - Forward Facing (Pitch Verification)
        • Camera - B-Pillar - LH (HW4) (Remove and Replace)
        • Camera - Bi - Forward Facing (HW4) (Remove and Replace)
        • Camera - Triple - Forward Facing (HW3) (Remove and Replace)
        • Camera - Interior (Remove and Replace)
        • Camera - Rear Facing (HW3) (Remove and Replace)
        • Camera - Rear Facing (HW4) (Remove and Replace)
        • Side Repeater Camera - Front - LH (HW4) (Remove and Replace)
      • 1727 - Parking Sensors
        • Retainer - Sensor - Parking Distance (Remove and Replace)
        • Sensor - Parking Distance - Inner - Front (HW3) (Remove and Replace)
        • Sensor - Parking Distance - Inner - Rear (HW3) (Remove and Replace)
        • Sensor - Parking Distance - Outer - Front (HW3) (Remove and Replace)
        • Sensor - Parking Distance - Outer - Rear (HW3) (Remove and Replace)
      • 1730 - Interior Switches and Aux Power Socket
        • 12V Power Socket - Center Console (Remove and Replace)
        • 12V Power Socket - Rear Trunk (Remove and Replace)
      • 1735 - Interior Lighting
        • Footwell Light - Rear - Center Console (Remove and Replace)
        • Light - Glove Box (Remove and Replace)
        • Light - Map - Front (Remove and Replace)
        • Light - Map - Rear (Remove and Replace)
        • Puddle Light - Front Door - LH (Remove and Replace)
        • Puddle Light - Liftgate (Remove and Replace)
        • Puddle Light - Rear Trunk (Remove and Replace)
      • 1740 - Exterior Lights
        • Cover - Side - Tail Light - Liftgate - LH (Remove and Replace)
        • Headlights - Adjust - Europe (ECE) (Wall Method)
        • Headlights - Adjust (Global) (Tool Method)
        • Headlights - Adjust (Global) (Wall Method)
        • Headlights - Adjust - NA (Tool Method)
        • Headlights - Adjust - NA (Wall Method)
        • Light - Fog/Reverse - Rear - LH (Remove and Replace)
        • Headlight - LH (Remove and Replace)
        • Lamp - Reflex - Rear - LH (Remove and Replace)
        • Light - Brake - High Mounted (Remove and Replace)
        • Light - Fog - Front - LH (Remove and Replace)
        • Side Repeater - Front - LH (HW3) (Remove and Replace)
        • Side Repeater - Front - LH (HW4) (Remove and Replace)
        • Switch - Hazard Warning (Remove and Replace)
        • Reflex Marker - Taillight - RH (Global) (Remove and Replace)
        • Reflex Marker - Taillight - RH (Remove and Replace)
        • Taillight - LH (Remove and Replace)
        • Taillight - RH (Remove and Replace)
      • 1745 - Keyless Entry and Security
        • Additional Key - Program (Existing Key Present)
        • Replacement Keys - Program (No Keys Present)
        • Module - Bluetooth Low Energy (BLE) - Front (Remove and Replace)
        • Module - Bluetooth Low Energy (BLE) - Rear (Remove and Replace)
        • Module - Body Controller - Security (Remove and Replace)
      • 1750 - Wipers and Washers
        • Hose - Washer - Reservoir (Remove and Replace)
        • Hose - Washer - Cowl Screen (Remove and Replace)
        • Pump - Windshield Washer Reservoir (Remove and Replace)
        • Reservoir - Windshield Washer (Remove and Replace)
        • Sensor - Level - Windshield Washer Reservoir (Remove and Replace)
        • Wiper Arm - LH (Remove and Replace)
        • Wiper Arm - RH (Remove and Replace)
        • Wiper Blades (Adjust)
        • Wiper Blades - Pair (Remove and Replace)
        • Wiper Module (Remove and Replace)
      • 1753 - Horn
        • Horn - High Tone (Remove and Replace)
        • Horn - Low Tone (Remove and Replace)
      • 1755 - Accelerator Pedal
        • Accelerator Pedal (Remove and Replace)
    • 18 - THERMAL MANAGEMENT
      • 1810 - Cabin HVAC
        • Actuator - Bypass - 1st Row - HVAC Case (Remove and Replace)
        • Actuator - Bypass - 2nd Row - HVAC Case (Remove and Replace)
        • Actuator - Defrost (Remove and Replace)
        • Actuator - Duct - Center Console (Remove and Replace)
        • Actuator - Duct - Floor - 2nd Row (Remove and Replace)
        • Actuator - Duct - Footwell - LH (Remove and Replace)
        • Actuator - Duct - Footwell - RH (Remove and Replace)
        • Actuator - Flap - Center Console - LH (Remove and Replace)
        • Actuator - Intake (Remove and Replace)
        • Actuator - Panel - LH (Remove and Replace)
        • Actuator - Panel - RH (Remove and Replace)
        • Actuator - Vane - Center Console - LH (Remove and Replace)
        • Air Vent - Instrument Panel - Driver (LHD) (Remove and Replace)
        • Air Vent - Instrument Panel - Passenger (LHD) (Remove and Replace)
        • Air Wave Assembly - Center Console (Remove and Replace)
        • Blower Motor - HVAC (Remove and Replace)
        • Cap - Air Wave - Center Console (Remove and Replace)
        • Cover - Filter - HEPA (Remove and Replace)
        • Duct - Center Console - 3rd Row (Remove and Replace)
        • Duct - Busbar - 3rd Row - LH (Remove and Replace)
        • Duct - Instrument Panel - Driver (Remove and Replace)
        • Duct - Instrument Panel - Front Passenger (Remove and Replace)
        • Duct - Jumper - Inboard - Driver (Remove and Replace
        • Duct - Jumper - Outboard - Driver (Remove and Replace
        • Duct - Rocker - 3rd Row - RH (Remove and Replace)
        • Duct - Side Window Defrost - LH (Remove and Replace)
        • Filter - Cabin (Remove and Replace)
        • Filter - HEPA (Remove and Replace)
        • Funnel - Drain - HVAC (Remove and Replace)
        • Hose - Drain - HVAC (Remove and Replace)
        • Housing - Filter - HEPA (Remove and Replace)
        • HVAC Assembly (Remove and Replace)
        • Sensor - Air Temperature - Duct - Defrost (Remove and Replace)
        • Sensor - Air Temperature - Duct - Driver (Remove and Replace)
        • Sensor - Air Temperature - Duct - Footwell - LH (Remove and Replace)
        • Sensor - Air Temperature - Duct - Footwell - RH (Remove and Replace)
        • Sensor - Air Temperature - Duct - Front Passenger (Remove and Replace)
        • Sensor - Air Temperature - Floor Duct - 2nd Row (Remove and Replace)
        • Sensor - Air Quality (Remove and Replace)
        • Sensor - Cabin Temperature (Fan Driven) (Remove and Replace)
        • Sensor - Ambient Air Temperature (Remove and Replace)
        • Sump Seal - HVAC Assembly \(Remove and Replace\)
        • Thermistor - Evaporator (Remove and Replace)
      • 1820 - Refrigerant System
        • A/C Compressor (Remove and Replace)
        • A/C Line - Supermanifold to HVAC (Remove and Replace)
        • A/C Refrigerant (Recovery and Recharge)
        • A/C Refrigerant (Unknown Oil Quantity) (Recovery, Flush, and Recharge)
        • Bracket - Compressor (Remove and Replace)
        • Compressor, Supermanifold, and A/C Lines (Remove and Replace)
        • Desiccant (Remove and Replace)
      • 1830 - Cooling System
        • 12mm Radiator (Remove and Replace)
        • 21mm Radiator (Remove and Replace)
        • 3 Way Coolant Valve - Radiator Bypass (Remove and Replace)
        • Cooling Fan Module (Remove and Replace)
        • Cooling System (Check and Fill)
        • Cooling System (Partial Refill and Bleed)
        • Cooling System (Vacuum Refill)
        • Hose - Battery Supply (Remove and Replace)
        • Hose - Front Drive Unit Heat Exchanger to Supermanifold (Remove and Replace)
        • Hose - Front Drive Unit Heat Exchanger to Supermanifold (Plaid) (Remove and Replace)
        • Hose - HV Battery to 3 Way Valve (Remove and Replace)
        • Hose - HV Battery to Front Drive Unit Inverter (Plaid) (Remove and Replace)
        • Hose - HV Battery to LH Front Sill (Remove and Replace)
        • Hose - Inlet - Inverter - Rear Drive Unit (Remove and Replace)
        • Hose - Inlet - Inverter - Rear Drive Unit (Plaid) (Remove and Replace)
        • Hose - Inverter Inlet - Front Drive Unit (Remove and Replace)
        • Hose - Inverter to Heat Exchanger - Front Drive Unit (Remove and Replace)
        • Hose - Offboard Powertrain Pump To Radiator (Remove and Replace)
        • Hose - Outlet - Radiator (Remove and Replace)
        • Hose - Outlet - Rear Drive Unit (Remove and Replace)
        • Hose - Outlet - Rear Drive Unit (Plaid) (Remove and Replace)
        • Hose - Powertrain Supply - HV Battery to Supermanifold (Remove and Replace)
        • Hose - Radiator to 3 Way Valve (Remove and Replace)
        • Hose - Return - Powertrain (Remove and Replace)
        • Hose - RH Front Sill to Underhood (Remove and Replace)
        • Hose - Supermanifold To 3 Way Valve And Radiator (Remove and Replace)
        • Hose - Supermanifold To Offboard Battery Pump (Remove and Replace)
        • Hose - Supermanifold To Offboard Powertrain Pump (Remove and Replace)
        • Pump - Coolant - Battery - Offboard (Remove and Replace)
        • Pump - Coolant - Powertrain - Radiator (Remove and Replace)
        • Shroud - Cooling Fan Module (Remove and Replace)
        • Thermal Fluid - Cooling System (Fill/Drain)
      • 1840 - Supermanifold
        • Actuator - Octovalve (Remove and Replace)
        • Check Valve - Cabin Condenser (Remove and Replace)
        • Check Valve - Evaporator (Remove and Replace)
        • Check Valve - Liquid Cooled Condenser (Remove and Replace)
        • Chiller (Remove and Replace)
        • Coil - EXV - Supermanifold (Remove and Replace)
        • Coolant Bottle (Remove and Replace)
        • Expansion Valve - Liquid Cooled Condenser (Remove and Replace)
        • Liquid Cooled Condenser (Remove and Replace)
        • Octovalve (Remove and Replace)
        • Pump - Coolant - Battery - Supermanifold (Remove and Replace)
        • Pump - Coolant - Powertrain - Supermanifold (Remove and Replace)
        • Sensor - Subcool - Pressure and Temperature (PT) - High Pressure (Remove and Replace)
        • Supermanifold (Remove and Replace)
        • Valve Body - EXV - Supermanifold (Remove and Replace)
      • 1850 - Air Distribution
        • Active Grille Shutter (Remove and Replace)
    • 20 - SAFETY AND RESTRAINT
      • Air Bag and Supplementary Restraint System (SRS) Precautions
      • 2001 - Air Bags
        • Airbag - Driver (Remove and Replace)
        • Airbag - Front Passenger (Remove and Replace)
        • Curtain Airbag - 2nd Row - LH (Remove and Replace)
        • Curtain Airbag - Driver (Remove and Replace)
        • Knee Airbag - Driver (Remove and Replace)
        • Knee Airbag - Front Passenger (Remove and Replace)
        • Module - Restraint Control (Remove and Replace)
        • Remove the Front Seat Airbag and Discard
        • Side Airbag - 2nd Row - LH (Remove and Replace)
        • Side Airbag - 2nd Row - RH (Remove and Replace)
      • 2005 - Seat Belts
        • Bracket - Escutcheon - Seatbelt - 2nd Row - Center (5 Seat) (Remove and Replace)
        • Bracket - Escutcheon - Seatbelt - 2nd Row - RH (5 Seat) (Remove and Replace)
        • Buckle - 1st Row - LH (Remove and Replace)
        • Buckle - 2nd Row - Center (5 Seat) (Remove and Replace)
        • Buckle - 2nd Row - LH (5 Seat) (Remove and Replace)
        • Buckle - 2nd Row - LH(6 Seat) (Remove and Replace)
        • Buckle - 3rd Row (Remove and Replace)
        • Escutcheon - Seatbelt - 2nd Row - Center (Remove and Replace)
        • Escutcheon - Seatbelt - 2nd Row - LH (6 Seat) (Remove and Replace)
        • Escutcheon - Seatbelt - 2nd Row - LH (Remove and Replace)
        • Escutcheon - Seatbelt - 3rd Row - LH (Remove and Replace)
        • Escutcheon - Seatbelt Anchor - 2nd Row - LH (6 Seat) (Remove and Replace)
        • Height Adjuster - Seat Belt - LH (Remove and Replace)
        • Retractor - Seatbelt - 1st Row - LH (Remove and Replace)
        • Retractor - Seatbelt - 2nd Row - Center (5 Seat) (Remove and Replace)
        • Retractor - Seatbelt - 2nd Row - LH (5 Seat) (Remove and Replace)
        • Retractor - Seatbelt - 2nd Row - RH (5 Seat) (Remove and Replace)
        • Retractor - Seatbelt - 2nd Row - LH (6 Seat) (Remove and Replace)
        • Retractor - Seatbelt - 3rd Row - LH (Remove and Replace)
        • Seatbelt Intermediate Web Guide (Remove and Replace)
      • 2010 - Pre-Tensioners
        • Lap Pretensioner - 1st Row - LH (Remove and Replace)
      • 2020 - Sensors
        • Seatbelt Reminder - 3rd Row - LH (Remove and Replace)
        • Seat Belt Reminder - 2nd Row - LH (6 Seat)(Remove and Replace)
        • Sensor - Crash Accelerometer - Front Bumper (Remove and Replace)
        • Sensor - Impact - B-Pillar - LH (Remove and Replace)
        • Sensor - Impact - C-Pillar - LH (Remove and Replace)
        • Sensor Mat - Occupant Classification System - 1st Row - RH (Remove and Replace)
        • Sensor - Pressure - Door - Front - LH (Remove and Replace)
        • Sensor - Resistive Occupancy - Front Seat - LH (Remove and Replace)
        • Sensor - Pressure Tube (Remove and Replace)
      • 2030 - Pedestrian Protection System
        • Actuator - Pedestrian Protection - LH (EMEA) (Remove and Replace)
        • Cover - Hinge - Active Hood - LH (Remove & Replace)
    • 21 - INFOTAINMENT
      • 2105 - Displays
        • Mechanism - Pivot - Touchscreen (Remove and Replace)
        • Service Panel - Instrument Panel (Remove and Replace)
        • Touchscreen - Rear (Remove and Replace)
        • Touchscreen (HW3) (Remove and Replace)
        • Touchscreen (HW4) (Remove and Replace)
      • 2115 - Car Computer
        • Car Computer (HW3) (Remove and Install)
        • Car Computer (HW4) (Remove and Install)
        • Car Computer (Remove and Replace)
        • Car Computer (Dispose)
        • Connectivity Board - Car Computer (Remove and Replace)
        • SIM Card - Car Computer (Remove & Replace)
        • SIM Card - Car Computer (Info-Ryzen) (Retrofit)
      • 2121 - Audio System - Speakers, Subwoofer, Amplifier
        • Amplifier - Audio - External (Remove and Replace)
        • Speaker - Dash - LH (Remove and Replace)
        • Speaker - Headliner - LH (Remove and Replace)
        • Speaker - Front Door - LH (Remove and Replace)
        • Speaker - Liftgate - LH (Remove and Replace)
        • Speaker - Rear Door - LH (Remove and Replace)
        • Subwoofer (Remove and Replace)
        • Tweeter - Liftgate - LH (Remove and Replace)
        • Tweeter - Rear Door - LH (Remove and Replace)
      • 2122 - Audio System - AM, FM, and HD Radio
        • Tuner - FM / HD / XM (Remove and Replace)
      • 2125 - Audio System - Bluetooth
      • 2126 - Audio System - USB Media Port
        • USB Hub - Center Console - Rear (Remove and Replace)
        • USB Hub - Center Console - Front (Remove and Replace)
      • 2130 - Antenna - AM, FM, and HD Radio
        • Antenna Amplifier - FM (Remove and Replace)
        • Noise Filter - Ground - Antenna (Remove and Replace)
        • Noise Filter - LV - Antenna (Remove and Replace)
      • 2131 - Antenna - Satellite Radio
        • Antenna - Satellite Radio (Remove and Replace)
      • 2132 - Antenna - GPS
        • Antenna - GNSS (Remove and Replace)
      • 2133 - Antenna - Wi-Fi
        • Antenna - MIMO - LH (Remove and Replace)
      • 2135 - Antenna - GSM
    • 30 - CHASSIS
      • 3001 - Chassis and Subframes
        • Shear Plate - Rear Subframe - LH (Remove and Replace)
        • Skidplate - Front (Remove and Replace)
        • Stiffener - Rear Subframe (Remove and Replace)
        • Stiffener - Rear Subframe (Plaid) (Remove and Replace)
        • Subframe Assembly - Front (Remove and Install)
        • Subframe Assembly - Front (Remove and Replace)
        • Subframe Assembly - Rear (Plaid) (Remove and Install)
        • Subframe Assembly - Rear (Plaid) (Remove and Replace)
        • Subframe Assembly - Rear (Remove and Install)
        • Subframe Assembly - Rear (Remove and Replace)
    • 31 - SUSPENSION
      • Torque Specifications - Suspension
      • Alignment Requirement - Suspension
      • 3100 - Adjustment
        • EPAS Alignment Check
        • Four Wheel Alignment Check and Adjust
        • Four Wheel Alignment Check
        • Ride Height (Adjust)
      • 3101 - Front Suspension (including Hubs)
        • Suspension - Front (Torque)
        • Control Arm - Upper - Front - LH (Remove and Replace)
        • Control Arm - Upper - Front - RH (Remove and Replace)
        • Hub - Front - LH (Remove and Replace)
        • Knuckle - Suspension - Front - LH (Remove and Replace)
        • Link - Aft - Lower - Front - LH (Remove and Replace)
        • Link - Fore - Lower - Front - LH (Remove and Replace)
        • Link - Stabilizer Bar - Front - LH (Remove and Replace)
        • Stabilizer Bar - Front (Remove and Replace)
      • 3103 - Rear Suspension (including Hubs)
        • Suspension - Rear (Torque)
        • Hub - Rear - LH (Remove and Replace)
        • Knuckle - Suspension - Rear - LH (Remove and Replace)
        • Link - Aft - Lower - Rear - LH (Remove and Replace)
        • Link - Aft - Upper - Rear - LH (Remove and Replace)
        • Link - Fore - Lower - Rear - LH (Remove and Replace)
        • Link - Fore - Upper - Rear - LH (Remove and Replace)
        • Link - Stabilizer Bar - Rear - LH (Remove and Replace)
        • Stabilizer Bar - Rear (Remove and Replace)
        • Toe Link Assembly - Rear - LH (Remove and Replace)
      • 3110 - Air Suspension System
        • Active Damper - Front - LH (Remove and Replace)
        • Active Damper - Rear - LH (Remove and Replace)
        • Air Line - Compressor to Valve Block - Air Suspension (Remove and Replace)
        • Air Line - Valve Block Intake/Exhaust - Air Suspension (Remove and Replace)
        • Air Suspension - Pressurize / Depressurize - Full System
        • Air Suspension Lines - Rear (Remove and Replace)
        • Air Suspension - Bundle - Front (Remove and Replace)
        • Bracket - Carrier - Compressor - Air Suspension (Remove and Replace)
        • Bracket - Compressor - Air Suspension (Remove and Replace)
        • Compressor - Air Suspension (Remove and Replace)
        • Fill Valve - Air Suspension (Retrofit)
        • Harness - Adaptive Air Spring Module - Front - LH (Remove and Replace)
        • Line - Air Suspension (Repair)
        • Module - Air Suspension - ECU (Tesla) (LHD) (Remove and Replace)
        • Reservoir - Auxiliary - Air Suspension (Remove and Replace)
        • Sensor - Ride Height - Front - LH (Remove and Replace)
        • Sensor - Ride Height - Rear - LH (Remove and Replace)
        • Superbeam (Remove and Replace)
        • Valve Block - Air Suspension (Remove and Replace)
    • 32 - STEERING
      • 3201 - Steering Rack and Lower Column
        • Module - Steering Column Control (Remove and Replace)
        • Steering Rack (Remove and Replace)
      • 3205 - Upper Column, Steering Wheel
        • Shroud - Lower - Steering Column (Remove and Replace)
        • Steering Column (Remove and Replace)
        • Steering Yoke/Wheel (Remove and Replace)
        • Touch Horn Steering Yoke/Wheel To Mechanical Horn Steering Yoke/Wheel (Retrofit)
    • 33 - BRAKES
      • 3301 - Brake Discs and Calipers
        • Brake Caliper - Front - LH (Remove and Replace)
        • Brake Caliper - Rear - LH (Remove and Replace)
        • Brake Pads - Burnishing
        • Brake Pads - Front (Remove and Replace)
        • Brake Pads - Rear (Remove and Replace)
        • Brake Pads and Rotors - Front - Set (Remove and Replace)
        • Brake Pads and Rotors - Rear - Set (Remove and Replace)
        • Brake Rotor - Front - LH (Measure Runout)
        • Brake Rotor - Front - LH (Remove and Replace)
        • Brake Rotor - Rear - LH (Measure Runout)
        • Brake Rotor - Rear - LH (Remove and Replace)
        • Clean And Lubricate Brake Calipers (Integrated Parking Brake)
        • Shield - Dust - Brake - Front - LH (Remove and Replace)
        • Shield - Dust - Brake - Rear - LH (Remove and Replace)
      • 3303 - Brake Pipes and Hoses
        • Brake Bleeder Machine (Flush)
        • Brake Fluid Bleed/Flush (Remove and Replace)
        • Brake Hose - Flexible - Front - LH (Remove and Replace)
        • Brake Hose - Flexible - Rear - LH (Remove and Replace)
        • Brake Lines - HCU to Side Sill (Remove and Replace)
        • Brake Lines - LH Sill (Remove and Replace)
        • Brake Lines - Master Cylinder to ABS (Remove and Replace)
        • Brake Lines - Rear - LH to Sill (Remove and Replace)
        • Brake Lines - Rear - RH to Sill (Remove and Replace)
        • Pipe - Brake Junction to Jounce - LH (Remove and Replace)
        • Pipe - Brake Junction to Jounce - RH (Remove and Replace)
        • Pipe Assembly - Front - Brake (Remove and Replace)
      • 3305 - Parking Brake
        • Park Brake Caliper - Release
        • Park Brake Caliper - Caliper Seized/Motor Failure - Release
      • 3310 - ABS, Traction, and Stability Control
        • Hydraulic Control Unit (HCU) - Brake (Remove and Replace)
        • Sensor - Wheel Speed - ABS - Front - LH (Remove and Replace)
      • 3320 - Electromechanical Brake Booster
        • Electromechanical Brake Booster Assembly (Remove and Replace)
      • 3325 - Brake Pedal
        • Pedal Assembly (Remove and Replace)
        • Pedal Pad - Brake (Remove and Replace)
        • Switch - Brake Light (Remove and Replace)
    • 34 - WHEELS AND TIRES
      • 3401 - Wheels
        • Wheel - Front - LH (Remove and Replace)
        • Wheel Assembly (Remove and Install)
      • 3402 - Tires
        • Replacement Tire Information
        • Tire - Front - LH (Repair)
        • Tire - Front - LH (Remove and Replace)
        • Tire - Front - LH (Road Force) (Balance)
        • Tire Rotation
      • 3404 - Tire Pressure Monitoring System (TPMS)
        • Sensor - TPMS - Front - LH (Remove and Replace)
        • TPMS (Sensor ID Drive Learn)
        • TPMS (Sensor ID Tool Learn)
    • 39 - FRONT DRIVE UNIT
      • 3901 - Front Drive Unit Assembly
        • Drive Unit - Front (Remove and Install)
        • Drive Unit - Front (Remove and Replace)
        • Ground Strap - Front Drive Unit (Remove and Replace)
        • Mount - Bushing Carrier - Front Drive Unit - RH (Remove and Replace)
        • Mount - Front Drive Unit - LH (Remove and Replace)
      • 3920 - Front Inverter
        • Cover - Inverter - Drive Unit - Front (Remove and Replace)
        • Drive Unit Inverter Diode Test
        • Fluid Coupling (55 Degrees) - Front Drive Unit (Remove and Replace)
        • Fluid Coupling (Straight) - Front Drive Unit (Remove and Replace)
        • HV Header - Inverter - Front Drive Unit (Remove and Replace)
        • Inverter - Front Drive Unit (Remove and Replace)
      • 3930 - Front Gearbox and Halfshafts
        • Gearbox Fluid - Front Drive Unit (Drain and Refill)
        • Halfshaft - Front Drive Unit - LH (Remove and Replace)
        • Halfshaft - Front Drive Unit - RH (Remove and Replace)
        • Heat Exchanger - Front Drive Unit (Remove and Replace)
        • Oil Pump - Front Drive Unit (Remove and Replace)
    • 40 - REAR DRIVE UNIT
      • 4001 - Rear Drive Unit Assembly
        • Bushing - Rear Drive Unit - Rear (Remove and Replace
        • Bushing - Rear Drive Unit - RH (Remove and Replace)
        • Drive Unit - Rear (Remove and Install)
        • Drive Unit - Rear (Remove and Replace)
        • Drive Unit - Rear (Plaid) (Remove and Install)
        • Drive Unit - Rear (Plaid) (Remove and Replace)
        • Ground Strap - Rear Drive Unit (Long Range) (Remove and Replace)
        • Ground Strap - Rear Drive Unit (Plaid) (Remove and Replace)
        • Mount - Rear Drive Unit - LH (Remove and Replace)
      • 4010 - Rear Motor
      • 4020 - Rear Inverter
        • Drive Unit Inverter Diode Test
        • Fluid Coupling (55 Degrees) - Rear Drive Unit (Remove and Replace)
        • Fluid Coupling (Straight) - Rear Drive Unit (Remove and Replace)
        • Hose - Inverter to Heat Exchanger - Rear Drive Unit (Remove and Replace)
        • Hose - Inverter to Heat Exchanger - Rear Drive Unit - LH (Plaid) (Remove and Replace)
        • Hose - Inverter to Heat Exchanger - Rear Drive Unit - RH (Plaid) (Remove & Replace)
        • Inverter Air Leak Test (In Vehicle)
        • Inverter Air Leak Test (On Table)
        • Inverter - LH - Rear Drive Unit (Plaid) (Remove and Replace)
        • Inverter - Rear Drive Unit (Remove and Replace)
      • 4030 - Rear Gearbox and Halfshafts
        • Breather - Rear Drive Unit (Remove and Replace)
        • Breather - Rear Drive Unit (Plaid) (Remove and Replace)
        • Gearbox Fluid - Rear Drive Unit (Drain and Refill)
        • Gearbox Fluid - Rear Drive Unit (Plaid) (Drain and Refill)
        • Halfshaft - Rear Drive Unit - LH (Remove and Replace)
        • Heat Exchanger - Rear Drive Unit - LH (Plaid) (Remove and Replace)
        • Heat Exchanger - Rear Drive Unit (Long Range) (Remove and Replace)
        • Oil Pump - LH - Rear Drive Unit (Plaid) (Manual Drain) (Remove and Replace)
        • Oil Pump - LH - Rear Drive Unit (Plaid) (Remove and Replace)
        • Oil Pump - Rear - Rear Drive Unit (Plaid) (Remove and Replace)
        • Oil Pump - Rear Drive Unit (Long Range) (Remove and Replace)
        • Seal - Axle - Rear Drive Unit - LH (Remove and Replace)
        • Seal - Axle - Rear Drive Unit - LH (Plaid) (Remove and Replace)
    • 44 - HIGH VOLTAGE SYSTEM
      • 4400 - High Voltage Testing
        • Isolation/Insulation Test
        • Vehicle HV Disablement Procedure
      • 4401 - Charge System Inlet
        • Busbars - Charge Port to HV Battery (EMEA) (Remove and Replace)
        • Busbars - Charge Port to HV Battery (GB) (Remove & Replace)
        • Busbars - Charge Port to HV Battery (Remove and Replace)
        • Charge Port (China) (Remove and Replace)
        • Charge Port (EMEA) (Remove and Replace)
        • Charge Port (Remove and Replace)
        • Charge Port Voltage Check
        • Connector - DC Input - Busbar - Charge Port to HV Battery (Remove and Replace)
        • Door Panel - Charge Port (Remove and Replace)
        • Door Assembly - Charge Port (NA) (Remove and Replace)
        • Door Assembly - Charge Port (Global) (Remove and Replace)
        • Door - Charge Port (Global) (Adjust)
        • ECU - Charge Port (Remove and Replace)
        • Safety Cap - Busbar - Charge Port to HV Battery (Remove and Replace)
        • Seal - Door - Charge Port (Retrofit)
      • 4450 - HV Harnesses
        • AC Cable - Charge Port to HV Battery (3-Phase) (Remove and Replace)
        • HV Harness - HV Battery To A/C Compressor (Remove and Replace)
        • HV Harness - HV Battery to Front Drive Unit (Remove and Replace)
        • HV Harness - HV Battery to Rear Drive Unit (Remove and Replace)
        • HV Harness - HV Battery to Rear Drive Unit - LH (Plaid) (Remove and Replace)
    • 50 - EXTERNAL CHARGING CONNECTORS
      • 5001 - Mobile Connector
        • Firmware Update - Mobile Connector
        • Remove Stuck Deadfront - Charge Handle
      • 5002 - Wall Connector
      • 5003 - Charging Adapters
        • Firmware Update - CHAdeMO Charging Adapter
    • © Tesla 2024
    • Procedure Feedback
    • Site Feedback

    Crowsfoot or Offset Wrench Extension Calculator

    Torque Calculator Values
    Note
    1. If the angle from the extension to the torque wrench is greater than 90° (Figure 2), input E as a positive number.
    2. If the angle from the extension to the torque wrench is less than 90° (Figure 3), input E as a negative number.
    3. If the angle from the extension to the torque wrench is exactly 90°, this calculator is not needed. Torque the fastener to T1.
    Figure 1
    Figure 2
    Figure 3