05/10/2022 15:11:56

Window Regulator - Rear - LH (Remove and Replace)

Correction code 11502202 0.90 NOTE: Unless otherwise explicitly stated in the procedure, the above correction code and FRT reflect all of the work required to perform this procedure, including the linked procedures. Do not stack correction codes unless explicitly told to do so. NOTE: See Flat Rate Times to learn more about FRTs and how they are created. To provide feedback on FRT values, email LaborTimeFeedback@tesla.com. NOTE: See Personal Protection to make sure proper PPE is worn when performing the below procedure.

Remove

  1. Open the LH front door and lower the front windows.
  2. Remove the LH rear door glass. See Door Glass - Rear - LH (Remove and Replace).
  3. Remove the LH rear door speaker. See Speaker - Rear Door - LH (Remove and Replace).
  4. Disconnect the LH rear door window motor electrical connector.
  5. Remove the nuts (x4) that attach the LH rear window regulator to the door assembly.
    10 Nm (7.4 lbs-ft)
    Tip: Use of the following tool(s) is recommended:
    • 10 mm socket
  6. Push the regulator outboard so that the studs no longer protrude through the door shell, push the 2 beams of the regulator together, and then remove the window motor/regulator assembly from the LH rear door.
    Informational PurposesAn informational icon, calling your attention
    Note
    Do not allow the washers to fall off the studs on the regulator.

Install

  1. Position the regulator inside the LH rear door, and then push the 2 beams together and ensure the studs protrude through the door openings.
    Informational PurposesAn informational icon, calling your attention
    Note
    Do not allow the washers to fall off the studs on the regulator.
  2. Install the nuts (x4) that attach the LH rear window regulator to the door assembly.
    10 Nm (7.4 lbs-ft)
    Tip: Use of the following tool(s) is recommended:
    • 10 mm socket
  3. Connect the LH rear door window motor electrical connector.
  4. Install the LH rear door speaker but do not install the door trim panel yet. See Speaker - Rear Door - LH (Remove and Replace).
  5. Install the LH rear door glass. See Door Glass - Rear - LH (Remove and Replace).
  6. Raise the front windows and close the LH front door.