2017–2023 Model 3 Service Manual

    Introduction

    Related links

    • Abbreviations and Symbols
    • Flat Rate Times
    • How to Use this Manual
    • Mobile Service Indicator
    • Repairs and Replacements
    • Warranty Service Regions
    Parent topic: General Information
    • Model 3 Service Manual
    • Release Notes
    • General Information
      • Introduction
        • Abbreviations and Symbols
        • Flat Rate Times
        • How to Use this Manual
        • Mobile Service Indicator
        • Repairs and Replacements
        • Warranty Service Regions
      • Best Practices
        • Airbag and Supplementary Restraint System (SRS) Component Replacement Policy
        • Airbag and Supplementary Restraint System (SRS) Precautions
        • Air Conditioning System Precautions
        • Consumable Parts
        • Diagnostic Connector Location
        • Electrical Precautions
        • Environmental Precautions
        • Ergonomic Precautions
        • Event Data Recorder Retrieval
        • Flexible Pipes and Hoses
        • General Fitting Instructions
        • General Precautions
        • Locking Devices
        • Multimeter (LoZ Setting)
        • Oil Seals
        • Personal Protection
        • Pre-Installation Glass Inspection
        • Vehicle Cameras and Autopilot
        • Wheels and Tires
          • Wheel Disposal (Rework)
      • Charging
        • General
      • Technical Data
        • Brakes
        • Electrical
        • Fuse Locations
        • Suspension and Steering
        • Tire Pressures
        • Wheel Alignment
        • Wheels
      • Identification Numbers
        • Vehicle Identification Number (VIN)
        • Serial Numbers
        • Drive Unit Number
        • Manufacturing Certification Label
        • Vehicle and Wheel Paint Codes
        • Type Approval (EU)
      • Fluids and Capacities
    • 00 - Inspection and Service
      • 0001 - Maintenance Service
        • Maintenance Service Intervals
        • Vehicle Health Check
      • 0002 - Firmware Service
        • Software Reinstall - Touchscreen
        • Software Reinstall - Toolbox
        • Software Update
        • User Data (Factory Reset)
      • 0005 - Service Modes
        • Gateway Configuration (Display and Change)
        • Gateway (Unlock)
        • How to Read Diagnostic Trouble Codes (DTCs) in Service Mode
        • Service Mode
        • Service Mode Plus
        • Toolbox (Connect and Disconnect)
      • 0006 - Periodic Roadworthiness Inspections
        • Ball Joints (Inspect)
        • Disabling PIN to Drive
        • Electronic Parking Brake (EPB) (Test)
        • Headlights and Fog Lights (Check Aiming)
        • Keeping the Vehicle in Neutral
        • Lifting the Vehicle
        • On-Board Diagnostics (OBD) Connector
        • Steering Column - Inspect for Lateral Play (Inspection)
        • Vehicle Identification Number (VIN)
    • 10 - Body
      • Torque Specifications - Body
      • 1000 - Vehicle Lifting
        • Raise Vehicle - 2 Post Lift
        • Raise Vehicle - 4 Post Lift
        • Raise Vehicle - Floor Jack (Mobile Service)
      • 1001 - Bumper / Fascia
        • Ankle Catcher (Remove and Replace)
        • Bracket - Fascia Center To Fender - LH (Remove and Replace)
        • Bracket - Fascia Side to Fender - LH (Remove and Replace)
        • Bracket - Rear - Center (Remove and Replace)
        • Bracket - Rear Wing - LH (Remove and Replace)
        • Bracket - Taillight - LH (Remove and Replace)
        • Bumper Beam - Front (Remove and Replace)
        • Bumper Beam - Rear (Remove and Replace)
        • Extrusion - Bumper Beam - Active Hood- Front (Remove and Replace)
        • Cover - Tow Hook - Front (Remove and Install)
        • Crush Can - Upper - Front - LH (Remove and Replace)
        • Fascia - Front (Remove and Install)
        • Fascia - Front (Remove and Replace)
        • Fascia - Rear (Remove and Install)
        • Fascia - Rear - Lower (Remove and Replace)
        • Fascia - Rear - Upper (Remove and Replace)
        • Foam - Bumper Beam - Front (Remove and Replace)
        • Grille - Fascia - Front (Remove and Replace)
        • Liner Stiffener- Front Wheel House - LH (Remove and Replace)
        • Reinforcement - Front Fascia - LH (Remove and Replace)
        • Tow Hook - Front (Remove and Replace)
        • Trailer Hitch - Rear Energy Absorber (Retrofit)
        • Valance - Front Fascia (Remove and Replace)
      • 1010 - Body Panels
        • Body Reinforcement - Floor - 2nd Row (Remove and Replace)
        • Brace - Shock Tower (Non-Heat Pump) (Remove and Replace)
        • Brace - Shock Tower (Heat Pump) (Remove and Replace)
        • Carrier - Front End (Non-Heat Pump) (Remove and Replace)
        • Carrier - Front End (Heat Pump) (Remove and Replace)
        • Crush Can - Front Subframe - LH (Remove and Replace)
        • Door - Front - LH (Remove and Install)
        • Door - Front - LH (Remove and Replace)
        • Check Strap - Door - Front - LH (Remove and Replace)
        • Check Strap - Door - Rear - LH (Remove and Replace)
        • Door - Rear - LH (Remove and Install)
        • Door - Rear - LH (Remove and Replace)
        • Fender Assembly - Front - LH (Remove and Install)
        • Fender Assembly - Front - LH (Remove and Replace)
        • Fender Support - Front - LH (Remove and Replace)
        • Hood (Remove and Install)
        • Hood (Remove and Replace)
        • Power Trunk (Remove and Install)
        • Power Trunk (Remove and Replace)
        • Stud - Bump Stop - Lamp Can - LH (Repair)
        • Stud - Bump Stop - Lamp Can - Pair (Repair)
        • Trunk (Remove and Install)
        • Trunk (Remove and Replace)
      • 1020 - Windshield and Body Glass
        • Clean Forward Camera View (Precision Cleaning of Inboard Glass)
        • Glass - Backlight (Heat Pump Model) (Remove and Replace)
        • Glass - Backlight (Heat Pump) (Remove and Install)
        • Glass - Backlight (Non-Heat Pump) (Remove and Install)
        • Glass - Backlight (Non-Heat Pump) (Remove and Replace)
        • Glass - Body - Rear Quarter - LH (Remove and Install)
        • Glass - Body - Rear Quarter - LH (Remove and Replace)
        • Glass - Roof - Fixed (Remove and Replace)
        • Seal - Trunk Flip - Backlight (Remove and Replace)
        • Sensor - Relative Humidity and Temperature (Remove and Install)
        • Sensor - Relative Humidity and Temperature (Remove and Replace)
        • Windshield and Roof Glass Repair and Replacement Guidelines
        • Windshield Chip Repair
        • Windshield Chip Repair (EMEA)
        • Windshield Scratch Repair
        • Windshield (Reuse Humidity and Temperature Sensor) (Remove and Replace)
        • Windshield (Vehicles with 2nd Generation or Later Autopilot) (Remove and Replace)
      • 1030 - Paint
        • Paint Defect Rectification
      • Panel Alignment
        • Fender Alignment
        • Front Door Alignment
        • Hood Alignment
        • Trunk Alignment
        • Panel Alignment Specifications
    • 11 - Closures
      • Torque Specifications - Closures
      • 1133 - Closure Assist Mechanisms and Hinges
        • Bracket - Active Hood Strut - LH (Remove and Replace)
        • Bracket - Passive Hood Strut - LH (Remove and Replace)
        • C-Clips - Strut - Hood - LH (Remove and Replace)
        • C-Clips - Strut - Trunk - LH (Remove and Replace)
        • Gas Strut - Hood - LH (Remove and Replace)
        • Gas Strut - Trunk - LH (Remove and Replace)
        • Hinge - Door - Front - Lower - LH (Remove and Replace)
        • Hinge - Door - Front - Upper - LH (Remove and Replace)
        • Hinge - Rear Door - Upper - LH (Remove & Replace)
        • Hinge - Door - Rear - Lower - LH (Remove and Replace)
        • Hinge - Hood - LH (Remove and Replace)
        • Hinge - Power Trunk - LH (Remove and Replace)
        • Hinge - Trunk - LH (Remove and Replace)
        • Power Strut - Trunk (Remove and Replace)
        • Stop - Trunk - LH (Remove and Replace)
        • Strut Reinforcement - Hood - LH (Remove and Replace)
      • 1135 - Latches Strikers and Pinch Sensors
        • Actuator - Latch - Hood - Primary (Remove and Replace)
        • Actuator - Latch - Hood - Secondary (Remove and Replace)
        • Actuator - Latch - Hood (Single Actuator System) (Remove and Replace)
        • Latch - Cinch - Trunk (Remove and Replace)
        • Latch - Door - Front - LH (Remove and Replace)
        • Latch - Door - Rear - LH (Remove and Replace)
        • Latch - Hood (Remove and Replace)
        • Latch - Hood (Single Actuator System) (Remove and Replace)
        • Latch - Trunk (Remove and Replace)
        • Manual Release - Door - Rear - LH (Actuate)
        • Striker - Door - Front - LH (Remove and Replace)
        • Striker - Door - Rear - LH (Remove and Replace)
        • Striker - Hood (Remove and Replace)
        • Striker - Trunk (Remove and Replace)
        • Switch and Camera Assembly - Exterior Release - Trunk (Remove and Replace)
        • Switch - Power Trunk - Interior (Remove and Replace)
        • Switch - Trunk - Exterior (Remove and Replace)
      • 1145 - Exterior Door Handles
        • Apply WD-40 to Door Handle Pivot Pins (Maintenance)
        • Hall Sensor - Exterior Release - Door - Front - LH (Remove and Replace)
        • Hall Sensor - Exterior Release - Door - Rear - LH (Remove and Replace)
        • Handle - Exterior Release - Door - Front - LH (Remove and Replace)
        • Handle - Exterior Release - Door - Rear - LH (Remove and Replace)
      • 1150 - Door Glass and Regulators
        • Glass - Door - LH - Front (Adjust)
        • Glass - Door - LH - Front (Remove and Replace)
        • Glass - Door - LH - Rear (Adjust)
        • Glass - Door - LH - Rear (Remove and Replace)
        • Switch - Window - Driver (Remove and Replace)
        • Switch - Window - Front Passenger (Remove and Replace)
        • Switch - Window - Rear (Remove and Replace)
        • Window Motor / Regulator Assembly - Front - LH (Remove and Replace)
        • Window Regulator - Rear - LH (Remove and Replace)
        • Window Regulator (Recalibrate)
      • 1170 - Seals Body Closures
        • Closeout Panel - Door - Front - LH (Remove and Replace)
        • Seal - Check Strap - Front Door - LH (Remove and Replace)
        • Seal - Body - Side - Front - Primary - LH (Remove and Replace)
        • Seal - Body - Side - Rear - Primary - LH (Remove and Replace)
        • Seal - Glass Run - Front Door - LH (Remove and Replace)
        • Seal - Hood (Remove and Replace)
        • Seal - Inner Belt - Front Door - LH (Remove and Replace)
        • Seal - Inner Belt - Rear Door - LH (Remove and Replace)
        • Seal - Outer Belt - Front Door - LH (Remove and Replace)
        • Seal - Outer Belt - Front Door - LH (Adjust)
        • Seal - Outer Belt - Rear Door - LH (Remove and Replace)
        • Seal - Outer Belt - Rear Door - LH (Adjust)
        • Seal - Secondary - Front Door - LH (Remove and Replace)
        • Seal - Secondary - Rear Door - LH (Remove and Replace)
        • Seal - Trunk (Remove and Replace)
    • 12 - Exterior Fittings
      • Torque Specifications - Exterior Fittings
      • 1201 - Wheel Arch Liners
        • Noise Absorber - Motor Bay - Front (Remove and Replace)
        • Wheel Arch Liner - Front - LH (Remove and Replace)
        • Wheel Arch Liner - Rear - LH (Remove and Replace)
      • 1203 - Undertray and Diffuser
        • Diffuser - Rear Fascia (Remove and Replace)
        • Panel - Aero Shield - Front (Remove and Replace)
        • Panel - Aero Shield - Rear (Remove and Replace)
      • 1205 - Badges and Films
        • Paint Protection Film - Rocker Panels (Retrofit)
        • Rear Lettering (Retrofit)
        • Sill Plate - Front - LH (Remove and Replace)
        • Tesla Badge - Front (Remove and Replace)
        • Tesla Badge - Rear (Remove and Replace)
        • Badge - Rear - LH (Remove and Replace) (China)
      • 1207 - License Plate Mountings
        • Bracket - License Plate - Front (EMEA) (Retrofit using Jig)
        • Bracket - License Plate - Front (EMEA) (Retrofit using Template)
        • Bracket - License Plate - Front (Remove and Replace)
        • Bracket - License Plate - Front (Retrofit)
        • Bracket - License Plate - Rear (EMEA) (Remove and Replace)
      • 1209 - Exterior Mirrors
        • Glass - Door Mirror - LH (Remove and Replace)
        • Mirror - Door - LH (Remove and Replace)
        • Skull Cap - Door Mirror - LH (Remove and Replace)
      • 1220 - Exterior Trim
        • Applique - A-Pillar - Mirror - Door - LH (Remove and Replace)
        • Applique - B-Pillar - LH (Remove and Replace)
        • Brightwork - Quarter Panel - LH (Remove and Replace)
        • Brightwork - Upper - LH (Remove and Replace)
        • Cover - Applique - B-Pillar - LH (Remove and Replace)
        • Cover - Rocker Panel - Lower - LH (Remove and Replace)
        • Mud Flaps (Retrofit)
        • Mud Flap - LH (Remove and Replace)
        • Splash Guards (Retrofit)
        • Splash Guard - LH (Remove and Replace)
      • 1222 - Spoiler
        • Spoiler - Rear (Remove and Install)
        • Spoiler - Rear (Remove and Replace)
        • Spoiler - Rear (Retrofit using Jig)
        • Spoiler - Rear (Retrofit using Tape)
      • 1225 - Underhood Trim
        • Carrier Bracket - Cowl Screen - LH (Remove & Replace)
        • Cover - Shock Tower - LH (Remove and Replace)
        • Panel - Cowl Screen (Remove and Replace)
        • Panel - Cowl Screen (Remove and Replace) (RHD)
        • Underhood Apron - Rear (Remove and Replace)
      • 1230 - Trailer Hitch
        • Assembly - Trailer Hitch (Remove and Replace)
        • Ball Neck - Trailer Hitch (Remove and Replace)
        • Cover – Trailer Hitch (Remove and Replace)
        • ECU – Trailer Hitch (Remove and Replace)
      • 1240 - Roof Rack
        • Roof Rack (Remove)
        • Roof Rack (Install)
    • 13 - Seats
      • Torque Specifications - Seats
      • 1301 - Front Seat Tracks and Motors
        • Button - Cushion Adjust - Driver Seat (Remove and Replace)
        • Cover - Front - Seat Track - 1st Row Seat (Remove and Replace)
        • Cover - Rear - Seat Track - 1st Row Seat (Remove and Replace)
        • Frame - Seat Cushion - Driver Seat (Remove and Replace)
        • Frame - Seat Cushion - Front Passenger Seat (Remove and Replace)
        • Module - ECU - Occupant Classification System (OCS) - Front Passenger (Remove and Replace)
        • Motor - Recliner - Backrest - Driver Seat (Remove and Replace)
        • Motor - Seat Height - Driver Seat (Remove and Replace)
        • Motor - Seat Track - Driver Seat (Remove and Replace)
        • Motor - Seat Track - Front Passenger Seat (Remove and Replace)
        • Motor - Seat Tilt - Driver Seat (Remove and Replace)
        • Motor - Seat Tilt - Front Passenger Seat (Remove and Replace)
        • Recline Button - Switch - Driver Seat (Remove and Replace)
        • Seat Track Assembly - 1st Row - RH (Remove and Replace)
        • Switch - Back Rest and Cushion Adjust - Front Passenger Seat (Rework)
        • Switch - Back Rest and Cushion Adjust - Driver Seat (Remove and Replace)
        • Track - Inner - Front Passenger Seat (Remove and Replace)
        • Track - Outer - Front Passenger Seat (Remove and Replace)
      • 1304 - Front Seat Assemblies and Hardware
        • Frame - Back Rest - Front Passenger Seat (Remove and Replace)
        • Lumbar Support - Backrest - Driver Seat (Remove and Replace)
        • Lumbar Support - Back Rest - Front Passenger Seat (Remove and Replace)
        • Post Guide - Headrest - Front Passenger Seat (Remove and Replace)
        • Shell - Seat Back - Driver (Remove and Replace)
        • Seat Assembly - 1st Row - LH (Remove and Replace)
        • Trim - Headrest - Driver (Remove and Replace)
      • 1305 - 2nd Row Seat Assemblies and Hardware
        • Adjustment Guide - Headrest - 2nd Row (Remove and Replace)
        • Armrest - 2nd Row (Remove and Replace)
        • Bezel - Handle - Seat Back - 2nd Row - LH (Remove and Replace)
        • Bolster - Side - Seat - 2nd Row - LH (Remove and Replace)
        • Bracket - Edge Support - Seat Cushion - 2nd Row - LH (Remove and Replace)
        • Bracket - Hinge - Seat Back - 2nd Row - LH (Remove and Replace)
        • Cap - 12V - Ancillary Bay (Remove and Replace)
        • Cap - HV - Ancillary Bay (Remove and Replace)
        • Clip - Seat Cushion- Lower- 2nd Row -LH (Remove and Replace)
        • Closeout - Armrest - 2nd Row (Remove and Replace)
        • Frame - Seat Back - 2nd Row - LH (Remove and Replace)
        • Guide Lock - Headrest - 2nd Row (Remove and Replace)
        • Handle - Seat Back - 2nd Row - LH (Remove and Replace)
        • Headrest - 2nd Row - Center (Remove and Replace)
        • Latch - Seat Back - 2nd Row - LH (Remove and Replace)
        • Pivot Sleeve - Seat Back - 2nd Row - LH (Remove and Replace)
        • Rail - 2nd Row - Inner - LH (Remove and Replace)
        • Rail - 2nd Row - Outer - LH (Remove and Replace)
        • Seat Back - 2nd Row - LH (Remove and Replace)
        • Seat Back - 2nd Row - RH (Remove and Replace)
        • Seat Cushion - Lower - 2nd Row (Remove and Replace)
        • Striker - Seat Back - 2nd Row - LH (Remove and Replace)
        • Striker - Seat Back - 2nd Row - RH (Remove and Replace)
      • 1307 - Front Seat Covers Pads and Trims
        • Cover - Back Rest - Driver (With Inboard Airbag) (Remove and Replace)
        • Side Shield - Outboard - Driver Seat (Remove and Replace)
        • Foam - Backrest - Driver Seat (Remove and Replace)
        • Foam - Backrest - Driver Seat (With Inboard Airbag) (Remove and Replace)
        • Foam - Cushion - Driver Seat (Remove and Replace)
        • Foam - Cushion - Front Passenger Seat (Remove and Replace)
        • Side Shield - Inboard - Driver Seat (Remove and Replace)
        • Suspension - Seat Cushion - Driver Seat (Remove and Replace)
        • Trim - Cushion - Driver Seat (Remove and Replace)
        • Trim - Seat Back - Driver Seat (Remove and Replace)
      • 1308 - 2nd Row Seat Covers Pads and Trims
        • Cover - Seat Back - 2nd Row - LH (Remove and Replace)
        • Cover - Seat Back - 2nd Row Seat - RH (Remove and Replace)
        • Cup Holder - 2nd Row (Remove and Replace)
    • 14 - Instrument Panel
      • Torque Specifications - Instrument Panel
      • 1405 - Instrument Panel
        • Beam - Cross Car (LHD) (Remove and Replace)
        • Beam - Cross Car (RHD) (Remove and Replace)
        • Cover - Airbag - Knee - Driver (Remove and Replace)
        • Cover - Airbag - Knee - Front Passenger (Remove and Replace)
        • Cover - Footwell - Driver (Remove and Replace)
        • Cover - Footwell - Passenger (LHD) (Remove and Replace)
        • Cover - Footwell - Passenger (RHD) (Remove and Replace)
        • Damper - Glove Box (Remove and Replace)
        • Decor Trim - Instrument Panel - Main (Remove and Replace)
        • Decor Trim - Instrument Panel - Main (Rework)
        • Defrost Cover - Instrument Panel - LH (Remove and Replace)
        • End Cap - Air Wave - LH (Remove and Replace)
        • End Cap - Instrument Panel - LH (Remove and Replace)
        • Finisher - Vent (Remove and Replace)
        • Gap Hider - Steering Column - Lower (Remove and Replace)
        • Gap Hider - Steering Column - Upper (Remove and Replace)
        • Glove Box - With Knee Airbags (Non-Heat Pump) (Remove and Replace)
        • Glove Box - With Knee Airbags (Heat Pump) (Remove and Replace)
        • Glove Box - Without Knee Airbags (Remove and Replace)
        • Grille - Speaker - Instrument Panel (Remove and Replace)
        • Glove Box - Without Knee Airbags (Remove and Replace) (RHD)
        • Housing - Center Display (Remove and Replace)
        • IP Carrier (Remove and Install)
        • IP Carrier (LHD) (Remove and Replace)
        • IP Carrier (RHD) (Remove and Replace)
        • NVH Pad - Glove Box (Remove and Replace)
        • Vent - Front - LH (Remove and Replace)
        • Vent - Front - RH (Remove and Replace)
        • Shroud - Upper - Steering Column (Remove and Replace)
        • Solenoid - Glove Box (Remove and Replace)
    • 15 - Interior Trim
      • Torque Specifications - Interior Trim
      • 1505 - Interior Mirror and Sun Visors
        • Bezel - Rear View Mirror (Remove and Replace)
        • Check Base - Sun Visor - LH (Remove and Replace)
        • Glare Shield (Remove and Replace)
        • Mirror - Rear View (Remove and Replace)
        • Quad Camera Cover - Lower (Remove and Replace)
        • Quad Camera Cover - Upper (Remove and Replace)
        • Sun Visor - LH (Remove and Replace)
      • 1511 - Trunk Trim
        • Cover - Latch - Power Trunk (Remove and Replace)
        • Garnish - Trunk (Remove and Replace)
        • Trim - Lid - Power Trunk (Remove and Replace)
        • Trim - Lid - Trunk (Remove and Replace)
      • 1513 - Door Trim
        • NVH Pad - Door - Front - LH (Remove and Replace)
        • NVH Pad - Door - Rear - LH (Remove and Replace)
        • Panel - Door Trim - Front - LH (Remove and Install)
        • Panel - Door Trim - Front - LH (Remove and Replace)
        • Panel - Door Trim - Rear - LH (Remove and Install)
        • Panel - Door Trim - Rear - LH (Remove and Replace)
        • Decor - Trim - Front Door - LH (Remove and Replace)
        • Reflector - Door - Front - LH (Remove and Replace)
        • Switch - Interior Door Release - Front - LH (Remove and Replace)
        • Switch - Interior Door Release - Rear - LH (Remove and Replace)
      • 1518 - Pillar and Sill Trim
        • Trim - A-Pillar - Lower - LH (Remove and Replace)
        • Trim - A-Pillar - Middle - LH (Remove and Replace)
        • Trim - A-Pillar - Upper - LH (Remove and Replace)
        • Trim - B-Pillar - Lower - LH (Remove and Replace)
        • Trim - B-Pillar - Upper - LH (Remove and Replace)
        • Trim - C-Pillar - Rear - LH (Remove and Replace)
        • Trim - C-Pillar - Upper - LH (Remove and Replace)
        • Trim - Side Rail - LH (Remove and Install)
        • Trim - Side Rail - LH (Remove and Replace)
        • Trim - Sill Panel - Rear - LH (Remove and Replace)
      • 1519 - Center Console
        • Armrest - Center Console (Remove and Replace)
        • Assembly - Rear Vent - Center Console (Remove and Replace)
        • Brightwork - Center Console (2.0) (Remove and Replace)
        • Center Console (Remove and Install)
        • Center Console (Remove and Replace)
        • Center Console (2.0) (Remove and Install)
        • Center Console (2.0) (Remove and Replace)
        • Cup Holder (Remove and Replace)
        • Decor Trim - Center Console - LH (Remove and Replace)
        • Decor Trim - Cup Holder - Center Console (Remove and Replace)
        • End Panel - Center Console (Remove and Replace)
        • H-Decor Trim - Center Console (2.0) (Remove and Replace)
        • Insert - Front Bin - Center Console (Remove and Replace)
        • Module - Inductive Charger - Center Console (2.0) (Remove and Replace)
        • Panel - Lower Rear - Center Console (Remove and Replace)
        • Phone Tray - Center Console (Remove and Replace)
        • Side Panel - Center Console - LH (Remove and Replace)
        • Sliding Lid - Center Console (Remove and Replace)
      • 1520 - Headliner
        • Coat Hook - Rear - LH (1 Piece Headliner) (Remove and Replace)
        • Headliner (Heat Pump) (Remove and Install)
        • Headliner (Heat Pump) (Remove and Replace)
        • Headliner (Non-Heat Pump) (Remove and Install)
        • Headliner (Non-Heat Pump) (Remove and Replace)
        • Headliner (without e-Call Button) (EMEA) (Retrofit)
        • Overhead Console - Front (Remove and Replace)
        • Overhead Console - Front (without e-Call Button) (EMEA) (Retrofit)
        • Overhead Console - Rear (Remove and Replace)
        • Visor Check Cover - Headliner - LH (Remove and Replace)
      • 1524 - Luggage Compartment Trim
        • Bag Holder Hook - Underhood Storage Unit - LH (Remove and Replace)
        • Cover - Hood Latch (Remove and Replace)
        • Flip Door - Tether Anchor - LH (Remove and Replace)
        • Reinforcement Bracket - Underhood Storage Unit (Remove and Replace)
        • Switch - Child Safety - Underhood Storage Area (Remove and Replace)
        • Trim - Floor - Trunk (Remove and Replace)
        • Trim - Side - Trunk - LH (Remove and Replace)
        • Trim - Side - Trunk - RH (Remove and Replace)
        • Trim - Sill - Trunk (Remove and Replace)
        • Trim - Package Tray (Remove and Replace)
        • Underhood Storage Unit (Remove and Replace)
      • 1530 - Carpeting and Mats
        • Carpet - Front - LH (Remove and Replace)
        • Carpet - Front - RH (Remove and Replace)
        • Carpet - Interior Complete (Remove and Replace)
        • Carpet - Rear (Remove and Replace)
        • Carpet - Underhood Storage (Remove and Install)
        • Carpet - Rear Trunk (1-Piece) (Remove and Replace)
        • Front Carpet - Trunk (2-Piece) (Remove and Replace)
        • Rear Carpet - Trunk (2-Piece) (Remove and Replace)
    • 16 - Battery System
      • Torque Specifications - Battery System
      • 1601 - HV Battery Assembly
        • HV Battery (AWD) (Remove and Install)
        • HV Battery (AWD) (Remove and Replace)
        • HV Battery (RWD) (Remove and Install)
        • HV Battery (RWD) (Remove and Replace)
      • 1610 - HV Battery Enclosure
        • Ancillary Bay Air Leak Test
        • Bracket - Skid Plate - Front - HV Battery (Remove and Replace)
        • Breathers - HV Battery (Remove and Replace)
        • Cover - Ancillary Bay (Remove and Install)
        • Cover - Ancillary Bay (Remove and Replace)
        • Cover - HV Probe - HV Battery (Remove and Replace)
        • Flood Ports - 2nd Generation (Remove and Replace)
        • Flood Ports - 2nd Generation (Retrofit)
        • HV Battery Air Leak Test
        • NVH Pads - HV Battery (Install)
        • Platter Enclosure Air Leak Test
        • Seal - Perimeter - HV Battery (Remove and Replace)
        • Ski - Center Rail - HV Battery (RWD) (Remove and Replace)
        • Ski - Center Rail - HV Battery (Dual Motor) (Remove and Replace)
        • Skid Plate - HV Battery - Front (Remove and Replace)
        • Skid Plate - HV Battery - Rear (Remove and Replace)
        • Vent Assembly - HV Battery - LH (Remove and Replace)
        • Vent Assembly - HV Battery - RH (Remove and Replace)
        • Vent Assembly - HV Battery - Pair (Remove and Replace)
      • 1620 - HV Battery Cooling System
        • Ancillary Bay Coolant (Drain and Refill)
        • Ancillary Bay Coolant Leak Test
        • Coolant - HV Battery (Drain and Refill)
        • Platter Enclosure Coolant (Drain and Refill)
        • Platter Enclosure Coolant Leak Test
        • Tube - Input - Coolant - Power Conversion System (Remove and Replace)
        • Tube - Output - Coolant - Power Conversion System (Remove and Replace)
      • 1630 - HV Battery Electrical Components
        • Busbar DC Input to Harness DC Input (Retrofit)
        • Contactor - Fast Charge - HV Battery (Remove and Replace)
        • Contactor - Negative - HV Battery (Remove and Replace)
        • Contactor - Positive - HV Battery (Remove and Replace)
        • Controller - High Voltage (Backup and Restore)
        • Controller - High Voltage (Remove and Install)
        • Controller - High Voltage (Remove and Replace)
        • DC Input Assembly - HV Battery (Busbar Type) (Remove and Replace)
        • DC Input Assembly - HV Battery (Harness Type) (Remove and Replace)
        • Fuse - Ancillary Bay (Remove and Replace)
        • Fuse - Cabin Heater - HV Battery (Battery On Table) (Install)
        • Guide - Probing - HV Battery (Remove and Replace)
        • Guide - Probing - HV Battery (Retrofit)
        • Harness - AC Inlet - HV Battery (Remove and Replace)
        • Harness - Ancillary Bay - HV Battery (Remove and Replace)
        • Hinge Tray - High Voltage Controller(Retrofit)
        • HV Battery Contactor Seize Check
        • HV Header - PTC Heater and A/C Compressor - HV Battery (Remove and Replace)
        • HV Header - Rear Drive Unit - HV Battery (Remove and Replace)
        • Insulators - HV Battery (Install and Remove)
        • Passthrough - DCDC - 12V (Busbar Type) (Remove and Replace)
        • Passthrough - DCDC - 12V (Cable Type) (Remove and Replace)
        • Power Conversion System (Remove and Install)
        • Power Conversion System (Remove and Replace)
        • Pyrotechnic Battery Disconnect (Remove and Replace)
        • Resistance Meter (Zero Adjust)
        • Seal - Probe Lid - HV Battery (Remove and Replace)
        • Shunt - HV Battery (Remove and Replace)
      • HV Battery Replacement - Add-On Procedures
        • Charge Port Components (Harness Type to Busbar Type) (Retrofit)
        • Controller - High Voltage (Rework) (Battery On Table)
        • Cover - Ancillary Bay (Rework) (Battery On Table)
        • Cover - Ancillary Bay (Swap) (Battery On Table)
        • PTC Heater Electronics (Retrofit)
        • Pyrotechnic Battery Disconnect (Remove and Install) (Battery On Table)
    • 17 - Electrical
      • Torque Specifications - Electrical
      • 1701 - 12V Battery and Fuses
        • 12V/LV Power (Disconnect and Connect)
        • 12V/LV Battery (Remove and Replace)
        • Battery Temperature Sensor - Main Front and Body Harnesses (Repair) (Repair)
        • Beam - 12V Battery (Dual Motor) (Remove and Replace)
        • Beam - 12V Battery (RWD) (Remove and Replace)
        • Bracket - 12V Battery (Dual Motor) (Remove and Replace)
        • Bracket - 12V Battery (RWD) (Remove and Replace)
        • LV Battery - Recover (Heat Pump) (Restore)
        • LV Maintainer (Connect and Disconnect)
        • Strap - 12V Battery (Remove and Replace)
        • Vehicle HV Disablement Procedure
        • Vent Hose - 12V Battery (Remove and Replace)
      • 1710 - Harnesses
        • Busbar - DCDC Ground (Remove and Replace)
        • Connector - Pedestrian Warning Speaker (CN) (Remove and Replace)
        • Harness - 12V Battery Ground (Remove and Replace)
        • Harness - 12V Battery Positive (Remove and Replace)
        • Harness - Body - LH (LHD) (Remove and Replace)
        • Harness - Body - LH (RHD) (Remove and Replace)
        • Harness - Body - LH (Busbar) (RHD) (Remove and Replace)
        • Harness - Body - RH (LHD) (Remove and Replace)
        • Harness - Body - RH (RHD) (Remove and Replace)
        • Harness - Door - Front - LH (Remove and Replace)
        • Harness - Door - Rear - LH (Remove and Replace)
        • Harness - Subframe - Front (Remove and Replace)
        • Harness - Electronic Parking Brake (EPB) - LH (Remove and Replace)
        • Harness - Fascia - Front (Remove and Replace)
        • Harness - Fascia - Rear (Remove and Replace)
        • Harness - Filter - Antenna - LH (Remove and Replace)
        • Harness - Filter - Antenna - RH (Remove and Replace)
        • Harness - Front End Module (Remove and Replace)
        • Harness - Headliner (Remove and Replace)
        • Harness - HVAC Assembly (Heat Pump) (Remove and Replace)
        • Harness - Instrument Panel (LHD) (Remove and Replace)
        • Harness - Instrument Panel (RHD) (Remove and Replace)
        • Harness - Main Front (LHD) (Remove and Replace)
        • Harness - Main Front (RHD) (Remove and Replace)
        • Harness - Main Front - Active Hood (Remove and Replace)
        • Harness - Main Front (Info-Ryzen/Li-Ion) (Remove and Replace)
        • Harness - Seat - Driver (Remove and Replace)
        • Harness - Steering Wheel (Remove and Replace)
        • Harness - Subassembly - Thermal (Heat Pump) (Remove and Replace)
        • Harness - Subframe - Rear (Remove and Replace)
        • Harness - Thermal Beam (Remove and Replace)
        • Harness - Trunk (Remove and Replace)
        • Harness - USB - Car Computer to Glove Box (RHD) (Remove and Replace)
        • Harness - Windshield (Remove and Replace)
        • Jumper Harness - Trailer Hitch (Remove and Replace)
        • Jumper Harness - Charge Port Inlet (Busbar Type) (Remove and Replace)
        • Jumper Harness - Windshield (Retrofit)
      • 1715 - Electronic Control Modules
        • Module - Body Controller - Front (Dual Motor) (Non-Heat Pump) (Remove and Replace)
        • Module - Body Controller - Front (Heat Pump) (Remove and Replace)
        • Module - Body Controller - Front (RWD) (Non-Heat Pump) (Remove and Replace)
        • Module - Body Controller - LH (LHD) (Heat Pump) (Remove and Replace)
        • Module - Body Controller - LH (LHD) (Non-Heat Pump) (Remove and Replace)
        • Module - Body Controller - LH (RHD) (Non-Heat Pump) (Remove and Replace)
        • Module - Body Controller - RH (Remove and Replace)
        • Module - Body Controller - RH (LHD) (Heat Pump) (Remove and Replace)
        • Module - Body Controller - RH (RHD) (Non-Heat Pump) (Remove and Replace)
        • Module - HomeLink Transmitter (Remove and Replace)
        • Shield - Body Controller - Front (Heat Pump) (Remove and Replace)
        • Steering Controller (Remove and Replace)
      • 1720 - Radar Sensor
        • Bracket - Radar - Front (Remove and Replace)
        • Sensor - Radar - Front (Calibration)
        • Sensor - Radar - Front (Remove and Replace)
      • 1723 - Front Cameras
        • Camera - Forward Facing (Pitch Verification)
        • Camera - Triple - Forward Facing (Remove and Replace)
      • 1724 - Interior Camera
        • Camera - Interior (Remove and Replace)
      • 1725 - Rear Cameras
        • Camera - Rear Facing (Remove and Replace)
      • 1727 - Parking Sensors
        • Retainer - Sensor - Parking Distance (Remove and Replace)
        • Sensor - Parking Distance - Inner - Front (Remove and Replace)
        • Sensor - Parking Distance - Outer - Front (Remove and Replace)
        • Sensor - Parking Distance - Inner - Rear (Remove and Replace)
        • Sensor - Parking Distance - Outer - Rear (Remove and Replace)
      • 1730 - Interior Switches
        • Power Socket 12V - Center Console (Remove and Replace)
        • Switch - Steering Wheel - LH (Remove and Replace)
        • Switch - Steering Wheel - RH (Remove and Replace)
      • 1735 - Interior Lighting
        • Light - Trunk (Remove and Replace)
        • Puddle Light - Front Door - LH (Remove and Replace)
        • Puddle Light - Rear Door - LH (Remove and Replace)
        • Task Light - Footwell Cover - LH (Remove and Replace)
      • 1740 - Exterior Lights
        • Bracket - Headlight - LH (Remove and Replace)
        • ECU - Headlight - LH (Remove and Replace)
        • Headlamps (SAE-to-Global) - Headlamp Assembly - Pair (Retrofit)
        • Headlights - Adjust - EMEA (Tool Method)
        • Headlights - Adjust - EMEA (Wall Method)
        • Headlights - Adjust - Global (Wall Method)
        • Headlights - Adjust - Global (Tool Method)
        • Headlights - Global - Adjust (EMEA with LET Tool)
        • Headlights - Adjust - NA (Tool Method)
        • Headlights - Adjust - NA (Wall Method)
        • Headlights (Check Aiming) (Inspection)
        • Headlights and Fog Lights (Check Aiming using Beisbarth Tool) (Inspection)
        • Headlights and Fog Lights (Check Aiming using LET Tool) (Inspection)
        • Headlight - LH (Remove and Install)
        • Headlight - LH (Remove and Replace)
        • Headlight - Pair - (Remove and Replace)
        • Light - Brake - Center High Mounted (Remove and Replace)
        • Light - Fog - Front (Adjust)
        • Lights - Fog - Front - Adjust (EMEA with LET Tool)
        • Light - Fog / Reverse - Rear - LH (Remove and Replace)
        • Light - License Plate (Remove and Replace)
        • Light - Side Repeater - Front - LH (Remove and Replace)
        • Light - Turn Signal / Fog - Front - LH (Remove and Replace)
        • Reflex Lens - Rear - RH (Remove and Install)
        • Reflex Lens - Rear - RH (Remove and Replace)
        • Reflector - Fascia - Rear - LH (Remove and Replace)
        • Taillight - LH (Remove and Install)
        • Taillight - LH (Remove and Replace)
        • Trim - Light - Side Repeater - Front - LH (Remove and Replace)
      • 1745 - Keyless Entry and Security
        • Antenna - Bluetooth Passive Entry - Front (Remove and Replace)
        • Antenna - Bluetooth Passive Entry - Rear (Remove and Replace)
        • Module - Body Controller - Security (Remove and Replace)
        • Module - Body Controller - Security (2nd Generation) (Remove and Replace)
        • Siren - Battery Backed (Remove and Replace)
        • Additional Key - Program (Existing Key Present)
        • Replacement Keys - Program (No Keys Present)
      • 1750 - Wipers and Washers
        • Reservoir - Windshield Washer (Remove and Replace)
        • Wiper Module (Remove and Replace)
        • Wiper Module (RHD) (Remove and Replace)
        • Wiper Arms (Remove and Replace)
        • Wiper Blades (Adjust)
        • Wiper Blades (Remove and Replace)
        • System - Windshield Washer (Remove and Replace)
        • Sensor - Level - Windshield Washer (Remove and Replace)
        • Pump - Windshield Washer (Remove and Replace)
        • Hose - Washer - Reservoir (RHD) (Remove and Replace)
        • Filler Neck - Reservoir - Windshield Washer (RHD) (Remove and Replace)
        • O-ring - Filler Neck - Reservoir - Windshield Washer (RHD) (Remove and Replace)
        • Cap - Reservoir - Windshield Washer (Remove and Replace)
        • Washer Nozzles (Adjust)
      • 1753 - Horns
        • Horn - High Tone (Remove and Replace)
        • Horn - High Tone (Remove and Replace) (Heat Pump)
        • Horn - Low Tone (Heat Pump) (Remove and Replace)
        • Horn - Low Tone (Remove and Replace)
        • Horn Assembly (Remove and Replace)
      • 1754 - Pedestrian Warning Speaker
        • Speaker - Pedestrian Warning (Remove and Replace)
        • Speaker - Pedestrian Warning (Retrofit)
      • 1755 - Accelerator Pedal
        • Accelerator (Remove and Replace)
    • 18 - Thermal Management
      • Torque Specifications - Thermal Management
      • 1810 - Cabin HVAC
        • Actuator - Bleed - LH (Heat Pump) (Remove and Replace)
        • Actuator - Bleed - LH (Non-Heat Pump) (Remove and Replace)
        • Actuator - Intake (Remove and Replace)
        • Actuator - Lower Mode (Heat Pump) (Remove and Replace)
        • Actuator - Lower Mode (Non-Heat Pump) (Remove and Replace)
        • Actuator - Upper Mode (Heat Pump) (Remove and Replace)
        • Actuator - Upper Mode (Non-Heat Pump) (Remove and Replace)
        • Actuator - Vent - LH (Remove and Replace)
        • Actuator - Vent - RH (Remove and Replace)
        • Air Extractor - LH (Remove and Replace)
        • Blower Motor - HVAC (Heat Pump) (Remove and Replace)
        • Blower Motor - HVAC (Non-Heat Pump) (Remove and Replace)
        • Clean the Blower Motor
        • Duct - Air Wave - LH (LHD) (Non-Heat Pump) (Remove and Replace)
        • Duct - Air Wave - LH (RHD) (Remove and Replace)
        • Duct - Air Wave - RH (LHD) (Remove and Replace)
        • Duct - Air Wave - RH (RHD) (Remove and Replace)
        • Duct - Upper - Cabin Intake (Remove and Replace)
        • Duct - Footwell - LH (LHD) (Remove and Replace)
        • Duct - Footwell - LH (RHD) (Remove and Replace)
        • Duct - Footwell - RH (LHD) (Remove and Replace)
        • Duct - Footwell - RH (RHD) (Remove and Replace)
        • Duct - Fresh Intake (Remove and Replace)
        • Duct - HVAC Plenum - Inner (Remove and Replace)
        • Plenum - Inlet - HVAC (Remove and Replace)
        • Filter - Cabin (Remove and Replace)
        • Heater - PTC (Remove and Replace)
        • HVAC Assembly (Heat Pump) (Remove and Replace)
        • HVAC Assembly (Non-Heat Pump) (Remove and Replace)
        • Sensor - Ambient Air Temperature (Non-Heat Pump) (Remove and Replace)
        • Sensor - Ambient Air Temperature (Heat Pump) (Remove and Replace)
        • Sensor - Cabin Temperature (Remove and Replace)
        • Sensor - Temperature - Evaporator (Remove and Replace)
        • Sensor - Temperature - LH (Remove and Replace)
        • Sensor - Temperature - RH (Remove and Replace)
        • Thermistor - Duct - Upper - LH (Heat Pump) (Remove and Replace)
        • Thermistor - Duct - Lower - RH (Heat Pump) (Remove and Replace)
        • Thermistor - Duct - Upper - RH (Heat Pump) (Remove and Replace)
        • Vehicle Sanitation - Evaporator - Tunap 994 (EMEA)
        • Vehicle Sanitation - Evaporator - Models with PTC Heater - Tunap 994 (EMEA)
      • 1820 - Refrigerant System
        • A/C Compressor and Supermanifold (Remove and Replace)
        • A/C Compressor, Supermanifold and Compressor to Supermanifold A/C Line (Heat Pump) (Remove and Replace)
        • A/C Line - Supermanifold to Compressor (Remove and Replace)
        • A/C Line - Supermanifold to HVAC (Remove and Replace)
        • Use Evaporator Foam Cleaner, Replace Cabin Filters
        • Use HVAC Cleaning Machine
        • A/C Refrigerant Leak Detection
        • A/C Refrigerant (Recovery and Recharge)
        • A/C Refrigerant (Heat Pump) (Unknown Oil Quantity or System Flush)
        • Bracket - Compressor (Heat Pump) (Remove and Replace)
        • Bracket - Compressor (Non-Heat Pump) (Remove and Replace)
        • Chiller and EXV Assembly (Non-Heat Pump) (Remove and Replace)
        • Compressor (Non-Heat Pump) (Remove and Replace)
        • Compressor (Heat Pump) (Remove and Replace)
        • Condenser (Remove and Replace)
        • Desiccant (Heat Pump) (Remove and Replace)
        • Evaporator (Non-Heat Pump) (Remove and Replace)
        • Fan- Radiator (Remove and Replace)
        • Module - Cooling Fan (Heat Pump) (Remove and Install)
        • Module - Cooling Fan (Remove and Install)
        • Module - Cooling Fan (Non-Heat Pump) (Remove and Replace)
        • Pipe - High Pressure - Compressor to Condenser (Non-Heat Pump) (Remove and Replace)
        • Pipes - Refrigerant - High / Low Pressure (Non-Heat Pump) (Remove and Replace)
        • Receiver Dryer and Desiccant (Non-Heat Pump) (Remove and Replace)
        • Sensor - Pressure and Temperature (PT) - High Pressure (Non-Heat Pump) (Remove and Replace)
        • Sensor - Pressure and Temperature (PT) - Low Pressure (Non-Heat Pump) (Remove and Replace)
        • Stone Guard（Heat Pump) (Remove and Replace)
        • TXV Valve - Evaporator (Non-Heat Pump)(Remove and Replace)
      • 1830 - Cooling System
        • Actuator - 5-Way Valve (Dual Motor) (Remove and Replace)
        • Actuator - 5-Way Valve (RWD) (Remove and Replace)
        • Clean Radiator
        • Clean Radiator (Heat Pump)
        • Cooling Fan Module Isolator Kit - Air Conditioning Condenser (Heat Pump) (Remove and Replace)
        • Coolant Pump - HV Battery (Heat Pump) (Remove and Replace)
        • Coolant Pump - HV Battery (Remove and Replace)
        • Coolant Pump - Powertrain (Heat Pump) (Remove and Replace)
        • Coolant Pump - Powertrain (Remove and Replace)
        • Cooling System (Check and Fill)
        • Cooling System (Drain and Refill)
        • Cooling System (Partial Refill and Bleed)
        • Cooling System (Vacuum Refill)
        • Hose - Chiller to Car Computer and HV Battery Supply Manifold (Dual Motor) (Remove and Replace)
        • Hose - Chiller to Car Computer and HV Battery Supply Manifold (RWD) (RHD) (Remove and Replace)
        • Hose - Front Drive Unit Powertrain Bypass (Heat Pump) (RWD) (Remove and Replace)
        • Hose - Front Manifold - LH (Remove and Replace)
        • Hose - Inlet - Inverter - Rear Drive Unit (4DU) (Remove and Replace)
        • Hose - Inlet - Inverter - Rear Drive Unit (3DU) (Remove and Replace)
        • Hose - Heat Exchanger to Superbottle - Front Drive Unit (Remove and Replace)
        • Hose - Inlet - Radiator (Non-Heat Pump) (Remove and Replace)
        • Hose - Inlet - Radiator (Heat Pump) (Remove and Replace)
        • Hose - Inverter Inlet - Front Drive Unit (Non-Heat Pump) (Remove and Replace)
        • Hose - Inverter Inlet - Front Drive Unit (Heat Pump) (Remove and Replace)
        • Hose - Inverter to Heat Exchanger - Front Drive Unit (Non-Heat Pump) (Remove and Replace)
        • Hose - Inverter to Heat Exchanger - Front Drive Unit (Heat Pump) (Remove and Replace)
        • Hose - Inverter to Heat Exchanger - Rear Drive Unit (3DU) (Remove and Replace)
        • Hose - Inverter to Heat Exchanger - Rear Drive Unit (4DU) (Remove and Replace)
        • Hose - Outlet - Radiator (Non-Heat Pump) (Remove and Replace)
        • Hose - Outlet - Radiator (Heat Pump) (Remove and Replace)
        • Hose - Outlet - Rear Drive Unit (4DU) (Remove and Replace)
        • Hose - Outlet - Rear Drive Unit (3DU) (Remove and Replace)
        • Hose - Passthrough - Front Manifold - HV Battery (Male Coupler) (Retrofit)
        • Hose - Powertrain Supply - Supermanifold (Heat Pump) (Remove and Replace)
        • Hose - Return - HV Battery (Remove and Replace)
        • Hose - Return - HV Battery - Front (Heat Pump) (Remove and Replace)
        • Hose - Return - Powertrain (Heat Pump) (Remove and Replace)
        • Hose - Return - Powertrain (Non-Heat Pump) (Remove and Replace)
        • Hose - Inverter Inlet - Front Drive Unit (Heat Pump) (Remove and Replace)
        • Hose - Super bottle To Powertrain Coolant Supply (Remove and Replace)
        • Hose - Supply - Powertrain (Non-Heat Pump) (Remove and Replace)
        • Kit - Cooling Fan Module Isolator - Air Conditioning Condenser (Remove and Replace)
        • Powertrain Coolant (Drain and Refill)
        • Radiator (Non-Heat Pump) (Remove and Replace)
        • Radiator (Heat Pump) (Remove and Replace)
        • Superbottle (Dual Motor) (Remove and Replace)
        • Superbottle (RWD) (Remove and Replace)
      • 1840 - Supermanifold
        • Check Valves - Supermanifold (Remove and Replace)
        • Chiller (Heat Pump) (Remove and Replace)
        • Coil - Recirculation Expansion Valve (Heat Pump) (Remove and Replace)
        • Coolant Bottle (Heat Pump) (Remove and Replace)
        • Liquid Cooled Condenser (Heat Pump) (Remove and Replace)
        • Octovalve (Heat Pump) (Remove and Replace)
        • Sensor - Pressure and Temperature (PT) - High Pressure (Heat Pump) (Remove and Replace)
        • Sensor - Pressure and Temperature (PT) - Low Pressure (Heat Pump) (Remove and Replace)
        • Sensor - Subcool - Pressure and Temperature (PT) - High Pressure (Heat Pump) (Remove and Replace)
        • Shut Off Valve - Liquid Cooled Condenser (Heat Pump) (Remove and Replace)
        • Supermanifold (Remove and Replace)
        • Valve Body - EXV - Supermanifold (Heat Pump) (Remove and Replace)
      • 1850 - Air Distribution
        • Active Grille Shutter (Remove and Replace)
        • Active Grille Shutter (Heat Pump) (Remove and Replace)
    • 20 - Safety and Restraint
      • Airbag and Supplementary Restraint System (SRS) Precautions
      • Torque Specifications - Safety and Restraint
      • 2001 - Airbags
        • Airbag - Curtain - LH (Remove and Replace)
        • Airbag - Driver (Remove and Replace)
        • Airbag - Front Passenger (Remove and Install)
        • Airbag - Front Passenger (Remove and Replace)
        • Airbag - Knee - Driver (Remove and Install)
        • Airbag - Knee - Driver (Remove and Replace)
        • Airbag - Knee - Front Passenger (Remove and Replace)
        • Harness - Airbag - Driver (Remove and Replace)
        • Module - Restraint Control (Heat Pump) (Remove and Install)
        • Module - Restraint Control (Heat Pump) (Remove and Replace)
        • Module - Restraint Control (Non-Heat Pump) (Remove and Install)
        • Module - Restraint Control (Non-Heat Pump) (Remove and Replace)
        • Remove the Front Seat Airbag and Discard
      • 2005 - Seatbelts
        • Adjustable Top Loop (Remove and Replace)
        • Box Clip - Seat Belt Reminder - 1st Row - LH (Remove and Replace)
        • Buckle - 1st Row - LH (Remove and Replace)
        • Buckle - 2nd Row - Center (Remove and Replace)
        • Buckle - 2nd Row - LH (Remove and Replace)
        • Retractor - Seatbelt - 1st Row - LH (Remove and Replace)
        • Seatbelt - 2nd Row - Center (Remove and Replace)
        • Seatbelt - 2nd Row - LH (Remove and Replace)
        • Webbing Guide Bar - Seatbelt - 1st Row - LH (Remove and Replace)
      • 2010 - Pretensioners
        • Pretensioner - Outboard Lap - 1st Row - LH (Remove and Replace)
      • 2020 - Sensors
        • Sensor - Impact Accelerometer - B-Pillar - LH (Remove and Replace)
        • Sensor - Impact Accelerometer - C-Pillar - LH (Remove and Replace)
        • Sensor - Impact Accelerometer - Front Bumper - Center (Remove and Replace)
        • Sensor - Impact Accelerometer - Front Bumper - LH (Remove and Replace)
        • Sensor - Pressure - Door - Front - LH (Remove and Replace)
        • Sensor - Pressure Tube (Pedestrian Protection) (Remove and Replace)
        • Sensor - Resistive Occupancy - Front Seat - LH (Remove and Replace)
        • Sensor - Resistive Occupancy - Front Seat - RH (Remove and Replace)
      • 2030 - Pedestrian Protection System
        • Actuator - Pedestrian Protection - LH (Remove and Replace)
        • Bracket - Corner - Active Hood - LH (Remove and Replace)
        • Cover - Hinge - Active Hood - LH (Remove and Replace)
    • 21 - Infotainment
      • Torque Specifications - Infotainment
      • 2105 - Touchscreen
        • Service Panel - Instrument Panel (Remove and Replace)
        • Touchscreen (Remove and Replace)
      • 2115 - Car Computer
        • Car Computer (Dispose)
        • Car Computer (Remove and Install)
        • Car Computer (Remove and Replace)
        • Car Computer - HW2.5 to HW3 (Retrofit)
        • Car Computer (RHD) (Remove and Install)
        • Car Computer (Info-Ryzen) (Remove and Install)
        • Connectivity Board - Car Computer (HW2.5) (Remove and Replace)
        • Connectivity Board - Car Computer (eCall) (HW3) (Remove and Replace)
        • Connectivity Board - Car Computer (Info-Ryzen) (Remove and Replace)
        • SD Card - Car Computer (HW2.5) (Remove and Replace)
        • SD Card - Car Computer (HW3) (Remove and Replace)
        • SIM Card - Car Computer (HW2.5) (Remove and Replace)
        • SIM Card - Car Computer (eCall) (Remove and Replace)
        • SIM Card - Car Computer (Info-Ryzen) (Retrofit)
        • Visor - Car Computer (Info-Ryzen) (Remove and Replace)
      • 2121 - Audio System - Speakers Subwoofer Amplifier
        • Amplifier - Audio - External (Remove and Replace)
        • Chime - Power Trunk (Remove and Replace)
        • Speaker - Dash - Center (Remove and Replace)
        • Speaker - Dash - LH (Remove and Replace)
        • Speaker - Front Door - LH (Remove and Replace)
        • Speaker - Emergency (Remove and Replace)
        • Speaker - Headliner - LH (Remove and Replace)
        • Speaker - Parcel Shelf - LH (Remove and Replace)
        • Speaker - Rear Door - LH (Remove and Replace)
        • Subwoofer (Remove and Replace)
        • Tweeter - Dash (Remove and Replace)
        • Tweeter - Front Door - LH (Remove and Replace)
      • 2122 - Audio System - AM, FM and HD Radio
        • Tuner - FM / HD / DAB (Remove and Replace)
      • 2125 - Audio System - Bluetooth
        • Microphone - Bluetooth (Remove and Replace)
      • 2126 - Audio System - USB Media Port
        • USB Hub - Center Console - Front (Remove and Replace)
        • USB Hub - Center Console - Front (2.0) (Remove and Replace)
        • USB Hub - Center Console - Rear (Remove and Replace)
      • 2130 - Antenna - FM HD Radio
        • Amplifier - Antenna - FM (Remove and Replace)
      • 2132 - Antenna - GPS
        • Antenna - GPS (Remove and Replace)
      • 2133 - Antenna - Wi-Fi
        • Antenna - MIMO - LH (Remove and Replace)
        • Antenna - Wi-Fi (Remove and Replace)
      • 2134 - Antenna - eCall
        • Antenna - eCall (LHD) (Remove and Replace)
        • Antenna - eCall (RHD) (Remove and Replace)
    • 30 - Chassis
      • Torque Specifications - Chassis
      • 3001 - Chassis and Subframes
        • Isolator - Motor Mount - Front - LH (Remove and Replace)
        • Shear Plate - Rear Subframe - Front - LH (Remove and Replace)
        • Subframe Assembly - Front (Dual Motor) (Remove and Install)
        • Subframe Assembly - Front (Dual Motor) (Remove and Replace)
        • Subframe Assembly - Front (RWD) (Remove and Install)
        • Subframe Assembly - Front (RWD) (Remove and Replace)
        • Subframe Assembly - Rear (Remove and Install)
        • Subframe Assembly - Rear (Remove and Replace)
    • 31 - Suspension
      • Alignment Requirement - Suspension
      • Replacing Additional Suspension Components (Access Already Performed)
      • Torque Specifications - Suspension
      • 3100 - Adjustment
        • EPAS Alignment Check
        • Four Wheel Alignment Check
        • Four Wheel Alignment Check and Adjust
      • 3101 - Front Suspension (Including Hubs)
        • Bushing Bracket - Stabilizer Bar - Front - Set (Remove and Replace)
        • Bushing Bracket - Stabilizer Bar - Front - LH (Remove and Replace)
        • Front Upper Control Arm (FUCA) Mount - LH (Remove and Replace)
        • Control Arm - Upper - Front - LH (Remove and Replace)
        • Hub - Front - LH (Dual Motor) (Remove and Replace)
        • Hub - Front - LH (RWD) (Remove and Replace)
        • Knuckle - Suspension - Front - LH (Dual Motor) (Remove and Replace)
        • Knuckle - Suspension - Front - LH (RWD) (Remove and Replace)
        • Link - Compliance - Lower - Front - LH (Remove and Replace)
        • Link - Lateral - Lower - Front - LH (Remove and Replace)
        • Link - Stabilizer Bar - Front - LH (Remove and Replace)
        • Links - Lateral - Lower - Front - Pair (Remove & Replace)
        • Stabilizer Bar - Front (Remove and Replace)
        • Suspension - Front (Check Torque)
      • 3103 - Rear Suspension (Including Hubs)
        • Ball Joint - Rear - Upper - Rear Knuckle - LH (Remove and Replace)
        • Cover - Rear Suspension - LH (Remove and Replace)
        • Drop Link - Stabilizer Bar - Rear - LH (Remove and Replace)
        • Hub - Rear - LH (Remove and Replace)
        • Knuckle - Suspension - Rear - LH (Remove and Replace)
        • Knuckle - Suspension - Rear - LH (Inspect)
        • Link - Aft - Lower - Rear - LH (Remove and Replace)
        • Link - Aft - Upper - Rear - LH (Remove and Replace)
        • Link - Fore - Lower - Rear - LH (Remove and Replace)
        • Link - Fore - Upper - Rear - LH (Remove and Replace)
        • Sensor - Ride Height - Rear - LH (Remove and Replace)
        • Stabilizer Bar - Rear (Remove and Replace)
        • Suspension - Rear (Check Torque)
        • Toe Link - Rear - LH (Remove and Replace)
      • 3115 - Coil Suspension System
        • Damper - Rear - LH (Remove and Replace)
        • Spring - Rear Suspension - LH (Remove and Replace)
        • Damper Assembly - Front - LH (Remove and Replace)
        • Damper Assembly - Front - Pair (Remove and Replace)
    • 32 - Steering
      • Torque Specifications - Steering
      • 3201 - Steering Rack and Lower Column
        • Module - Steering Column Control (Remove and Replace)
        • Steering Rack (Dual Motor) (LHD) (Remove and Replace)
        • Steering Rack (Dual Motor) (RHD) (Remove and Replace)
        • Steering Rack (RWD) (Remove and Replace)
        • Steering Rack (RWD) (RHD) (Remove and Replace)
        • Tie Rod End - LH (Remove and Replace)
        • Tie Rod Kit - LH (Remove and Replace)
      • 3205 - Upper Column Steering Wheel Steering Lock
        • Bolt - Steering Wheel to Upper Column (Remove and Replace)
        • Grub Screws - Upper Steering Column (Inspect)
        • Grub Screws - Upper Steering Column (Rework)
        • Horn - Steering Wheel (Remove and Replace)
        • Rim - Steering Wheel (Remove and Replace)
        • Shroud - Lower - Steering Column (Remove and Replace)
        • Spoke Cover - Steering Wheel - Lower (Remove and Replace)
        • Steering Column (LHD) (Remove and Replace)
        • Steering Column (RHD) (Remove and Replace)
        • Steering Wheel (Remove and Install)
        • Steering Wheel (Remove and Replace)
        • Surround - Steering Wheel (Remove and Replace)
    • 33 - Brakes
      • Torque Specifications - Brakes
      • 3301 - Brake Discs and Calipers
        • Brake Caliper - Front - LH (Remove and Replace)
        • Brake Caliper - Rear - LH (Remove and Replace)
        • Brake Caliper - Rear - Pair (Remove and Replace)
        • Brake Pads - Burnishing
        • Brake Pads and Rotors - Front - Set (Remove and Replace)
        • Brake Pads and Rotors - Rear - Set (Remove and Replace)
        • Brake Pad Kit - Front (Base Brakes) (Remove and Replace)
        • Brake Pad Kit - Front (Sport Brakes) (Remove and Replace)
        • Brake Pad Kit - Rear (Base Brakes) (Remove and Replace)
        • Brake Pad Kit - Rear (Sport Brakes) (Remove and Replace)
        • Brake Rotor - Front - LH (Measure Runout)
        • Brake Rotor - Front - LH (Remove and Replace)
        • Brake Rotor - Rear - LH (Measure Runout)
        • Brake Rotor - Rear - LH (Remove and Replace)
        • Clean and Lubricate Brake Calipers (Non-Performance Brakes)
        • Clean and Lubricate Brake Calipers (Performance Brakes)
        • ECU - ABS Modulator (Heat Pump) (Remove and Replace)
        • NVH Tape - Brake Pads - Front (EMEA) (Retrofit)
        • Shield - Dust - Brake - Front - LH (Remove and Replace)
        • Shield - Dust - Brake - Rear - LH (Remove and Replace)
        • Shield - Dust - Brake - Rear - LH and RH (Retrofit)
      • 3303 - Brake Pipes and Hoses
        • Brake Fluid Bleed - One Caliper
        • Brake Fluid Bleed/Flush
        • Brake Fluid Check
        • Brake Hose - Flexible - Front - LH (Remove and Replace)
        • Brake Hose - Flexible - Rear - LH (Remove and Replace)
        • Brake Lines - 4 Tube Bundle - ABS to Wheels (RWD) (Remove and Replace)
        • Brake Lines - 4 Tube Bundle - ABS to Wheels (Dual Motor) (Remove and Replace)
        • Brake Lines - LH Sill (Remove and Replace)
        • Brake Lines - Master Cylinder to ABS (Remove and Replace)
        • Brake Lines - Master Cylinder to ABS (RHD) (Remove and Replace)
        • Brake Lines - Master Cylinder to ABS (Dual Motor) (RHD) (Remove and Replace)
        • Brake Lines - Rear - LH to Sill (Remove and Replace)
        • Brake Lines - Rear - RH to Sill (Remove and Replace)
      • 3305 - Parking Brake
        • Motor - Brake Caliper - Rear - LH (Remove and Replace)
        • Parking Brake - Caliper - Rear - LH (Release)
      • 3310 - ABS Traction and Stability Control
        • ABS Modulator (Heat Pump) (Remove and Replace)
        • ABS Modulator (Non-Heat Pump) (Remove and Replace)
        • Sensor - Wheel Speed - ABS - Front - LH (Remove and Replace)
        • Sensor - Wheel Speed - ABS - Rear - LH (Remove and Replace)
      • 3320 - Brake Booster
        • Electromechanical Brake Booster Assembly (Non-Heat Pump) (LHD) (Remove & Replace)
        • Booster - Brake - Electromechanical (Heat Pump) (LHD) (Remove and Replace)
        • Electromechanical Brake Booster Assembly (Non-Heat Pump) (RHD) (Remove and Replace)
        • Master Cylinder and Reservoir Assembly (Remove and Replace)
      • 3325 - Brake Pedal
        • Brake Pedal (Remove and Replace)
        • Brake Pedal (Remove and Replace) (RHD)
        • Clevis Pin - Brake (Remove and Replace)
        • Switch - Brake Light (Remove and Replace)
    • 34 - Wheel and Tires
      • Torque Specifications - Wheels and Tires
      • 3401 - Wheels
        • Cap - Wheel (Remove and Replace)
        • Wheel Assembly (Remove and Install)
        • Wheel (Remove and Replace)
        • Wheels - Set (Remove and Replace)
      • 3402 - Tires
        • Replacement Tire Information
        • Tire - Front - LH (Tire Purchase)
        • Tire - Front - LH (Balance)
        • Tire - Front - LH (Road Force) (Balance)
        • Tire - Front - LH (Repair)
        • Tire Rotation
      • 3404 - Tire Pressure Monitoring System (TPMS)
        • BLE TPMS (Retrofit)
        • BLE TPMS (Update Configuration)
        • Module - TPMS (Remove and Replace)
        • Sensor - TPMS (Remove and Replace)
        • TPMS (Sensor ID Drive Learn)
        • TPMS (Sensor ID Tool Learn)
    • 39 - Front Drive Unit
      • Torque Specifications - Front Drive Unit
      • 3901 - Front Drive Unit Assembly
        • Bushing – Front Drive Unit – RH (Remove and Replace)
        • Bushing - Gearbox - Front Drive Unit (Remove and Replace)
        • Drive Unit - Front (Remove and Replace)
        • Fluid Coupling (90 Degrees) - Front Drive Unit (Remove and Replace)
        • Fluid Coupling (Straight) - Front Drive Unit (Remove and Replace)
        • Ground Strap - Front Drive Unit (Remove and Replace)
        • Mount - Front Drive Unit - LH (Remove and Replace)
      • 3920 - Front Drive Inverter
        • Inverter - Front Drive Unit (Remove and Replace)
      • 3930 - Front Gearbox and Halfshafts
        • Bushing - Gearbox - Front Drive Unit (Remove and Replace)
        • Breather - Front Drive Unit (Remove and Replace)
        • Filter - Oil - Front Drive Unit (Remove and Replace)
        • Gearbox Fluid - Front Drive Unit (Check and Fill)
        • Gearbox Fluid - Front Drive Unit (Drain and Refill)
        • Gearbox Fluid - Front Drive Unit (3DU) (Drain and Refill) (Machine Only)
        • Halfshaft - Front Drive Unit - LH (Lubricate at Hub)
        • Halfshaft - Front Drive Unit - LH (Remove and Replace)
        • Heat Exchanger - Front Drive Unit (Remove and Replace)
        • Oil Pump - Front Drive Unit (Remove and Replace)
        • Seal - Axle - Front Drive Unit - LH (Remove and Replace)
    • 40 - Rear Drive Unit
      • Torque Specifications - Rear Drive Unit
      • 4001 - Rear Drive Unit Assembly
        • Bushing - Rear Drive Unit - Rear (3DU) (Remove and Replace)
        • Bushing - Rear Drive Unit - RH (3DU) (Remove and Replace)
        • Drive Unit - Rear (3DU) (Remove and Install)
        • Drive Unit - Rear (3DU) (Remove and Replace)
        • Drive Unit - Rear (4DU) (Remove and Install)
        • Drive Unit - Rear (4DU) (Remove and Replace)
        • Ground Strap - Rear Drive Unit (Remove and Replace)
        • Mount - Rear Drive Unit - LH (3DU) (Remove and Replace)
        • Mount - Rear Drive Unit - LH (4DU) (Remove and Replace)
        • Mount and Bushings Set - Rear Drive Unit (3DU) (Remove and Replace)
        • Mount and Bushings Set - Rear Drive Unit (4DU) (Remove and Replace)
      • 4020 - Rear Drive Inverter
        • Fluid Coupling (55 Degrees) - Rear Drive Unit (Remove and Replace)
        • Fluid Coupling (Straight) - Rear Drive Unit (Remove and Replace)
        • Inverter Air Leak Test
        • Inverter Coolant Leak Test
        • Inverter - Rear Drive Unit (4DU) (Remove and Replace)
        • Inverter - Rear Drive Unit (3DU) (Remove and Replace)
      • 4030 - Rear Gearbox and Halfshafts
        • Breather - Rear Drive Unit (Remove and Replace)
        • Filter - Oil - Rear Drive Unit (Remove and Replace)
        • Gearbox Fluid - Rear Drive Unit (3DU) (Drain and Refill)
        • Gearbox Fluid - Rear Drive Unit (4DU) (Drain and Refill)
        • Gearbox Fluid - Rear Drive Unit (3DU) (Drain and Refill) (Machine Only)
        • Halfshaft - Rear Drive Unit - LH (Lubricate at Hub)
        • Halfshaft - Rear Drive Unit - LH (Remove and Replace)
        • Heat Exchanger - Rear Drive Unit (4DU) (Remove and Replace)
        • Heat Exchanger - Rear Drive Unit (3DU) (Remove and Replace)
        • Oil Pump - Rear Drive Unit (4DU) (Remove and Replace)
        • Oil Pump - Rear Drive Unit (3DU) (Remove and Replace)
        • Seal - Axle - Rear Drive Unit - LH (Remove and Replace)
    • 44 - High Voltage System
      • Torque Specifications - High Voltage System
      • 4400 - High Voltage Testing
        • Isolation/Insulation Test
        • Vehicle HV Disablement Procedure
      • 4401 - Charge System Inlet
        • Actuator - Door Assembly - Charge Port (NA) (Remove and Replace)
        • Bracket - Busbar - Charge Port to HV Battery (3-Phase) (Remove and Replace)
        • Bracket - Manual Release Cable - Charge Port (Remove & Replace)
        • Bracket - Retainer - Busbar - Charge Port to HV Battery (3-Phase) (Remove and Replace)
        • Busbars - Charge Port to HV Battery (NACS) (Remove and Replace)
        • Busbars - Charge Port to HV Battery (GB) (Remove and Replace)
        • Busbars - Charge Port to HV Battery (CCS) (Remove and Replace)
        • Charge Port and Busbar to HV Battery (Single-Phase) (Retrofit)
        • Charge Port and Busbar to HV Battery (3-Phase) (Retrofit)
        • Carrier Assembly - Charge Port (Remove and Replace)
        • Charge Port - Manual Release of Cable
        • Charge Port (Busbar Type) (NACS) (Remove and Replace)
        • Charge Port (GB) (Remove and Replace)
        • Charge Port Lubrication (China)
        • Charge Port (Busbar Type) (CCS) (Remove and Replace)
        • Charge Port Voltage Check
        • ECU - Charge Port (Combo Adapter) (Retrofit)
        • Deadfronts - Pin - Charge Port (NA) (Damaged) (Remove and Replace)
        • Deadfronts - Pin - Charge Port (NA) (Undamaged) (Remove and Replace)
        • Door and Hinge Cover - Charge Port (Remove and Replace)
        • Door Assembly - Charge Port (Busbar Type) (EMEA) (Remove and Replace)
        • Door Assembly - Charge Port (China) (Remove and Replace)
        • Door Assembly - Charge Port (EMEA) (Remove and Replace)
        • Door Assembly - Charge Port (NA) (Harness Type) (Remove and Replace)
        • ECU - Charge Port (Remove and Replace)
        • Latch Actuator - Charge Port (Remove and Replace)
        • Latch Pin - AC - Charge Port (China) (Remove and Replace)
        • Latch Pin - DC - Charge Port (China) (Remove and Replace)
        • Release Cable - Charge Port (NA) (Remove and Replace)
        • Safety Cap - Busbar - Charge Port to HV Battery (Remove and Replace)
        • Sensor Target - Door - Charge Port (Remove and Replace)
        • Sub-Assembly - Latch - Charge Port (EMEA) (Remove and Replace)
      • 4450 - HV Harnesses
        • AC Cable - Charge Port to HV Battery (3-Phase) (Remove and Replace)
        • AC Cable - Charge Port to HV Battery (3-Phase) (Retrofit)
        • HV Harness - Center Ski to A/C Compressor (Remove and Replace)
        • Charge Port and HV Harness Assembly (NACS) (Remove and Replace)
        • HV Harness Assembly - Charge Port to HV Battery (Three-Phase) (Remove and Replace)
        • HV Harness - HV Battery to Front Drive Unit (Remove and Replace)
        • HV Harness - HV Battery to PTC Heater and A/C Compressor (Dual Motor) (Remove and Replace)
        • HV Harness - HV Battery to PTC Heater and A/C Compressor (RWD) (Remove and Replace)
        • HV Harness - HV Battery to Rear Drive Unit (4DU) (Remove and Replace)
        • HV Harness - HV Battery to Rear Drive Unit (3DU) (Remove and Replace)
        • Low Internal Isolation Diagnostics - HV System (Test)
    • 50 - External Charging Connectors
      • 5001 - Mobile Connector
        • Cleaning - Universal Mobile Connector
        • Firmware Update - Mobile Connector
        • Remove Stuck Deadfront - Charge Handle
      • 5003 - Charging Adapters
        • Firmware Update - CHAdeMO Charging Adapter
    Send Procedure Feedback
    Jump to:
    • Related links
    • © Tesla 2026

    You will be redirected to your default email client to provide feedback.

    Crowsfoot or Offset Wrench Extension Calculator

    Torque Calculator Values
    Note
    1. If the angle from the extension to the torque wrench is greater than 90° (Figure 2), input E as a positive number.
    2. If the angle from the extension to the torque wrench is less than 90° (Figure 3), input E as a negative number.
    3. If the angle from the extension to the torque wrench is exactly 90°, this calculator is not needed. Torque the fastener to T1.
    Figure 1
    Figure 2
    Figure 3