18 - Thermal Management

    Related links

    • Torque Specifications - Thermal Management
    • 1810 - Cabin HVAC
    • 1820 - Refrigerant System
    • 1830 - Cooling System
    • 1840 - Supermanifold
    • 1850 - Air Distribution
    • Model 3 2024+ Service Manual
    • Release Notes
      • Current Release Notes
      • Release Notes Archive
        • Release Notes October-December 2023
        • Release Notes January-March 2024
        • Release Notes April-June 2024
        • Release Notes July-September 2024
    • General Information
      • INTRODUCTION
        • How to Use this Manual
        • Abbreviations and Symbols
        • Flat Rate Times
        • Repairs and Replacements
        • Warranty Service Regions
      • BEST PRACTICES
        • Airbag and Supplementary Restraint System (SRS) Component Replacement Policy
        • Airbag and Supplementary Restraint System (SRS) Precautions
        • Air Conditioning System Precautions
        • Diagnostic Connector Location
        • Electrical Precautions
        • Environmental Precautions
        • Event Data Recorder Retrieval
        • Flexible Pipes and Hoses
        • General Fitting Instructions
        • General Precautions
        • Locking Devices
        • Multimeter (LoZ Setting)
        • Oil Seals
        • Personal Protection
        • Vehicle Cameras and Autopilot
        • Wheels and Tires
          • Wheel Disposal (Rework)
      • CHARGING
        • General
      • TECHNICAL DATA
        • Brakes
        • Electrical
        • Suspension
        • Tire Pressures
        • Wheel Alignment
        • Wheels
      • IDENTIFICATION NUMBERS
        • Drive Unit Number
        • Manufacturing Certification Label
        • Serial Numbers
        • Vehicle and Wheel Paint Codes
        • Vehicle Identification Number (VIN)
      • FLUIDS AND CAPACITIES
        • Fluids and Capacities
    • 00 - Inspection and Service
      • 0001 - Maintenance Service
        • Maintenance Service and Intervals
      • 0002 - Firmware Service
        • Software Reinstall - Touchscreen
        • Software Update
      • 0005 - Service Modes
        • Gateway Configuration (Display and Change)
        • Gateway Unlock
        • OBD Connector (Retrofit) (Retrofit)
        • Service Mode
        • Service Mode Plus
        • Toolbox 3 (Connect and Disconnect)
    • 10 - Body
      • Torque Specifications - Body
      • 1000 - Vehicle Lifting
        • GUID-0ECF2493-88F6-48E9-ADBB-9AE1D52E217C.xml
      • 1001 - Bumper / Fascia
        • Carrier - Bumper - Front (Remove and Replace)
        • Reinforcement - Fascia - Front - LH (Remove and Replace)
        • Fascia - Front - Lower (Remove and Replace)
        • Cover - Hood Latch (Remove and Replace)
        • Bracket - Fascia Side to Fender - LH (Remove and Replace)
        • Bracket - Fascia Side to Fender - RH (Remove and Replace)
        • Cover - Tow Hook - Front (Remove and Replace)
        • Fascia - Front (Remove and Replace)
        • Tow Hook - Front (Remove and Replace)
        • Grille - Fascia - Front (Remove and Replace)
        • Ankle Catcher (Remove and Replace)
        • Bumper Beam - Front (Remove and Replace)
        • Bumper Beam - Rear (Remove and Replace)
        • Crush Can - Upper - Front - LH (Remove and Replace)
        • Foam - Bumper Beam - Front (Remove and Replace)
        • Crush Can - Lower - Front (Remove and Replace)
        • Fascia - Rear - Upper (Remove and Replace)
        • Fascia - Rear - Lower - Base (Remove and Replace)
        • Fascia - Rear - Lower (Remove and Replace)
        • Bracket - Rear - Center (Remove and Replace)
        • Bracket - Rear Wing - LH (Remove and Replace)
        • Bracket - Tail Lamp - LH (Remove and Replace)
        • Fascia Assembly - Rear \(Remove and Install\)
      • 1010 - Body Panels
        • Fender Assembly - Front - LH (Remove and Install)
        • Fender Assembly - Front - LH (Remove and Replace)
        • Door - Rear - LH (Remove and Install)
        • Door - Rear - LH (Remove and Replace)
        • Brace - Shock Tower (Remove and Replace)
        • Trunk (Remove and Install)
        • Door - Front - LH (Remove and Install)
        • Door - Front - LH (Remove and Replace)
        • Trunk (Remove and Replace)
        • Hood Assembly \(Remove and Replace\)
      • 1020 - Windshield and Body Glass
        • Clear Forward Camera View (Precision Cleaning Of Inboard Windshield)
        • Glass - Backlight (Remove and Replace)
        • Glass - Body - Rear Quarter - LH (Remove and Replace)
        • Glass - Door - Front - LH (Remove and Replace)
        • Glass - Door - Rear - LH (Remove and Replace)
        • Glass - Roof - Fixed (Remove and Replace)
        • Seal - Trunk Flip - Backlight (Remove and Replace)
        • Seal - Upper Perimeter - Backlight (Remove and Replace)
        • Temperature and Humidity Sensor (Remove and Replace)
        • Windshield (LHD) (Remove and Replace)
        • Windshield Chip Repair (EMEA)
        • Windshield and Roof Glass Repair and Replacement Guidelines
      • 1030 - Paint
        • Paint Defect Rectification
      • Panel Alignment
        • Fender Alignment
    • 11 - Closures
      • Torque Specifications - Closures
      • 1120 - Trunk
        • Latch - Cinch - Trunk (Remove and Replace)
        • Striker - Trunk (Remove and Replace)
      • 1133 - Closure Assist Mechanisms and Hinges
        • Carbon Fiber Spoiler - Rear (Retrofit using Jig)
        • Seal - Check Strap - Door - Front (Remove and Replace)
        • Closeout Panel - Door - Front - LH (Remove and Replace)
        • Check Strap - Door - Front - LH (Remove and Replace)
        • Hinge - Door - Front - Lower - LH (Remove and Replace)
        • Hinge - Door - Front - Upper - LH (Remove and Replace)
        • Latch - Door - Front - LH (Remove and Replace)
        • Striker - Door - LH (Remove and Replace)
        • Hinge - Active Hood - LH (Remove and Replace)
        • Strut Reinforcement - Active Hood (Remove and Replace)
        • Cover - Hood Hinge - LH (Remove and Replace)
        • Bracket - Hood Strut - RH (Remove and Replace)
        • Gas Strut - Hood (Remove and Replace)
        • Striker - Active Hood (Remove and Replace)
        • Latch - Hood (Single Actuator System) (Remove and Replace)
        • Check Strap - Door - Rear (Remove and Replace)
        • Hinge - Door - Rear - Lower - LH (Remove and Replace)
        • Hinge - Door - Rear - Upper - LH (Remove and Replace)
        • Latch - Door - Rear - LH (Remove and Replace)
        • Bump Stop - Liftgate (Remove and Replace)
        • Bump Stop - Overslam - Liftgate (Remove and Replace)
        • Power Strut - Liftgate - LH (Remove and Replace)
        • Hinge - Power Trunk - LH (Remove and Replace)
      • 1135 - Latches Strikers and Pinch Sensors
        • Handle - Exterior Release - Trunk (Remove and Replace)
      • 1145 - Exterior Door Handles
        • Handle - Exterior Release - Door - Front - LH (Remove and Replace)
        • Sensor - Exterior Door Handle - Front - LH (Remove and Replace)
        • Sensor - Exterior Door Handle - Rear - LH (Remove and Replace)
        • Handle - Exterior Release - Door - Rear - LH (Remove and Replace)
        • Handle - Exterior Release - Door - Front - LH (Recalibrate)
      • 1150 - Door Glass and Regulators
        • Seal - Glass Run - Front Door - LH (Remove and Replace)
        • Window Motor / Regulator Assembly - Rear - LH (Remove and Replace)
        • Window Motor / Regulator Assembly - Front - LH (Remove and Replace)
        • Glass - Door - LH - Front (Adjust)
        • Glass - Door - LH - Rear (Adjust)
        • Window Regulator (Recalibrate) (Module Reset/Reflashed)
      • 1170 - Seals Body Closures
        • Seal - Inner Belt - Front Door - LH (Remove and Replace)
        • Seal - Inner Belt - Rear Door - LH (Remove and Replace)
        • Seal - Body - Side - Front - Primary - LH (Remove and Replace)
        • Seal - Body - Side - Rear - Primary - RH (Remove and Replace)
        • Seal - Outer Belt - Front Door - LH (Remove and Replace)
        • Seal - Secondary - Front Door - LH (Remove and Replace)
        • Seal - Outer Belt - Rear Door - LH (Remove and Replace)
        • Seal - Secondary - Rear Door - LH (Remove and Replace)
        • Seal - Trunk (Remove and Replace)
    • 12 - Exterior Fittings
      • Torque Specifications - Exterior Fittings
      • 1201 - Wheel Arch Liners
        • Noise Absorber - Motor Bay - Front (Remove and Replace)
        • Noise Absorber - Motor Bay - Rear (Remove and Replace)
        • Wheel Arch Liner - Front - LH (Remove and Replace)
        • Wheel Arch Liner - Rear - LH (Remove and Replace)
      • 1203 - Undertray and Diffuser
        • Panel - Aero Shield - Front (Remove and Replace)
        • Valance - Front Fascia (Non-Performance) (Remove and Replace)
        • Diffuser - Rear Fascia (Remove and Replace)
        • Cover - Rear Suspension - LH (Remove and Replace)
        • Panel - Aero Shield - Rear (Remove and Replace)
      • 1205 - Badges and Films
        • Performance Badge - Rear (Remove and Replace)
        • Sill Plate - Front - LH (Remove and Replace)
        • Tesla Badge - Front (Remove and Replace)
        • Sill Plate - Rear - LH (Remove and Replace)
        • Tesla Badge - Rear (Remove and Replace)
        • Tesla Badge - Rear (China) (Remove and Replace)
      • 1207 - License Plate Mountings
        • Bracket - License Plate - Front (AU) (Retrofit using Jig)
        • Bracket - License Plate - Front (EMEA) (Retrofit using Jig)
        • Bracket - License Plate - Rear (China) (Remove and Replace)
        • Bracket - License Plate - Rear (EMEA) (Remove and Replace)
        • Front License Plate Bracket (NA) (Remove and Replace)
      • 1209 - Exterior Mirrors
        • Skull Cap - Door Mirror - LH (Remove and Replace)
        • Applique - A-Pillar - Mirror - Door - LH (Remove and Replace)
        • Glass - Door Mirror - LH (Remove and Replace)
        • Mirror - Door - LH (Remove and Replace)
      • 1220 - Exterior Trim
        • Applique - B-Pillar - LH (Remove and Replace)
        • Cap - Brightwork - Upper - LH (Remove and Replace)
        • Exterior Trim Fittings - Mud Flaps - Pair
        • Mud Flaps (Retrofit)
        • Cover - Rocker Panel - Lower - LH (Remove and Replace)
        • Spoiler - Carbon Fiber (Remove and Replace)
      • 1224 - Luggage Compartment Trim
        • Underhood Storage Unit (Remove and Replace)
        • Switch - Child Safety - Underhood Storage Area (Remove and Replace)
        • Exterior Fittings - Luggage Compartment Trim - Front Luggage Storage Compartment - Frunk Reinforcement Assembly
      • 1225 - Underhood Trim
        • Panel - Cowl Screen (Remove and Replace)
        • Carrier Bracket - Cowl Screen - LH (Remove and Replace)
        • Underhood Apron - Rear (Remove and Replace)
        • Cover - Shock Tower - LH (Remove and Install)
      • 1230 - Trailer Hitch
        • Trailer Hitch - Rear Energy Absorber (Retrofit)
    • 13 - Seats
      • Torque Specifications - Seats
      • 1301 - Front Seat Tracks and Motors
        • Button - Cushion Adjust - LH (Remove and Replace)
        • Button - Recliner - LH (Remove and Install)
        • Switch Assembly - Front Seat - LH (Remove and Replace)
        • Frame - Seat Cushion - Front Seat (Remove and Replace)
        • Motor - Seat Track - Driver Seat (Remove and Replace)
        • Motor - Seat Height - Front Seat (Remove and Replace)
        • Motor - Seat Track - Passenger Seat (Remove and Replace)
        • Lumbar Support - Backrest - Driver Seat (Remove and Replace)
        • Motor - Recliner - Backrest - Front Seat (Remove and Replace)
        • Cover - Front - Seat Track - Front Seat (Remove and Replace)
        • Motor - Seat Tilt - Front Seat (Remove and Replace)
        • Suspension - Cushion - Front Seat - LH (Remove and Replace)
        • Suspension - Backrest - Front Seat - LH (Remove and Replace)
        • Blower - Backrest - Front Seat - LH (Remove and Replace)
        • Blower - Cushion - Front Seat - LH (Remove and Replace)
        • Frame - Back Rest - Front Seat (Remove and Replace)
      • 1302 - 2nd Row Seat Tracks and Motors
        • Bracket - Edge Support - Seat Cushion - 2nd Row - LH (Remove and Replace)
      • 1304 - Front Seat Assemblies and Hardware
        • Headrest - Front Seat (Remove and Replace)
        • Headrest - Front Seat (Sport Seat) (Remove and Replace)
        • Seat Assembly - 1st Row - LH (Remove and Replace)
        • Seat Assembly - 1st Row - No Lumbar - RH (Remove and Replace)
      • 1305 - 2nd Row Seat Assemblies and Hardware
        • Pivot Sleeve - Seat Back - 2nd Row - Center (Remove and Replace)
        • Armrest - 2nd Row (Remove and Replace)
        • Bolster - Side - Seat - 2nd Row - LH (Remove and Replace)
        • Seatback - 2nd Row - LH (Remove and Replace)
        • Pivot Cover - Seat Back - 2nd Row (Remove and Replace)
        • Seatback - 2nd Row - RH (Remove and Replace)
        • Seat Cushion - 2nd Row (Remove and Replace)
        • Latch - Seat Back - 2nd Row - RH (Remove and Replace)
        • Projections Cover - Seat Back - 2nd Row (Remove and Replace)
        • Escutcheon - Seat Belt - Center (Remove and Replace)
        • Support - Escutcheon - Seat Belt - Center (Remove and Replace)
        • Handle - Seat Back - 2nd Row - LH (Remove and Replace)
        • Handle - Seat Back - 2nd Row - RH (Remove and Replace)
        • Bezel - Handle - Seat Back - 2nd Row - LH (Remove and Replace)
        • Bracket - Hinge - Seat Back - 2nd Row (Remove and Replace)
        • Bezel - Handle - Seat Back - 2nd Row - RH (Remove and Replace)
        • Striker - Seat Back - 2nd Row (Remove and Replace)
        • Closeout - Armrest - 2nd Row (Remove and Replace)
        • Trim - Lower Closeout - Armrest - 2nd Row (Remove and Replace)
      • 1307 - Front Seat Covers Pads and Trims
        • Trim - Seat Back - Front Seat - RH (Remove and Replace)
        • Cover- Front Seat Cushion- LH (Sport Seat) (Remove and Replace)
        • Post Guide - Headrest - Front Seat (Remove and Replace)
        • Side Shield - Outboard - LH (Remove and Replace)
        • Foam Pad - Seat Back - Front Seat - LH (Remove and Replace)
        • Shell - Seat Back - Front Seat (Remove and Replace)
        • Shell - Seat Back - Front Seat (Sport Seat) (Remove and Replace)
        • Trim - Seat Back - Front Seat - LH (Remove and Replace)
        • Foam - Cushion - Front Seat (Remove and Replace)
        • Foam - Cushion - Front Seat- LH (Sport Seat) (Remove and Replace)
        • Trim - Cushion - Front Seat - LH (Remove and Replace)
        • Foam - Seat Back - Front Seat - RH (Remove and Replace)
        • Decor Panel -1st Row Seat - LH (Sport Seat) (Remove and Replace)
        • Carrier - Side Shield - LH (Remove and Replace)
        • Side Shield - Inboard - LH (Remove and Replace)
      • 1308 - 2nd Row Seat Covers Pads and Trims
        • Upholstery Wire - Armrest - 2nd Row - LH (Remove and Replace)
        • Foam - Seat Back - 2nd Row - LH (Remove and Replace)
        • Foam - Seat Back - 2nd Row - RH (Remove and Replace)
        • Trim - Seat Back - 2nd Row - LH (Remove and Replace)
        • Trim - Seat Back - 2nd Row - RH (Remove and Replace)
    • 14 - Instrument Panel
      • Torque Specifications - Instrument Panel
      • 1405 - Instrument Panel
        • Cover - Footwell - Driver (Remove and Replace)
        • End Cap - Instrument Panel - LH (Remove and Replace)
        • Glove Box (Remove and Replace)
        • Assembly - Instrument Panel - Lower (Remove and Replace)
        • NVH Pad - IP Carrier (Remove and Replace)
        • Cover - Footwell - Front Passenger (Remove and Replace)
        • Shroud - Lower - Steering Column (Remove and Replace)
        • Shroud - Upper - Steering Column (Remove and Replace)
        • Beam - Cross Car (LHD) (Remove and Replace)
        • Support Bracket - Display - LH (Remove and Replace)
        • Riser Bracket - Instrument Panel - RH (Remove and Replace)
        • Float Wing - Instrument Panel (Remove and Replace)
        • USB Module - Glove Box (Remove and Replace)
        • IP Carrier (Remove and Install)
        • IP Carrier (Remove and Replace)
        • Speaker Grille - Instrument Panel (Remove and Replace)
        • Thermistor - Duct (Remove and Replace)
        • Air Vent - Driver (Remove and Replace)
        • Duct - Air Wave - LH (Remove and Replace)
        • Duct - Air Wave - RH (Remove and Replace)
        • Duct - Footwell - LH (Remove and Replace)
        • Duct - Footwell - RH (Remove and Replace)
        • Duct - Defrost - LH (Remove and Replace)
        • Knee Impact Foam - LH (NA) (Remove and Replace)
        • Knee Impact Foam - RH (NA) (Remove and Replace)
        • Beam - Cross Car (RHD) (Remove and Replace)
        • Cover - Footwell - Driver (RHD) (Remove and Replace)
        • Cover - Footwell - Front Passenger (RHD) (Remove and Replace)
        • Glove Box (RHD) (Remove and Replace)
        • Duct - Air Wave - LH (RHD) (Remove and Replace)
        • Duct - Footwell - LH (RHD) (Remove and Replace)
    • 15 - Interior Trim
      • Torque Specifications - Interior Trim
      • 1505 - Interior Mirror and Sun Visors
        • Mirror - Rear View (Remove and Replace)
        • Camera Cover - Upper (Remove and Replace)
        • Camera Cover - Lower (Remove and Replace)
        • Hood - Camera (Remove and Replace)
        • Sun Visor Assembly, LH (Remove and Replace)
      • 1511 - Trunk Trim
        • Cover - Latch - Trunk (Remove and Replace)
        • Close Switch - Trunk (Remove and Replace)
        • Trim - Lid - Trunk (Remove and Replace)
        • Trim - Package Tray (Premium) (Remove and Replace)
        • Garnish - Trunk (Remove and Replace)
      • 1513 - Door Trim
        • Ambient Lighting Brightwork Assembly - Front - LH (China) (Remove and Replace)
        • Ambient Lighting Brightwork Assembly - Rear - LH (China) (Remove and Replace)
        • Switch - Interior Door Release - Front - LH (Remove and Replace)
        • NVH Pad - Door - Front - LH (Remove and Replace)
        • Speaker Grille - Front Door - LH (Remove and Replace)
        • Tweeter - Front Door - LH (Remove and Replace)
        • Panel - Door Trim - Rear - LH (Remove and Install)
        • Panel - Door Trim - Front - LH (Remove and Install)
        • Panel - Door Trim - Front - LH (Remove and Replace)
        • Panel - Door Trim - Rear - LH (Remove and Replace)
        • Reflector - Door - Front - LH (Remove and Replace)
        • Switch - Window - Driver (Remove and Replace)
        • Switch - Window - Front Passenger (Remove and Replace)
        • Ambient Light - Front Door (Remove and Replace)
        • Ambient Light - Rear Door (Remove and Replace)
        • Puddle Lamp - Front Door (Remove and Replace)
        • Puddle Lamp - Rear Door (Remove and Replace)
        • Switch - Interior Door Release - Rear - LH (Remove and Replace)
        • Switch Window - Rear (Remove and Replace)
        • NVH Pad - Door - Rear - LH (Remove and Replace)
      • 1518 - Pillar and Sill Trim
        • Trim - A-Pillar - Lower - LH (Remove and Replace)
        • Trim - A-Pillar - Upper - LH (Remove and Replace)
        • Bracket - B-Pillar - LH (Remove and Replace)
        • Trim - B-Pillar - Lower - LH (Remove and Replace)
        • PE Foam - B-Pillar - Middle - LH (Remove and Replace)
        • Trim - B-Pillar - Middle - LH (Remove and Replace)
        • Trim - B-Pillar - Upper - LH (Remove and Replace)
        • Trim - C-Pillar - LH (Remove and Replace)
        • Bracket - C-Pillar - LH (Remove and Replace)
        • Trim - Side Rail - LH (Remove and Replace)
        • Trim - Trunk Sill (Remove and Replace)
      • 1519 - Center Console
        • Outlet - 12V - Center Console (Remove and Replace)
        • Air Wave - Center Console (Remove and Replace)
        • Hinge - Armrest - Center Console (Remove and Replace)
        • Inertia Lock - Armrest (Remove and Replace)
        • Armrest - Inner - Center Console (Remove and Replace)
        • Armrest - Outer - Center Console (Remove and Replace)
        • Center Console (Remove and Replace)
        • CloseOut - Center Console (Remove and Replace)
        • Switch - Console Light (Remove and Replace)
        • Panel - Rear End - Center Console (Remove and Replace)
        • Carpet - Side - Center Console - LH (Remove and Replace)
        • Carpet - Side - Center Console - RH (Remove and Replace)
        • Structure - Center Console (Remove and Replace)
        • Sliding Lid - Center Console (Remove and Replace)
        • Front Bin - Center Console (Remove and Replace)
        • Decor Trim - Center Console - LH (Remove and Replace)
        • Puddle Lamp - Center Console (Remove and Replace)
        • Module - Rear End - Center Console (Remove and Replace)
        • Panel - Rear Side - Center Console - LH (Remove and Replace)
        • Top Panel - Center Console (Remove and Replace)
        • USB Module - Center Console (Remove and Replace)
        • Vent Cover - Center Console (Remove and Replace)
        • Wireless Charger Module - Center Console
        • Armrest - Center Console (Remove and Install)
        • Sliding Door Assembly - Center Console (Remove and Replace)
        • Phone Dock (Clip) - Interior Trim - Center Console (Remove and Replace)
        • Phone Dock (Screw) - Interior Trim - Center Console (Remove and Replace)
      • 1520 - Headliner
        • Coat Hook - LH (Remove and Replace)
        • Microphone - Headliner (Remove and Replace)
        • Headliner (Remove and Replace)
        • Visor Check - Magnetic (Remove and Replace)
        • Overhead Console - Front (Remove and Replace)
        • Map Light - Rear (Remove and Replace)
      • 1530 - Carpeting and Mats
        • Insulator - Stuffer - Wheelhouse (Remove and Replace)
        • Insulator - Dash (Remove and Replace)
        • Kit - Floor Mat - LHD (Remove and Replace)
        • Carpet - Front - LH (Remove and Replace)
        • Carpet - Rear (Remove and Replace)
        • Carpet - Front - RH (Remove and Replace)
        • Load Floor - Trunk (Remove and Replace)
        • Bracket - Trunk Load Floor - LH (Remove and Replace)
        • Lamp - Trunk (Remove and Replace)
        • Front Carpet - Rear Trunk (Remove and Replace)
        • Trim - Side - Trunk - LH (Remove and Replace)
        • Tub Carpet - Rear Trunk (Remove and Replace)
    • 16 - Battery System
      • Torque Specifications - Battery System
      • 1601 - HV Battery Assembly
        • Flood Port (Remove and Replace)
        • HV Battery (AWD) \(Remove and Replace\)
        • Header - HV - A/C Compressor - HV Battery (Remove and Replace)
        • Header - HV - Rear Drive Unit - HV Battery (Remove and Replace)
        • Passthrough - DCDC - LV (Cable Type) (Remove and Replace)
        • Snap In Vent - HV Battery - Rear (Remove and Replace)
        • Ski Cover - HV Battery - Center (Remove and Replace)
        • HV Battery (RWD) \(Remove and Replace\)
        • NVH Pad - HV Battery (Remove and Replace)
        • Engagement Seal - Ancillary Bay (Remove and Replace)
        • Skid Plate - HV Battery - Rear (Remove and Replace)
        • High Voltage Battery Assembly - Front Skid Plate Bracket (Remove and Replace)
      • 1610 - HV Battery Enclosure
        • Ancillary Bay Air Leak Test (Inspection)
        • Skid Plate - HV Battery - Front (Remove and Replace)
        • HV Battery Air Leak Test
        • HV Battery Assembly - High Voltage Battery Assembly - Vent with Shroud - Pair (Remove and Replace)
        • Platter Enclosure Air Leak Test
      • 1620 - HV Battery Cooling System
        • Ancillary Bay Coolant (Drain and Refill)
        • Coolant - HV Battery (Drain and Refill)
        • Ancillary Bay Coolant Leak Test (Inspection)
        • Platter Enclosure Coolant Leak Test
      • 1630 - HV Battery Electrical Components
        • DC Link - Positive - Ancillary Bay (Remove and Replace)
        • Fast Charge Contactor (Remove and Replace)
        • Harness - AC Filter (Remove and Replace)
        • Harness - AC Filter (3-Phase) (Remove and Replace)
        • Hose - Inlet - Power Conversion System (Remove and Replace)
        • Hose - Outlet - Power Conversion System (Remove and Replace)
        • Insulator - FastCharge - Lower (Remove and Replace)
        • HV Pack Contactor (Remove and Replace)
        • PCS Assembly (Remove and Replace)
        • Ancillary Bay Cover (Remove and Replace)
        • Probe Lid - Ancillary Bay Cover (Remove and Replace)
        • HV Battery Contactor Seize Check
        • Shunt - Ancillary Bay (Remove and Replace)
        • Busbar - Fast Charge - Input - Negative (Remove and Replace)
        • Busbar - Fast Charge - Input - Positive (Remove and Replace)
        • Busbar - Fast Charge Contactor to DC Bus - Negative (Remove and Replace)
        • Busbar - Fast Charge Contactor to DC Bus - Positive (Remove and Replace)
        • Cover - Busbar Module 3 to Shunt - Ancillary Bay (Remove and Replace)
        • Cover - Left Terminals - Ancillary Bay (Remove and Replace)
        • Pyro Disconnect - HV Battery (Remove and Replace)
        • Tab - Fuse 63A 700VDC (Remove and Replace)
        • Hinge - Tray - HV Controller (Remove and Replace)
        • Header - Busbar DC Input (Remove and Replace)
        • HV Dummy Header (Remove and Replace)
        • Insulator - Fast Charge Access (Remove and Replace)
        • Insulator - Access - Shunt (Remove and Replace)
        • Insulators - HV Battery (Remove and Install)
        • PCBA - HV System Controller (Remove and Replace)
        • Seal - Probe Lid - Ancillary Bay Cover (Remove and Replace)
        • Controller - High Voltage (Backup and Restore)
        • Harness - Ancillary Bay
    • 17 - Electrical
      • Torque Specifications - Electrical
      • 1701 - LV Battery and Fuses
        • LV Battery - Li-lon (Disconnect and Connect)
        • LV Battery - Recover
        • LV Battery (Remove and Replace)
        • LV Maintainer (Connect and Disconnect) (Maintenance)
        • Vehicle HV Disablement Procedure
      • 1710 - Harnesses
        • Rear Bumper and Subframe Harnesses - Rear Subframe Harness (Remove and Replace)
        • Harness - HVAC (Remove and Replace)
        • Harness - Center Console Extension (Remove and Replace)
        • Harness - Center Console (Remove and Replace)
        • Harness - Front Door Trim - Driver (Remove and Replace)
        • Harness - Instrument Panel Trim - LH (LHD) (Remove and Replace)
        • Harness - Instrument Panel Trim - RH (LHD) (Remove and Replace)
        • IP Harness (LHD) (NA) (Remove and Replace)
        • Harness - Trunk Lid (Remove and Replace)
        • Harness - Front Door - LH (Remove and Replace)
        • Harness - Trunk Lid Trim (Remove and Replace)
        • Harness - Rear Door - LH (Remove and Replace)
        • Harness - Rear Door Trim - LH (Remove and Replace)
        • Harness - Front End Module (Remove and Replace)
        • Harness - Fascia -Front (Remove and Replace)
        • Harness - Headliner (Remove and Replace)
        • Harness - Parcel Shelf (Gen 2) (EU) (Remove and Replace)
        • Ground Strap - Rear Defrost (Remove and Replace)
        • Harness - Main Front (Remove and Replace)
        • Harness - Body - RH (LHD) (Remove and Replace)
        • Harness - Body - LH (NA/EU) (Remove and Replace)
        • Harness - Busbar - 12V DCDC (Remove and Replace)
        • Harness - Front Subframe (Dual Motor) (Remove and Replace)
        • Harness - Fascia - Rear (Remove and Replace)
        • Harness - 1st Row Seat - RH (Remove and Replace)
        • Harness - 1st Row Seat - LH (Remove and Replace)
        • Jumper Harness - B2B - Ethernet (Remove and Replace)
        • Harness - Sub Assembly - Thermal (Remove and Replace)
        • Harness - Windshield (Remove and Replace)
      • 1715 - Electronic Control Modules
        • Module - Body Controller - Front (Gen 3) (Remove and Replace)
        • Module - Body Controller - LH (Remove and Replace)
        • Module - Body Controller - RH (Remove and Replace)
        • Shield - Body Controller - Front (Remove and Replace)
        • Module - Homelink Transmitter (Remove and Replace)
        • Vehicle Controller - USB Assembly (Remove and Replace)
      • 1720 - Radar Sensor
        • Radar - Cabin (Remove and Replace)
      • 1723 - Front Cameras
        • Camera - B-Pillar - LH (Remove and Replace)
        • Camera - Forward Facing (Remove and Replace)
        • Camera - Sider Repeater - LH (Remove and Replace)
      • 1724 - Interior Camera
        • Fan - Triple Cam (Remove and Replace)
        • Camera - Interior (LHD) (Remove and Replace)
      • 1725 - Rear Cameras
        • Camera - Rear Facing (Remove and Replace)
      • 1740 - Exterior Lights
        • Headlights - Adjust - NA (Tool Method)
        • Headlights - Adjust - Global (Wall Method)
        • Side Repeater - LH (Remove and Replace)
        • Headlight - LH (ECE) (Remove and Replace)
        • Reflex Assembly - Electrical - Exterior Lights - Tail Lights - RH (Remove and Replace)
        • Trunk Lid Light - LH (Remove and Replace)
        • Licens Plate Light (Remove and Replace)
        • Rear Fascia Light - LH (Remove and Replace)
        • Light - Brake - Center High Mounted (Remove and Replace)
      • 1745 - Keyless Entry and Security
        • Module - BLE - Interior (Remove and Replace)
        • Module - BLE - Rear (Remove and Replace)
        • BLE Assembly - Rear - LH (Remove and Replace)
        • Key Card (Remove and Replace)
        • Key Card (Remove and Replace)
      • 1750 - Wipers and Washers
        • Cap - Coolant Reservoir (Remove and Replace)
        • Assembly - Reservoir - Windshield Washer (Remove and Replace)
        • Nozzle - Windshield Washer (Adjust)
        • Electrical - Wipers and Washers - Windshield Washer Bottle and Pump - Connection Hose Assembly (Remove and Replace)
        • Wiper Blades (Adjust)
        • Wiper Blades - Pair (Remove and Replace)
        • Wiper Module (LHD) (Remove and Replace)
        • Reservoir - Windshield Washer (Remove and Replace)
        • Grommet - Sensor - Level - Windshield Washer (Remove and Replace)
        • Sensor - Level - Windshield Washer (Remove and Replace)
        • Grommet - Pump - Windshield Washer (Remove and Replace)
        • Pump - Windshield Washer (Remove and Replace)
        • Wiper Module (RHD) (Remove and Replace)
        • Wiper Arm - Driver Side (Remove and Replace)
        • Wiper Blade - Driver Side (Remove and Replace)
      • 1754 - Pedestrian Warning Speaker
        • Speaker - Pedestrian Warning (Remove and Replace)
    • 18 - Thermal Management
      • Torque Specifications - Thermal Management
      • 1810 - Cabin HVAC
        • Air Extractor (Remove and Replace)
        • Sensor - Cabin Temperature - Fan Driven (Remove and Replace)
        • Actuator - HVAC (Remove and Replace)
        • Blower Motor - HVAC (Remove and Replace)
        • Combination Filter - HVAC (Remove and Replace)
        • Assembly - Fresh Air Gutter - HVAC (Remove and Replace)
        • Fresh Air Intake - HVAC (Remove and Replace)
        • Harness - HVAC (Remove and Replace)
        • HVAC Assembly (Remove and Replace)
        • NVH Seal - HVAC (Remove and Replace)
        • Actuator - Upper and Lower - HVAC (Remove and Replace)
        • Thermistor Duct - HVAC (Remove and Replace)
        • Thermistor Evaporator - HVAC (Remove and Replace)
        • Duct - Floor - 2nd Row - LH (Remove and Replace)
        • Duct - Floor - 2nd Row - RH (Remove and Replace)
        • Duct - Thermistor - Lower - LH (Remove and Replace)
        • Vehicle Sanitation - Evaporator - Tunap 994 - (EMEA)
        • Vehicle Sanitation - Interior Air - Tunap 589 - (EMEA)
      • 1820 - Refrigerant System
        • Assembly - A/C Line - Supermanifold to HVAC (Remove and Replace)
        • Assembly - A/C Line - Supermanifold to Compressor (Remove and Replace)
        • Diagnosis: Detecting Refrigerant Leaks (Add Refrigerant Part if Needed) (General Diagnosis)
        • A/C Refrigerant (Recovery and Recharge) (Maintenance)
        • A/C Refrigerant (Unknown Oil Quantity) (Heat Pump) (Recovery, Flush, and Recharge) (Maintenance)
        • Bracket Assembly - A/C Compressor (Remove and Replace)
        • Acoustic Blanket - A/C Compressor (Remove and Replace)
        • A/C Compressor (Remove and Replace)
        • Cooling Fan Module (Remove and Replace)
      • 1830 - Cooling System
        • Hose - HV Battery Return (Remove and Replace)
        • Cooling System (Check and Fill)
        • Cooling System - Drain and Refill
        • Cooling System (Partial Refill and Bleed)
        • Cooling System - Vacuum Refill
        • Assembly - Cooling Fan and Shroud (Remove and Replace)
        • Radiator (Remove and Replace)
        • Hose - Chiller to HV Battery (LHD) (Remove and Replace)
        • Hoses - Hose, Chiller To Battery, LHD (RWD)
        • Hose - Return - Front Drive Unit Bypass (Remove and Replace)
        • Hose - Front Drive Unit to Oil Cooler (Remove and Replace)
        • Hose - Return - Front Drive Unit Return (Remove and Replace)
        • Hose - Powertrain Supply (Remove and Replace)
        • Hose - Radiator Inlet (Remove and Replace)
        • Hose - Radiator Outlet (Remove and Replace)
        • Hose - Outlet - Rear Drive Unit (Remove and Replace)
        • Hose - Inlet - Front Drive Unit Inverter (Remove and Replace)
        • Hose - Inlet - Rear Drive Unit Inverter (Remove and Replace)
        • Hose - Rear Drive Unit to Oil Coller (Remove and Replace)
        • Hose - Front Manifold (Remove and Replace)
        • Hose - HV Battery Return (Remove and Replace)
        • Tube (Powertrain) - Rear Powertrain Return
        • Tube- Rear Powertrain Supply
      • 1840 - Supermanifold
        • Check Valve - Cabin Condenser (Remove and Replace)
        • Coolant Pump - HV Battery (Remove and Replace)
        • Cap - Coolant Reservoir (Remove and Replace)
        • Octovalve (Remove and Replace)
        • PT Sensor - High Pressure (Remove and Replace)
        • PT Sensor - Low Pressure (Remove and Replace)
        • Service Kit - Chiller (Remove and Replace)
        • Service Kit - Coolant Reservoir (Remove and Replace)
        • Service Kit - Coolant Pump (Remove and Replace)
        • Service Kit - Liquid Cooled Condenser (Remove and Replace)
        • SOV Core - Supermanifold (Remove and Replace)
        • Check Valve - Evaporator (Remove and Replace)
        • Check Valve - Supermanifold (Remove and Replace)
        • EXV Coil - Supermanifold (Remove and Replace)
        • EXV Core - Supermanifold (Remove and Replace)
        • Desiccant (Remove and Replace)
        • SOV Coil - Supermanifold (Remove and Replace)
        • Supermanifold (Remove and Replace)
      • 1850 - Air Distribution
        • Active Grill Shutter (Remove and Replace)
        • Sensor - Ambient Air Temperature (Remove and Replace)
    • 20 - Safety and Restraint
      • Torque Specifications - Safety and Restraint
      • 2001 - Airbags
        • Airbag - Driver (Remove and Replace)
        • Harness - Airbag - Driver (Remove and Replace)
        • Airbag - Front Passenger (NA) (Remove and Replace)
        • Airbag - Front Passenger (Remove and Replace)
        • Airbag - Knee - LH (Remove and Replace)
        • Airbag - Knee - RH (Remove and Replace)
        • Remove the Front Seat Airbag and Discard
        • Airbag - Curtain - LH (LHD) (Remove and Replace)
        • Airbag - Curtain - RH (RHD) (Remove and Replace)
        • Remove the Front Seat Airbag and Discard
      • 2005 - Seatbelts
        • Height Adjuster - Seatbelt - LH (Remove and Replace)
        • Buckle - Seatbelt - 1st Row - LH (Remove and Replace)
        • Retractor - Seatbelt - Driver (Remove and Replace)
        • Retractor - Seatbelt - 2nd Row - Center (Remove and Replace)
        • Buckle - Seatbelt - 2nd Row - RH and Center (Remove and Replace)
        • Buckle - Seatbelt - 2nd Row - LH (Remove and Replace)
        • Sensor - Occupant - Front Seat - LH (Seat Belt Reminder) (Remove and Replace)
        • Webbing Guide Bar - Seatbelt - 1st Row (Single Side) (Remove and Replace)
        • 1st Row Seat Belts -Service Kit - OCS (Rework)
        • Retractor - Seatbelt - 2nd Row - Outboard (Single Side) (Remove and Replace)
        • 2nd Row Seat Belts - Rear SBR Assembly - Occupant Switch 3 Position (Remove and Replace)
      • 2010 - Pretensioners
        • Pretensioner - Driver (Remove and Replace)
      • 2020 - Sensors
        • Sensor - Pressure - Door - Front - LH (Remove and Replace)
        • Module - Restraint Control - Universal (Remove and Replace)
        • Sensor - Impact Accelerator - Front Bumper - Center (Remove and Replace)
        • Sensor - Impact Accelerator - Front Bumper - LH (Remove and Replace)
        • Sensor - Impact Accelerometer - B-Pillar - LH (Remove and Replace)
        • Sensor - Pressure Tube - Pedestrian Protection (Remove and Replace)
      • 2030 - Pedestrian Protection System
        • Actuator - Pedestrian Protection - Active Hood - LH (Remove and Replace)
    • 21 - Infotainment
      • Torque Specifications - Infotainment
      • 2105 - Touchscreen
        • SD Card - Car Computer (Remove and Replace)
        • Touchscreen - Rear (Remove and Replace)
        • Service Panel - Instrument Panel (Remove and Replace)
        • Touchscreen - Front (Remove and Replace)
      • 2115 - Car Computer
        • Car Computer (Dispose)
        • Car Computer (LHD) (Remove and Install)
        • Car Computer (Remove and Replace)
        • Drip Guard - Car Computer (Remove and Replace)
      • 2121 - Audio System - Speakers Subwoofer Amplifier
        • Speaker - Headliner - LH (Remove and Replace)
        • Super Horn (Remove and Replace)
        • Speaker - Dash - Center (Remove and Replace)
        • Speaker - Dash - LH (Remove and Replace)
        • Speaker - Front Door - LH (Remove and Replace)
        • Amplifier - Audio - External (Remove and Replace)
        • Woofer - Parcel Shelf (Remove and Replace)
      • 2135 - Antennas and Amplifiers
        • SIM Card - Car Computer (Remove and Replace)
        • GNSS Antenna (Remove and Replace)
        • Telematics Control Unit (TCU) (Remove and Replace)
        • Tuner FM/HD/DAB (Remove and Replace)
    • 30 - Chassis
      • Torque Specifications - Chassis
      • 3001 - Chassis and Subframes
        • Subframe Assembly -Front (Remove and Replace)
        • Subframe Assembly - Rear (Partial Drop) (Remove and Install)
        • Subframe Assembly - Rear (Remove and Replace)
        • Shear Plate - Rear Subframe - LH (Remove and Replace)
    • 31 - Suspension
      • Torque Specifications - Suspension
      • Alignment Requirement - Suspension
      • 3100 - Adjustment
        • Four Wheel Alignment Check and Adjust
        • Four Wheel Alignment Check (No Adjustment Needed)
      • 3101 - Front Suspension (Including Hubs)
        • Bracket - Bushing - Front Stabilizer Bar - LH (Remove and Replace)
        • Control Arm - Upper - Front - LH (Remove and Replace)
        • Hub Assembly - Front - LH (Dual Motor) (Remove and Replace)
        • Hub Assembly - Front - LH (RWD) (Remove and Replace)
        • Knuckle - Front - LH (Remove and Replace)
        • Link - Compliance - Lower - Front - LH (Remove and Replace)
        • Link - Compliance - Lower - Front - Pair (Remove and Replace)
        • Link - Lateral - Lower - Front - Pair (Remove and Replace)
        • Link - Lateral - Lower - Front - LH (Remove and Replace)
        • Link - Stabilizer Bar - Front - LH (Remove and Replace)
        • Stabilizer Bar - Front (Remove and Replace)
        • Suspension - Front (Check Torque)
      • 3103 - Rear Suspension (Including Hubs)
        • Hub - Rear - LH (Remove and Replace)
        • Knuckle - Rear - LH (Remove and Replace)
        • Link - Aft - Lower - Rear - LH (Remove and Replace)
        • Link - Aft - Upper - Rear - LH (Remove and Replace)
        • Link - Fore - Lower - Rear - LH (Remove and Replace)
        • Link - Fore - Upper - Rear - LH (Remove and Replace)
        • Link - Fore - Upper - Rear - RH (Remove and Replace)
        • Link - Stabilizer Bar - Rear - LH (Remove and Replace)
        • Stabilizer Bar - Rear (Remove and Replace)
        • Suspension - Rear (Check Torque)
        • Toe link - Rear - LH (Remove and Replace)
      • 3115 - Coil Suspension System
        • Coil Spring - Rear - LH (Dual Motor) (Remove and Replace)
        • Damper - Front - LH (Dual Motor) (Remove and Replace)
        • Damper - Rear - LH (Remove and Replace)
        • Isolator - Mount - Front Upper Control Arm - LH (Remove and Replace)
        • Isolator - Rear Spring - Lower - LH (Remove and Replace)
        • Isolator - Rear Spring - Upper - LH (Remove and Replace)
        • Mount - Front Upper Control Arm - LH (Remove and Replace)
    • 32 - Steering
      • Torque Specifications - Steering
      • 3201 - Steering Rack and Lower Column
        • Steering Rack (Dual Motor) (RHD) (Remove and Replace)
        • Steering Rack (LHD) (Remove and Replace)
        • Tie Rod End - LH (Remove and Replace)
      • 3205 - Upper Column Steering Wheel Steering Lock
        • Bright Surround - Steering Wheel Spoke (Remove and Replace)
        • Cover - Lower Spoke - Steering Wheel (Remove and Replace)
        • Gap Hider - Steering Column - Upper (Remove and Replace)
        • Harness - Steering Wheel (Remove and Replace)
        • Module - Steering Column Control (Remove and Replace)
        • Shroud - Steering Column - Lower (Remove and Replace)
        • Steering Column (LHD) (Remove and Replace)
        • Steering Column (RHD) (Remove and Replace)
        • Steering Wheel (Remove and Replace)
        • Switch - Steering Wheel - LH (Remove and Replace)
    • 33 - Brakes
      • Torque Specifications - Brakes
      • 3301 - Brake Discs and Calipers
        • Brake Caliper - Front (Sport Brakes) - LH (Remove and Replace)
        • Brake Caliper - Front (Sport Brakes) - RH (Remove and Replace)
        • Brake Caliper - Rear (Base Brakes) - LH (Remove and Replace)
        • Brake Caliper - Rear (Sport Brakes) - LH (Remove and Replace)
        • Brake Caliper - Rear (Sport Brakes) - RH (Remove and Replace)
        • Brake Pad Kit - Front (Base Brakes) (Remove and Replace)
        • Brake Pad Kit - Front (Sport Brakes) (Remove and Replace)
        • Brake Pad Kit - Rear (Base Brakes) (Remove and Replace)
        • Brake Pads - Burnishing
        • Brake Rotor - Front - LH (Measure Runout)
        • Brake Rotor - Front (Base Brakes) - LH (Remove and Replace)
        • Brake Rotor - Rear - LH (Measure Runout)
        • Brake Rotor - Rear (Base Brakes) - LH (Remove and Replace)
        • Clean And Lubricate Brake Calipers (Non-Performance Brakes) (Requires Code 34012501) (Maintenance)
        • Clean And Lubricate Brake Calipers (Performance Brakes) (Requires Code 34012501) (Maintenance)
        • Bracket - EPB Harness (Base Brakes) - LH (Remove and Replace)
        • Brake Shield - Front (Base Brakes) - LH (Remove and Replace)
        • Brake Shield - Rear (Base Brakes) - LH (Remove and Replace)
      • 3303 - Brake Pipes and Hoses
        • Jounce Hose - Front Brake - LH (Remove and Replace)
        • Assembly - Brake Lines - Master Cylinder to HCU (RHD) (Remove and Replace)
        • Brake Fluid Bleed/Flush (Maintenance)
        • Brake Fluid Bleed - One Caliper \(Remove and Replace\)
        • Brake Fluid Check
        • Junction Block - Brake Line (Remove and Replace)
        • Assembly - Brake Lines - Master Cylinder to HCU (LHD) (Remove and Replace)
        • Assembly - Brake Lines - Front (Remove and Install)
        • Assembly - Brake Lines - Rear - LH (Remove and Install)
        • Assembly - Brake Lines - Rear - RH (Remove and Replace)
        • Jounce Hose - Rear Brake (Remove and Replace)
      • 3305 - Parking Brake
        • Parking Brake - Caliper - Rear - LH (Release)
      • 3310 - ABS Traction and Stability Control
        • Brake Hydraulic Control Unit (Remove and Replace)
        • Sensor - Wheel Speed - Front - LH (Performance) (Remove and Replace)
        • Sensor - Wheel Speed - Front - LH (Remove and Replace)
        • Sensor - Wheel Speed - Rear - LH (Remove and Replace)
      • 3320 - Brake Booster
        • Assembly - Brake Booster and Master Cylinder (LHD) (Remove and Replace)
        • Assembly - Brake Booster and Master Cylinder (RHD) (Remove and Replace)
      • 3325 - Brake Pedal
        • Assembly - Brake Pedal (LHD) (Remove and Replace)
        • Clevis Pin - Brake Pedal (Remove and Replace)
        • Assembly - Brake Pedal (RHD) (Remove and Replace)
    • 34 - Wheel and Tires
      • Torque Specifications - Wheels and Tires
      • 3401 - Wheels
        • Wheel Assembly (Remove and Install)
        • Wheel Trim - Performance (Remove and Install)
        • Wheel - Front - LH (Remove and Replace)
      • 3402 - Tires
        • Replacement Tire Information
        • Tire Rotation
        • Tire - Front - LH (Balance)
        • Tire - Front - LH (Road Force) (Balance) (Tire Repair)
      • 3404 - Tire Pressure Monitoring System (TPMS)
        • Sensor - TPMS (Remove and Replace)
        • TPMS (Sensor ID Drive Learn)
        • TPMS (Sensor ID Tool Learn)
    • 39 - Front Drive Unit
      • Torque Specifications - Front Drive Unit
      • 3901 - Front Drive Unit Assembly
        • Breather Assembly - Front Drive Unit (3DU) (Remove and Replace)
        • Bushing - Front Drive Unit - RH (3DU) (Remove and Replace)
        • Bushing - Gearcase - Front Drive Unit (3DU) (Remove and Replace)
        • Cover Assembly - Phase Out - Front Dreive Unit (3DU) (Remove and Replace)
        • Drive Unit - Front (3DU) (Remove and Replace)
        • Filter - Oil - Front Drive Unit (3DU) (Remove and Replace)
        • Ground Straps - Front Drive Unit (Remove and Replace)
        • Heat Exchanger - Front Drive Unit (3DU) (Remove and Replace)
        • Isolator - Motor Mount - Front - RH (Remove and Replace)
        • Mount Assembly - Front Drive Unit - LH (3DU) (Remove and Replace)
        • Oil Pump - Electric - Front Drive Unit (Remove and Replace)
      • 3920 - Front Drive Inverter
        • Fluid Coupling (90 Degrees) - Front Drive Inverter (Remove and Replace)
        • Fluid Coupling (Straight) - Front Drive Inverter (Remove and Replace)
        • Inverter - Front Drive Unit (3DU) (Remove and Replace)
        • Seal - Inverter - Gearbox (3DU) (Remove and Replace)
      • 3930 - Front Gearbox and Halfshafts
        • Gearbox Fluid - Front Drive Unit (3DU) (Drain and Refill)
        • Halfshaft - Front Drive Unit - LH (Lubricate at Hub)
        • Halfshaft - Front Drive Unit - LH (Remove and Replace)
        • Seal - Axle - Output - Front Drive Unit (3DU) (Remove and Replace)
    • 40 - Rear Drive Unit
      • Torque Specifications - Rear Drive Unit
      • 4001 - Rear Drive Unit Assembly
        • Axle Seal - Output - Rear Drive Unit (3DU) (Remove and Replace)
        • Axle Seal - Output - Rear Drive Unit (4DU) (Remove and Replace)
        • Breather - Rear Drive Unit (3DU) (Remove and Replace)
        • Breather - Rear Drive Unit (4DU) (Remove and Replace)
        • Bushing - Gearcase - Rear Drive Unit (3DU) (Remove and Replace)
        • Bushing - Gearcase - Rear Drive Unit (4DU) (Remove and Replace)
        • Bushing - Rear Drive Unit - RH (3DU) (Remove and Replace)
        • Bushing - Rear Drive Unit - RH (4DU) (Remove and Replace)
        • Cover - Phase Out - Rear Drive Inverter (4DU) (Remove and Replace)
        • Cover - Phase Out - Rear Drive Unit (3DU) (Remove and Replace)
        • Drive Unit - Rear (4DU) (Remove and Replace)
        • Filter - Oil - Rear Drive Unit (3DU) (Remove and Replace)
        • Ground Strap - Rear Drive Unit (Remove and Replace)
        • Heat Exchanger - Rear Drive Unit (3DU) (Remove and Replace)
        • Heat Exchanger - Rear Drive Unit (4DU) (Remove and Replace)
        • Label - High Voltage Marking - Rear Drive Unit (4DU) (Remove and Replace)
        • Mount - Rear Drive Unit - LH (3DU) (Remove and Replace)
        • Mount - Rear Drive Unit - LH (4DU) (Remove and Replace)
        • Oil Pump - Electric - Rear Drive Unit (4DU) (Remove and Replace)
        • Oil Pump - Electric - Tesla - Rear Drive Unit (Remove and Replace)
        • Rear Drive Unit - Mosfet - HC (3DU) (Remove and Replace)
      • 4020 - Rear Drive Inverter
        • Inverter Air Leak Test (Inspection)
        • Inverter Coolant Leak Test (Inspection)
        • Powertrain Coolant - Rear (Drain and Refill)
        • Drive Unit - Rear Drive Inverter (4DU) (Remove and Replace)
        • Rear Drive Inverter (3DU) (Remove and Replace)
        • Fluid Coupling (55 Degrees) - Rear Drive Inverter (Remove and Replace)
        • Fluid Coupling (Straight) - Rear Drive Inverter (Remove and Replace)
        • HV Header - Rear Drive Inverter (3DU) (Remove and Replace)
        • Gearbox Seal - Rear Drive Inverter (3DU) (Remove and Replace)
      • 4030 - Rear Gearbox and Halfshafts
        • Gearbox Fluid - Rear Drive Unit (3DU) (Drain and Refill) (Remove and Replace)
        • Half shaft - Rear Drive Unit - LH (Lubricate at Hub)
        • Halfshaft - Rear Drive Unit - LH (Remove and Replace)
    • 44 - High Voltage System
      • Torque Specifications - High Voltage System
      • 4401 - Charge System Inlet
        • Actuator - Charge Port (Gen 3) (Remove and Replace)
        • Bracket - Cable Release - Charge Port (Remove and Replace)
        • Retainer Bracket - Charge Port (Remove and Replace)
        • Charge Port Voltage Check
        • Chargeport (EU) (Remove and Replace)
        • Charge Port (EU) (Remove and Replace)
        • Charge Port (NA) (Remove and Replace)
        • ECU - Charge Port (Gen4) (Remove and Replace)
        • Charge Port - Manual Release of Cable
        • Door Assembly - Charge Port (China) (Remove and Replace)
        • Door Assembly - Charge Port (EU) (Remove and Replace)
        • Door - Charge Port (NA) (Remove and Replace)
        • Elbow - Drain Tube Assembly (Remove and Replace)
        • Tube Assembly - Charge Port (Remove and Replace)
        • Safety Cap - Busbar - Charge Port to HV Battery (3-Phase) (Remove and Replace)
      • 4450 - HV Harnesses
        • HV Harness - HV Battery to Rear Drive Unit (Remove and Replace)
        • Cable Kit - Charge Port (3 Phase) (EU) (Remove and Replace)
        • Bracket - High Voltage - Ski - Bottom (Remove and Replace)
        • Bracket - High Voltage - Ski - Top (Remove and Replace)
        • Connector - Battery Side - Charge Port to HV Battery Busbar (Remove and Replace)
        • HV Harness - Ancillary Bay (Remove and Replace)
        • Busbar - Charge Port to HV Battery (China) (Remove and Replace)
        • HV Harness - A/C Compressor (Remove and Replace)
        • HV Harness - HV Battery to Front Drive Unit (Remove and Replace)
    • © Tesla 2024
    • Feedback

    Crowsfoot or Offset Wrench Extension Calculator

    Torque Calculator Values
    Note
    1. If the angle from the extension to the torque wrench is greater than 90° (Figure 2), input E as a positive number.
    2. If the angle from the extension to the torque wrench is less than 90° (Figure 3), input E as a negative number.
    3. If the angle from the extension to the torque wrench is exactly 90°, this calculator is not needed. Torque the fastener to T1.
    Figure 1
    Figure 2
    Figure 3