Cybertruck Service Manual

    Pillar and Sill Trim - A-B-C Post Interior Trim - Illuminated A-Pillar Lower Trim - LH (Remove and Replace)

    1518

    This procedure is in development. Please reach out to ServiceDevelopment@tesla.com for questions and support.

    Parent topic: 1518 - Pillar and Sill Trim
    • Cybertruck Service Manual
    • Release Notes
      • Current Release Notes
      • Release Notes Archive
        • Release Notes January-March 2024
        • Release Notes April-June 2024
        • Release Notes July-September 2024
    • GENERAL INFORMATION
      • INTRODUCTION
        • Abbreviations and Symbols
        • Flat Rate Times
        • How To Use This Manual
        • Repairs and Replacements
        • Warranty Service Regions
      • BEST PRACTICES
        • Airbag and Supplementary Restraint System (SRS) Precautions
        • Air Conditioning System Precautions
        • Diagnostic Connector Location
        • Electrical Precautions
        • Environmental Precautions
        • Event Data Recorder Retrieval
        • Flexible Pipes and Hoses
        • General Fitting Instructions
        • General Precautions
        • Locking Devices
        • Oil Seals
        • Personal Protection
        • SRS Component Replacement Policy
        • Vehicle Cameras and Autopilot
        • Vehicle Weight Information and Lifting Precautions
      • CHARGING
        • Precautions
        • General
      • FLUIDS AND CAPACITIES
        • Fluids
        • Fluid Capacities
      • IDENTIFICATION NUMBERS
        • Vehicle and Wheel Paint Codes
        • Vehicle Identification Number (VIN)
      • TECHNICAL DATA
        • Suspension
        • Tire Pressures
        • Wheel Alignment
        • Wheels
    • 00 - INSPECTION AND SERVICE
      • 0001 - Scheduled Service
      • 0002 - Firmware Service
        • Software Reinstall - Touchscreen
        • Software Update (Over The Air)
      • 0005 - Service Modes
        • Gateway (Unlock)
        • Service Mode
        • Toolbox 3 (Connect and Disconnect)
    • 10 - BODY
      • 1000 - Vehicle Lifting
        • Raise Vehicle - 2 Post Lift
        • Raise Vehicle - Jack
      • 1001 - Bumper/Fascia
        • Front Bumper Carrier - Front End Carrier Plastic Assembly (Remove and Install)
        • Front Bumper Fascia - Front Fascia Fairing Assembly - LH (Remove and Install)
        • Front Bumper Fascia - Front Fascia Lower Camera Cover (Remove and Install)
        • Front Bumper Fascia - Front Fascia (Remove and Install)
        • Front Energy Absorber - Front Bumper Beam Assembly (Remove and Install)
        • Front Energy Absorber - Support Bracket - Center (Remove and Install)
        • Front Energy Absorber - Support Bracket - LH (Remove and Install)
        • Front Grille and Applique - Foam Seal - Side (Remove and Install)
        • Front Grille and Applique - Foam Seal - Upper/Lower (Remove and Install)
        • Front Grille and Applique - Front Center Applique Assembly (Remove and Install)
        • Front Grille and Applique - Front Lower Grille (Remove and Install)
        • Front Grille and Applique - Frunk Switch (Remove and Install)
        • Front Grille and Applique - Lower Tow Eye Cap - LH (Remove and Replace)
        • Rear Bumper Fascia - Body Side Bracket - LH (Remove and Install)
        • Rear Bumper Fascia - Fascia Step Bracket Center - LH (Remove and Install)
        • Rear Bumper Fascia - Rear Fascia (Remove and Install)
        • Rear Bumper Fascia - Rear Fascia (Remove and Replace)
        • Rear Bumper Fascia - Trailer Hitch Cover (Remove and Install)
        • Rear Energry Absorber - Cast Bumper Assembly - LH (Remove and Install)
        • Rear Energry Absorber - Center Bracket (Remove and Install)
        • Rear Energry Absorber - Fascia Step Bracket - Center (Remove and Install)
      • 1010 - Body Panels
        • Body Panel (Refinish)
        • Trim - Roof Rail - LH (Remove and Install)
        • Closure Panels - Assembly - Fender - Left (Remove and Install)
        • Closure Panels - Assembly - Fender - Left (Remove and Replace)
        • Closure Panels - Assembly - Front Door - Left (Remove and Install)
        • Closure Panels - Assembly - Powergate Fascia (Remove and Install)
        • Closure Panels - Assembly - Powergate Hood (Remove and Install)
        • Closure Panels - Assembly - Powergate Hood (Remove and Replace)
        • Closure Panels - Assembly - Rear Door - Left (Remove and Install)
        • Closure Panels - Assembly - Bed Side Outer - Left (Remove and Install)
        • Closure Panels - Assembly - Tailgate (Remove and Install)
        • Closure Panels - Assembly - Tailgate (Remove and Replace)
        • Closure Panels - Lamp Step Bracket - LH (Remove and Replace)
        • Closure Panels - Lamp Step Bracket - RH (Remove and Replace)
        • Closure Panels - Sail Applique Corner Bracket - RH (Remove and Install)
        • Front Bumper Fascia - Front Fascia Lower Dummy LP Cover (Remove and Install)
        • NVH Damping and Paint Armor - Dash Absorber - LH (Remove and Install)
        • NVH Damping and Paint Armor - Dash Absorber - RH (Remove and Install)
        • Powergate (Manual Release)
        • Body Panels - Rear Under Body - Rear Fascia Bracket - LH (Remove and Install)
      • 1020 - Windshield and Body Glass
        • Clear Forward Camera View (Precision Cleaning Of Inboard Windshield)
        • Door Glass - Front Quarter Glass Assembly - LH (Remove and Install)
        • Door Glass - Front Quarter Glass Seal, LH (Remove and Install)
        • Door Glass - Moving Glass - Front LH (Remove and Install)
        • Door Glass - Moving Glass - Rear LH (Remove and Install)
        • Fixed Glass Roof Assembly (Remove and Replace)
        • Windshield and Backlite - Fixed Glass Backlite (Remove and Install)
        • Windshield and Backlite - Header Seal, LH (Remove and Install)
        • Windshield and Backlite - Primary Seal Front, LH (Remove and Install)
        • Windshield and Backlite - Primary Seal Rear, LH (Remove and Install)
        • Windshield - Windshield Assembly (Remove and Replace)
        • Windshield - Windshield Front Edge Seal (Remove and Replace)
        • Windshield - Windshield Edge Seal - LH (Remove and Replace)
        • Windshield and Body Glass - Windshield and Backlite - Header Seal - LH (Remove and Install)
        • Windshield and Roof Glass Repair and Replacement Guidelines
      • 1030 - Paint
    • 11 - CLOSURE COMPONENTS
      • 1120 - Tonneau
        • Bushing Slat and Seal (Remove and Install)
        • Tonneau Applique (Remove and Install)
        • Tonneau - Bed Cargo Tub Strut (Remove and Install)
        • Tonneau - Flat Cassette Assembly - LH (Remove and Replace)
        • Tonneau - Manual Release, Tailgate (Remove and Install)
        • Tonneau - LH Tonneau Horizontal Rail Assembly (Remove and Install)
        • Tonneau - LH Tonneau Motor Assembly (Remove and Install)
        • Tonneau - Lower Assembly, Tonneau (Remove and Install)
        • Tonneau Slat Assembly - Slat System - Tonneau (Rework)
        • Tonneau - Tonneau NVH Barrier Assembly (Remove and Install)
        • Tonneau - Tonneau Rail - LH (Remove and Install) (Post 11/4/2024)
        • Tonneau - Tonneau Rail - RH (Remove and Install) (Post 11/4/2024)
        • Tonneau - Tonneau Slat Assembly - Chain Link (Remove and Install)
        • Tonneau - Tonneau Slat Assembly - Mid Slat (Remove and Install)
        • Tonneau - Tonneau Slat Assembly - Sealing Slat (Remove and Install)
        • Tonneau - Tonneau Slats (Manual Release)
        • Slat System - Tonneau (Remove and Install)
      • 1133 - Closure Assist Mechanisms and Hinges
        • Check Strap - Front Door - LH (Remove and Replace)
        • Door Presenter - Front Door - LH (Remove and Replace)
        • Door Presenter - Rear Door - LH (Remove and Replace)
        • Check Strap, Rear (Remove and Replace)
        • Front and Rear Door Latch and Striker - Door Latch - Front LH (Remove and Install)
        • Front and Rear Door Latch and Striker - Door Latch - Rear LH (Remove and Install)
        • Front and Rear Door Latch and Striker - Side Door Striker, Angle Base, Black (Remove and Install)
        • Hinges - Hinge, Powergate, LH (Remove and Install)
        • Hinges - Hood Strut (Remove and Install)
        • Latch - Powergate (Remove and Install)
        • Latch - Powergate (Remove and Replace)
        • Tailgate Latch and Striker - Bumpstop, Tailgate (Remove and Install)
        • Tailgate Latch and Striker - Cable Strap, Tailgate (Remove and Install)
        • Tailgate Latch and Striker - LH Body - Side Hinge, Tailgate (Remove and Install)
        • Tailgate Latch and Striker - LH Tailgate Cinching Latch (Remove and Install)
        • Tailgate Latch and Striker - RH Body - Side Hinge, Tailgate (Remove and Install)
        • Tailgate Latch and Striker - Striker, Powergate (Remove and Install)
        • Tailgate Latch and Striker - Striker, Tailgate (Remove and Install)
        • Tailgate Latch and Striker - Tailgate Strut Damper (Remove and Install)
        • Hinges - Door Hinge, Front LH Upper (Remove and Install)
        • Hinges - Door Hinge, Rear LH Upper (Remove and Install)
        • Closure Assist Mechanisms and Hinges - Hinges - Front Door Hinge - Lower - LH (Remove and Install)
        • Closure Assist Mechanisms and Hinges - Hinges - Rear Door - Lower Hinge - LH (Remove and Install)
      • 1135 - Latches, Strikers, and Pinch Sensors
      • 1140 - Interior Door Handles
      • 1145 - Exterior Door Handles
      • 1150 - Door Glass and Regulators
        • Front and Rear Door Glass - Front Moving Glass - LH (Adjust)
        • Front and Rear Door Glass - Rear Moving Glass - LH (Adjust)
        • Front and Rear Door Glass Regulator - Front Door LH Door Closeout Panel (Remove and Install)
        • Front and Rear Door Glass Regulator - Window Regulator, 48V Q-Motor (Remove and Install)
        • Front and Rear Door Glass Regulator - Window Regulator - Front LH (Remove and Install)
        • Front and Rear Door Glass Regulator - Window Regulator - Rear LH (Remove and Install)
      • 1170 - Seals Body Enclosures
        • Front and Rear Door Seals - Glass Run Seal, Front Door, A-Pillar (Remove and Install)
        • Front and Rear Door Seals - Inner Waist Belt Seal, Front Door, LH (Remove and Install)
        • Front and Rear Door Seals - Inner Waist Belt Seal, Rear Door, LH (Remove and Install)
        • Front and Rear Door Seals - Outer Waist Belt Seal, Front Door, LH (Remove and Install)
        • Front and Rear Door Seals - Outer Waist Belt Seal, Rear Door, LH (Remove and Install)
        • Front and Rear Door Seals - Secondary Seal, Front Door, LH (Remove and Install)
        • Front and Rear Door Seals - Secondary Seal, Rear Door, LH (Remove and Install)
        • Powergate Seals - Powergate Aero Seal, LH (Remove and Install)
        • Tailgate Seals - Tailgate, Seal, LH (Remove and Install)
        • Tailgate Seals - Tonneau Water Management Seal, LH, Center (Remove and Install)
        • Seals Body Closures - Front and Rear Door Seals - Front Door - Glass Run Seal - Inboard - LH (Remove and Install)
    • 12 - EXTERIOR FITTINGS
      • 1201 - Wheel Arch Liners
        • Wheel Arch Liners - Front Wheel Liner - LH (Remove and Replace)
        • Wheel Arch Liners - Rear Wheel Liner - LH (Remove and Install)
      • 1203 - Undertray and Diffuser
        • Undertray - Diffuser (Remove and Install)
        • Undertray - Front Aeroshield (Remove and Install)
        • Undertray - Lower Tub Crossmember Assembly (Remove and Install)
        • Undertray - Mid Aeroshield (Remove and Install)
        • Undertray - Rear Aeroshield (Remove and Install)
        • Undertray - Skid Plate (Remove and Install)
      • 1205 - Badges and Films
      • 1207 - License Plate Mountings
        • Bracket - License Plate - Front (Retrofit)
        • License Plate Mounting - Front License Plate Assembly (Remove and Install)
      • 1209 - Exterior Mirrors
        • Exterior Mirrors - Exterior Mirror Assembly - Electromechanical - LH (Remove and Install)
        • Exterior Mirrors - Exterior Mirror Glass - Flat - Electrochromic Dimming - LH (Remove and Install)
        • Exterior Mirrors - Skull Cap, Exterior Mirror, LH (Remove and Install)
      • 1215 - Truck Bed
        • Bed Cargo Tub - Bed Cargo Smugglers Bay (Remove and Install)
        • Bed Cargo Tub - Bed Cargo Tub Bumpstops (Remove and Install)
        • Bed Cargo Tub - Bed Cargo Tub Lid (Remove and Replace)
        • Bed Cargo Tub - Bed Cargo Tub Seal (Remove and Install)
        • Bed Side Wall - Bed Side Wall - LH (Remove and Install)
        • Bed Side Wall - Bed Tiedown Assembly - Fore - LH (Remove and Install)
        • Bed Side Wall - Forged Bed Tiedown Assembly (Remove and Install)
        • Truck Bed - Bed Floor Assembly (Remove and Install)
        • Truck Bed - False Wall Assembly (Remove and Install)
        • Truck Bed - Manual Release Cap Tailgate Cover (Remove and Install)
        • Truck Bed - Rear Bed Closeout - LH (Remove and Install)
        • Truck Bed - Tailgate Inner Cover (Remove and Install)
      • 1220 - Exterior Trim
        • Exterior Trim Fittings - Backlite Applique Assembly - LH (Remove and Install)
        • Exterior Trim Fittings - B-Pillar Applique - LH (Remove and Install)
        • Exterior Trim Fittings - Closeout - LH (Remove and Install)
        • Exterior Trim Fittings - C-Pillar Applique - LH (Remove and Install)
        • Exterior Trim Fittings - C-Pillar Applique Closeout - LH (Remove and Install)
        • Exterior Trim Fittings - Fascia Upper Applique Assembly (Remove and Install)
        • Exterior Trim Fittings - Fender Baffle - LH (Remove and Install)
        • Exterior Trim Fittings - Lightbar Beauty Cover Bracket - LH (Remove and Install)
        • Exterior Trim Fittings - Lightbar Beauty Cover - LH (Remove and Install)
        • Exterior Trim Fittings - Sail Baffle Applique - LH (Remove and Install)
        • Exterior Trim Fittings - Sail Baffle Closeout - LH (Remove and Install)
        • Exterior Trim Fittings - Roof Applique Bracket (Remove and Install)
        • Exterior Trim Fittings - Roof Applique - LH (Remove and Install)
        • Exterior Trim Fittings - Roof Applique - Standalone - LH (Rework)
        • Exterior Trim Fittings - Wiper Applique Assembly (Remove and Install)
        • Front and Rear Garnish - Carrier - Front Fender Flare Aft - LH (Remove and Install)
        • Front and Rear Garnish - Carrier - Front Fender Flare Fore - LH (Remove and Install)
        • Front and Rear Garnish - Carrier - Rear Fender Flare Aft - LH (Remove and Install)
        • Front and Rear Garnish - Carrier - Rear Fender Flare Aft - RH (Remove and Install)
        • Front and Rear Garnish - Carrier - Rear Fender Flare Fore - LH (Remove and Install)
        • Front and Rear Garnish - Rear Fender Flare Aft - LH (Remove and Install)
        • Front and Rear Garnish - Rear Fender Flare Fore - LH (Remove and Install)
        • Front and Rear Garnish - Rear Fender Flare - RH (Remove and Install)
        • Rocker Panel Trim - Front Rocker Step Reinforcement - LH (Remove and Install)
        • Rocker Panel Trim - Rear Rocker Step Reinforcement - LH (Remove and Install)
        • Rocker Panel Trim - Rocker Assembly - LH (Remove and Install)
        • Fairing - Rocker Panel - Rear - LH (Remove and Replace)
        • Truck Bed Exterior Trim - Sail Applique Set (Retrofit)
        • Truck Bed Exterior Trim - Rear Lamp Closeout Applique - LH (Remove and Install)
        • Truck Bed Exterior Trim - Sail Applique Assembly - LH (Remove and Install) (Post 11/4/2024)
        • Truck Bed Exterior Trim - Sail Applique Assembly - LH (Remove and Replace)
        • Truck Bed Exterior Trim - Sail Applique Assembly - RH (Remove and Install) (Post 11/4/2024)
        • Truck Bed Exterior Trim - Sail Applique Assembly - RH (Remove and Replace)
        • Truck Bed Exterior Trim - Tailgate Top Applique (Remove and Replace)
        • Truck Bed Exterior Trim - Upper Bed Side Wall Assembly - LH (Remove and Install)
      • 1224 - Luggage Compartment Trim
        • Front Luggage Storage Compartment - Frunk Access Panel (Remove and Install)
        • Frunk Assembly (Remove and Install)
        • Front Luggage Storage Compartment - Frunk Lamp (Remove and Install)
        • Front Luggage Storage Compartment - Frunk Seal (Remove and Install)
        • Front Luggage Storage Compartment - Safety Lock Switch (Remove and Install)
      • 1225 - Underhood Trim
        • Underhood Trim - Rear Apron Assembly (Remove and Install)
        • Underhood Trim - Side Apron Assembly - LH (Remove and Install)
      • 1230 - Trailer Hitch
        • Trailer Hitch - Tow Hitch (Remove and Install)
      • 1245 - Door Triggers
        • Door Trigger - Front Door - LH (Remove and Install)
        • Door Trigger - Rear Door - LH (Remove and Install)
    • 13 - SEATS
      • 1301 - Front Seat Tracks
        • Front Seat Control Switches - 1R Seat SW Button Cushion Grey LH (Remove and Install)
        • Front Seat Control Switches - 1R Seat SW Button Cushion Grey RH (Remove and Install)
        • Front Seat Control Switches - 1R Seat SW Button Recl Grey LH (Remove and Install)
        • Front Seat Control Switches - 1R Seat SW Grey LH 8WY+LBR (Remove and Install)
        • Front Seat Sliders and Controllers - 1R Height Motor [Keiper] (Remove and Install)
        • Front Seat Sliders and Controllers - 1R Keiper Recline Motor (Remove and Install)
        • Front Seat Sliders and Controllers - 1R Mini - Tilt Motor (Remove and Install)
        • Front Seat Sliders and Controllers - 1R Nyc Track Cover (Remove and Install)
        • Front Seat Sliders and Controllers - 1R SC Frame Power (Remove and Install)
        • Front Seat Sliders and Controllers - 1R Seat Inboard Riser LH (Remove and Replace)
        • Front Seat Sliders and Controllers - 1R Seat Outboard Riser Cast LH (Remove and Install)
        • Front Seat Sliders and Controllers - 1R Seat Outboard Riser Cast RH (Remove and Install)
        • Front Seat Sliders and Controllers - 1R Seat Riser Crossmember Cover (Remove and Install)
        • Front Seat Sliders and Controllers - 1R Power Lumbar Seatback Assembly (Remove and Install)
        • Front Seat Tracks and Motors - Front Seat Control Switches - 1st Row Seat Switch Assembly RH No Lumbar (Remove and Install)
        • Front Seat Tracks and Motors - Front Seat Sliders and Controllers - Seatback Assembly with Lumbar - LH (Remove and Install)
      • 1302 - 2nd Row Seat Tracks and Motors
      • 1304 - Front Seat Assemblies and Hardware
        • Front Seat Assemblies - 1st Row Seat Assembly - LH Drive - LH - Black (Remove and Install)
        • Front Seat Assemblies - 1st Row Seat Assembly - LH Drive - RH - Black (Remove and Install)
      • 1305 - 2nd Row Seat Assemblies and Hardware
        • 2nd Row Seat Back Hardware - 2nd Row Seat Shoulder Cover - LH (Remove and Install)
        • 2nd Row Seat Back Hardware - 2R Seat Underbelly LH (Remove and Install)
        • 2nd Row Seat Assemblies - 2nd Row Cushion Assembly - RH (Remove and Replace)
        • 2nd Row Seat Assemblies - 2R Seat Center Headrest (Remove and Install)
        • 2nd Row Seat Assemblies - 2nd Row Cushion Assembly - LH (Remove and Install)
        • 2nd Row Seat Assemblies - 2nd Row Seat Back Assembly - LH (Remove and Install)
        • 2nd Row Seat Assemblies - 2R Seat Back Inboard Bolster LH (Remove and Install)
        • 2nd Row Seat Assemblies - 2R Seat Integrate Armrest (Remove and Install)
        • 2nd Row Seat Assemblies - 2R Seat Side Bolster LH (Remove and Install)
        • 2nd Row Seat Back Hardware - 2R Seat A - Rest Cupholder Bezel (Remove and Install)
        • 2nd Row Seat Back Hardware - 2R Seat Armrest Closeout (Remove and Install)
        • 2nd Row Seat Back Hardware - 2R Seat Armrest Mounting Bracket (Remove and Install)
        • 2nd Row Seat Back Hardware - 2R Seat Back Lumbar (Remove and Install)
        • 2nd Row Seat Back Hardware - 2R Seat Center Top Tether Cap (Remove and Install)
        • 2nd Row Seat Back Hardware - 2R Seat Cushion Release Buckle Strap (Remove and Install)
        • 2nd Row Seat Back Hardware - 2R Seat Shoulder Cover Cap (Remove and Install)
        • 2nd Row Seat Back Hardware - 2R Seat Underbelly RH (Remove and Install)
        • 2nd Row Seat Assemblies and Hardware - 2nd Row Seat Assemblies - 2nd Row Cushion Assembly - LH (Remove and Install)
        • 2nd Row Seat Assemblies and Hardware - 2nd Row Seat Assemblies - 2nd Row Seatback Assembly - RH (Remove and Install)
        • 2nd Row Seat Assemblies and Hardware - 2nd Row Seat Back Hardware - 2nd Row Seat Armrest (Remove and Install)
        • 2nd Row Seat Assemblies and Hardware - 2nd Row Seat Back Hardware - 2nd Row Seat Underbelly - LH (Remove and Install)
      • 1307 - Front Seat Covers, Pads, and Trims
        • Front Seat Covers and Pads - 1R FSC Trim 1R LH/RH (Remove and Install)
        • Front Seat Covers and Pads - 1R Front Seat Back Foam LH With Ventilation (Remove and Install)
        • Front Seat Covers and Pads - 1R Front Seat Back Foam RH With Ventilation (Remove and Install)
        • Front Seat Covers and Pads - 1R LH Inboard Cybershield Paint (Remove and Install)
        • Front Seat Covers and Pads - 1R LH Outboard Cybershield Fab (Remove and Install)
        • Front Seat Covers and Pads - 1R Seat Screw Cover LH (Remove and Install)
        • Front Seat Covers and Pads - Trim TRK 1R LH Front Seat Back Premium D4 (Remove and Install)
        • Front Seat Covers, Pads and Trims - Front Seat Covers and Pads - 1st Row Outboard Side Shield - RH (Remove and Install)
        • Front Seat Covers, Pads and Trims - Front Seat Covers and Pads - 1st Row Seat Cushion Trim with Ventilation - LH (Remove and Install)
        • Front Seat Covers, Pads and Trims - Front Seat Covers and Pads - Seat Trim - RH (Remove and Install)
        • Front Seat Covers, Pads and Trims - Front Seat Covers and Pads- 1st Row Inboard Side Shield - RH (Remove and Install)
      • 1308 - 2nd Row Seat Covers Pads and Trims
        • 2nd Row Seat Covers and Pads - 2nd Row Seat Backrest Substrate LH (Remove and Install)
        • 2nd Row Seat Covers and Pads - 2nd Row Seat Backrest Substrate RH (Remove and Install)
        • 2nd Row Seat Covers and Pads - 2R Backrest Insert Trim (Remove and Install)
        • 2nd Row Seat Covers and Pads - 2R Seat Backrest Insert Foam (Remove and Install)
        • 2nd Row Seat Covers, Pads and Trims - 2nd Row Seat Covers and Pads - 2nd Row Seatback Bolster Foam - Inboard - LH (Remove and Install)
        • 2nd Row Seat Covers, Pads and Trims - 2nd Row Seat Covers and Pads - 2nd Row Seatback Inboard Bolster Trim - LH (Remove and Install)
    • 14 - INSTRUMENT PANELS AND PEDALS
      • 1405 - Instrument Panel
        • Dash Panel - Defrost Panel (Remove and Install)
        • Dash Panel - Instrument Panel Lower Assembly (Remove and Install)
        • Dash Panel - Instrument Panel Top Pad Assembly (Remove and Install)
        • Dash Panel - IP Glovebox Assembly (Remove and Install)
        • Dash Panel - IP Mid Panel Assembly (Remove and Install)
        • Dash Panel - Puddle Lamp V2.0 (Remove and Install)
        • Dash Panel - Quarter Panel Assembly - LH (Remove and Install)
        • Dash Support Frame - Ethernet Diagnostic - RJ45 Module (Remove and Install)
        • Dash Support Frame - Footwell Cover (Remove and Install)
        • Dash Support Frame - IP Center Shroud Service Panel (Remove and Install)
        • Dash Support Frame - IP Downleg Bracket LH (Remove and Install)
        • Dash Support Frame - IP Display Shroud (Remove and Install)
        • Dash Support Frame - IP Downleg Bracket LH (Remove and Install)
        • Dash Support Frame - IP Steering Column Bracket (Remove and Install)
        • Dash Support Frame - Puddle Lamp V2.0 (Remove and Install)
        • Dash Support Frame - Supercarrier Assembly (Remove and Install)
        • Dash Support Frame - Super Cowl Assembly (Remove and Replace)
        • Interior Ducting and Vents - Demist Duct Asssembly - Driver (Remove and Install)
        • Interior Ducting and Vents - Demist Duct Asssembly - Passenger (Remove and Install)
        • Interior Ducting and Vents - Instrument Panel Floor Duct Outboard - LH (Remove and Install)
        • Interior Ducting and Vents - IP Aerobracket Assembly (Remove and Install)
        • Interior Ducting and Vents - IP Aerobracket Assembly (Remove and Replace)
        • Interior Ducting and Vents - IP Airwave Module (Remove and Install)
        • Interior Ducting and Vents - Panel Duct - LH (Remove and Install)
        • Interior Ducting and Vents - Side Window Demist Duct - LH (Remove and Install)
        • Upper Column and Steering Wheel - Steering Column and Wheel - Instrument Panel Gap Hider - Lower (Remove and Install)
    • 15 - INTERIOR TRIM
      • 1505 - Interior Mirror and Sun Visors
        • Rearview Mirror - Beauty Cover (Remove and Install)
        • Rearview Mirror - Glare Shield (Remove and Install)
        • Front Overhead Console Assembly (Remove and Install)
        • Front Overhead Console Assembly (Remove and Replace)
        • Rearview Mirror - Rear View Miror (Remove and Install)
        • Sun Visors - Sunvisor Assembly - LH (Remove and Install)
        • Interior Mirror and Sun Visors - Sun Visors - Sunvisor and Curtain Assembly - LH (Remove and Install)
      • 1511 - Liftgate Trim
      • 1513 - Door Trim
        • Front Door Trim Pad - Ambient Module, Door Map Pocket (Remove and Install)
        • Front Door Trim Pad - Beltline Assembly - LH (Remove and Install)
        • Front Door Trim Pad - Beltline Assembly - LH (Remove and Replace)
        • Front Door Trim Pad - Door Trim Front - LH (Remove and Install)
        • Front Door Trim Pad - Door Reflector (Remove and Install)
        • Front Door Trim Pad - Electric Door Release Switch - LH (Remove and Install)
        • Front Door Trim Pad - Front NVH Foam - LH (Remove and Install)
        • Front Door Trim Pad - Puddle Lamp V2.0 (Remove and Install)
        • Front Door Trim Pad - Window Switch - LH (Remove and Install)
        • Front Door Trim Pad - Window Switch - RH (Remove and Install)
        • Rear Door Trim Pad - Ambient Module, Door Map Pocket (Remove and Install)
        • Rear Door Trim Pad - Beltline Assembly - LH (Remove and Install)
        • Rear Door Trim Pad - Beltline Assembly - LH (Remove and Replace)
        • Rear Door Trim Pad - Door Trim Rear - LH (Remove and Install)
        • Rear Door Trim Pad - Puddle Lamp V2.0 (Remove and Install)
        • Rear Door Trim Pad - Rear NVH Foam - LH (Remove and Install)
        • Rear Door Trim Pad - Window Switch (Remove and Install)
        • Door Trim - Front Door Trim Pad - Electric Door Release Switch - RH (Remove and Install)
        • Door Trim - Front Door Trim Pad - Map Pocket Lamp (Remove and Install)
      • 1518 - Pillar and Sill Trim
        • A-B-C Post Interior Trim - A-Pillar Forward Trim - LH (Remove and Install)
        • A-B-C Post Interior Trim - A-Pillar Lower Trim - LH (Remove and Install)
        • A-B-C Post Interior Trim - A-Pillar Mid Trim - LH (Remove and Install)
        • A-B-C Post Interior Trim - A-Pillar Upper Trim - LH (Remove and Install)
        • A-B-C Post Interior Trim - B-Pillar Lower Trim - LH (Remove and Install)
        • A-B-C Post Interior Trim - B-Pillar Upper Trim Bezel - LH (Remove and Install)
        • A-B-C Post Interior Trim - B-Pillar Upper Trim - LH (Remove and Install)
        • A-B-C Post Interior Trim - C-Pillar Ramp Bracket - LH (Remove and Install)
        • A-B-C Post Interior Trim - C-Pillar Lower Trim - LH (Remove and Install)
        • A-B-C Post Interior Trim - C-Pillar Upper Trim - LH (Remove and Install)
        • Pillar and Sill Trim - A-B-C Post Interior Trim - Illuminated A-Pillar Lower Trim - LH (Remove and Replace)
        • Pillar and Sill Trim - A-B-C Post Interior Trim - Illuminated A-Pillar Lower Trim - Pair (Install)
      • 1519 - Center Console
        • Center Console - Armrest Assembly (Remove and Install)
        • Center Console - Armrest Cap Assembly (Remove and Install)
        • Center Console - Airwave Assembly (Remove and Install)
        • Center Console - Back Panel Assembly (Remove and Install)
        • Center Console - Center Console Assembly (Remove and Install)
        • Center Console - Center Console Cupholder (Remove and Install)
        • Center Console - Console, Airwave, Airwave Cap (Remove and Install)
        • Center Console - External Panel Assembly - LH (Remove and Install)
        • Center Console - Front Panel Assembly (Remove and Install)
        • Center Console - Puddle Lamp V2.0 (Remove and Install)
        • Center Console - Top Decor Assembly (Remove and Install)
        • Center Console - Wireless Charger Gen 5.0 (Remove and Install)
        • Center Console - Wireless Charger Gen 5.0 (Remove and Replace)
        • USB Hub - Back Panel Solo USB Hub (Remove and Install)
        • USB Hub - VCUSB (Remove and Install)
        • USB Hub - VCUSB (Remove and Replace)
        • Center Console - USB Hub - 2nd Row USB Hub (Remove and Install)
      • 1520 - Headliner
        • Headliner Trim - Cantrail Trim - LH (Remove and Install)
        • Headliner Trim - Coathook and Maplight - LH (Remove and Install)
        • Headliner Trim - Front Header Trim (Remove and Install)
        • Headliner Trim - Front Maplight (Remove and Install)
        • Headliner Trim - Rear Header Trim (Remove and Install)
        • Headliner Trim - TCU Bracket (Remove and Install)
      • 1524 - Luggage Compartment Trim
      • 1530 - Carpeting and Mats
        • Interior Sound Insulation - NVH Pad - Cowl (Remove and Install)
        • Interior Sound Insulation - NVH Pad - Dash (Remove and Install)
        • Interior Sound Insulation - NVH Pad - Rear Wall (Remove and Install)
        • Passenger Compartment Carpet - Center Floor Rail - LH (Remove and Install)
        • Passenger Compartment Carpet - Center Floor Trim (Remove and Install)
        • Passenger Compartment Carpet - Center Floor Upper Bracket (Remove and Install)
        • Passenger Compartment Carpet - End Item, Driver Carpet Assembly, Soft Trim (Remove and Install)
        • Passenger Compartment Carpet - End Item, Duct Bezel, Soft Trim (Remove and Install)
        • Passenger Compartment Carpet - End Item, Passenger Carpet Assembly, Soft Trim (Remove and Install)
        • Passenger Compartment Carpet - End Item, Rear Carpet Assembly, Soft Trim (Remove and Install)
        • Passenger Compartment Carpet - End Item, Rear Wall Lower Trim, Soft Trim (Remove and Install)
        • Passenger Compartment Carpet - Floor Mat Kit (Remove and Install)
        • Passenger Compartment Carpet - Pedal - Side Trim (Remove and Install)
    • 16 - BATTERY SYSTEM
      • 1601 - HV Battery Assembly
        • Thermal Vent - HV Battery (Remove and Replace)
        • HV Battery (AWD) \(Remove and Install\)
        • HV Battery (AWD) \(Remove and Replace\)
        • High Voltage Battery Assembly - HV Connector Header, DC FC, Doubler (Remove and Install)
        • High Voltage Battery Assembly - HV Connector Header, DC FC (Remove and Replace)
        • High Voltage Battery Assembly - HV Battery Discharge - At Contactors (Discharge)
        • High Voltage Battery Assembly - Littelfuse 828 - 30 (Remove and Install)
        • High Voltage Battery Assembly - Pyro Access Cover, HVB (Remove and Install)
        • High Voltage Battery Assembly - Rear Skid Plate Assembly (Remove and Install)
        • HV Battery Assembly - High Voltage Battery Assembly - Flood Port 3.1 (Remove and Install)
        • HV Battery Assembly - High Voltage Battery Assembly - Front Chinstrap (Remove and Install)
        • HV Battery Assembly - High Voltage Battery Assembly - HV Connector Header 2-Pole (Remove and Install)
        • HV Battery Assembly - High Voltage Battery Assembly - Littelfuse 828 30A (Remove and Install)
        • HV Battery Assembly - High Voltage Battery Assembly - Rear Venting Bracket (Remove and Install)
        • Undertray and Diffuser - Undertray - Battery Armor (Remove and Install)
      • 1610 - HV Battery Enclosure
      • 1620 - HV Battery Cooling System
      • 1630 - HV Battery Electrical Components
        • AC Junction Box (Remove and Install)
        • Ancillary Components - Fuse, 60A, 1000VDC, Eaton EVK22-60-T (Remove and Replace)
        • Ancillary Components - HV Harness - HVDC, HVB (Remove and Install)
        • Ancillary Components - HV Connector Header, FD (Remove and Install)
        • Ancillary Components - High Voltage Harness - AC Junction Box To FC (Remove and Install)
        • Ancillary Components - Harness - Shunt Jumper (Remove and Install)
        • Ancillary Components - Flood Port (Remove and Install)
        • Ancillary Components - Last Mile Busbar Assembly (Remove and Install)
        • Ancillary Components - PCB, AC Junction Box, B2 (Remove and Install)
        • Ancillary Cover (Remove and Install)
        • Disconnect, Pyro (Remove and Install)
        • Device Cluster Assembly (Backup and Restore)
        • Device Cluster Assembly (Remove and Install)
        • Device Cluster Assembly (Remove and Replace)
        • HV Battery Contactor Seize Check
        • HV Harness - AC Junction Box To PCS (Remove and Replace)
        • Power Conversion System (Remove and Replace)
        • 30A Sand Fuse - Ancillary Bay (Remove and Install)
        • DC Inlet - Negative - Ancillary Bay (Remove and Install)
        • HV Battery Electrical Components - Ancillary Components - DC Inlet - Positive (Remove and Install)
        • HV Battery Electrical Components - Ancillary Components - HV Harness - Ancillary HV Harness (Remove and Install)
        • HV Battery Electrical Components - Ancillary Components - Positive DC Busbar Link (Remove and Install)
    • 17 - ELECTRICAL
      • 1702 - MV Battery
        • Disconnect MV Power
        • MV Battery - Recover
        • Vehicle HV Disablement Procedure
        • MV BATTERY-LITHUM ION-48V (Remove and Install)
        • MV BATTERY-LITHUM ION-48V (Remove and Replace)
      • 1710 - Harnesses
        • Bed and Backbone Harnesses - Bed Left (Remove and Install)
        • Bed and Backbone Harnesses - Bed Right (Remove and Install)
        • Bed and Backbone Harnesses - Harness - MV Backbone (Remove and Install)
        • Dash, IP and Console Harnesses - Harness - Console (Remove and Install)
        • Dash, IP and Console Harnesses - Harness - Cowl (Remove and Install)
        • Dash, IP and Console Harnesses - Harness - Cowl Speaker (Remove and Install)
        • Dash, IP and Console Harnesses - IP (Remove and Install)
        • Door Harnesses - Harness - Door, Closures Devices (Remove and Install)
        • Door Harnesses - Harness - Front LH Door (Remove and Install)
        • Door Harnesses - Harness - Trim, Front LH Door (Remove and Install)
        • Door Harnesses - Harness - Trim, Round Wire, Rear LH Door (Remove and Install)
        • Door Harnesses - Rear LH Door (Remove and Install)
        • Drive Unit and Rear Subframe Harnesses - Rear Subframe - Dual Motor (Remove and Install)
        • Drive Unit and Rear Subframe Harnesses - Rear Subframe - Tri Motor (Remove and Replace)
        • Front Drive Unit Harness (Remove and Install)
        • Front Fascia, Front Gate and Fem Harnesses - Harness - Fem (Remove and Install)
        • Front Fascia, Front Gate and Fem Harnesses - Harness - Front Fascia (Remove and Install)
        • Front Fascia, Front Gate and Fem Harnesses - Harness, Front Gate (Remove and Install)
        • Frunk and Cabin Harnesses - Harness - Cabin Floor (Remove and Install)
        • Frunk and Cabin Harnesses - Harness - Left Frunk (Remove and Install)
        • Frunk and Cabin Harnesses - Harness - Right Frunk (Remove and Install)
        • Harness - Ancillary Bay (Remove and Replace)
        • Rear Fascia and Tail Gate Harnesses - Harness - Rear Fascia (Remove and Replace)
        • Rear Fascia and Tail Gate Harnesses - Tailgate (Remove and Install)
        • Side and A-Pillar Harnesses - Harness - Left A - Trim (Remove and Install)
        • Side and A-Pillar Harnesses - Harness - Roof Accessory Jumper (Remove and Install)
        • Side and A-Pillar Harnesses - RH Side Assembly (Remove and Install)
        • Side and A-Pillar Harnesses - LH Side Assembly (Remove and Install)
        • Steering Harnesses - Harness - Rear Steer Jumper (Remove and Install)
        • Harness - Steering Jumper (Remove and Install)
        • Thermal and HVAC Harnesses - HVAC Dry Side (Remove and Install)
        • Windshield Harness - Harness - Glass Assembly (Remove and Install)
        • Harnesses - Side and A-Pillar Harnesses - Harness - A-Pillar Trim - RH (Remove and Install)
      • 1715 - Electronic Control Modules
        • Door Controller - Front - LH (Remove and Replace)
        • Door Controller - Rear - LH (Remove and Replace)
        • Body Controllers - Left Controller (Remove and Install)
        • Body Controllers - Left Controller (Remove and Replace)
        • Body Controllers - MV Locking Cover Circlip (Remove and Replace)
        • Body Controllers - Rear Controller (Remove and Install)
        • Body Controllers - Rear Controller (Remove and Replace)
        • Body Controllers - Right Controller (Remove and Install)
        • Body Controllers - Right Controller (Remove and Replace)
        • Body Controllers - Trailer ECU (Remove and Install)
        • Body Controllers - Trailer ECU (Remove and Replace)
      • 1720 - Radar Sensor
        • Radar - Cabin (Remove and Install)
        • Radar - Cabin (Remove and Replace)
      • 1722 - Cameras
        • Forward Facing - Forward Bi - Cam (Remove and Install)
        • Forward Facing - Forward Bi - Cam (Remove and Replace)
        • Forward Facing - Heated Fascia Camera Trinity (Remove and Install)
        • Forward Facing - Heated Fascia Camera Trinity (Remove and Replace)
        • Rear Camera - Trinity Cam, HFOV180, Rotate, Dkey, Back (Remove and Install)
        • Side and Fender Flare Cameras - B-Pillar Camera - LH (Remove and Install)
        • Side and Fender Flare Cameras - Fender Flare Camera - LH (Remove and Install)
        • Side and Fender Flare Cameras - Fender Flare Camera - LH (Remove and Replace)
        • Side and Fender Flare Cameras - B-Pillar Camera - LH (Remove and Replace)
        • Fan - Camera - Windshield (Remove and Replace)
      • 1724 - Interior Camera
        • Interior Camera - Interior Camera (Remove and Install)
        • Interior Camera - Interior Camera (Remove and Replace)
      • 1735 - Interior Lighting
      • 1740 - Exterior Lights
        • Bed Lights - Bed Light - LH (Remove and Install)
        • Front Lights (Excluding Headlamps) - Front Lightbar (Remove and Install)
        • Headlamps - Headlamp Assembly - LH (Remove and Install)
        • Headlight - Adjust (Wall Method)
        • Tail Lights - Body Side Tail Lamp - LH (Remove and Install)
        • Tail Lights - License Plate Lamp (Remove and Install)
        • Tail Lights - Rear Marker Lamp - LH (Remove and Install)
        • Tail Lights - Reverse Lamp - LH (Remove and Install)
        • Tail Lights - Tailgate Lamp (Remove and Install)
      • 1745 - Keyless Entry and Security
        • Remote and Passive Entry - Front Rear BLE Gen 3 (Remove and Install)
        • Remote and Passive Entry - Interior End Point (Remove and Install)
        • Remote and Passive Entry - Rear BLE (Remove and Install)
        • Remote and Passive Entry - Rear BLE (Remove and Replace)
        • Remote and Passive Entry - Wheel Well Endpoint, BLE (Remove and Install)
      • 1750 - Wipers and Washers
        • Windshield Washer Bottle and Pump - Windshield Wiper Washer Hose (Remove and Install)
        • Windshield Washer Bottle and Pump - Mega Beam - Washer Hose Assembly (Remove and Install)
        • Windshield Washer Bottle and Pump - Washer Level Sensor (Remove and Install)
        • Windshield Washer Bottle and Pump - Washer Pump (Remove and Install)
        • Windshield Washer Bottle and Pump - Washer Tank Assembly (Remove and Install)
        • Windshield Washer Bottle and Pump - Washer Tank Cap (Remove and Install)
        • Windshield Washer Bottle and Pump - Washer Tank Neck (Remove and Replace)
        • Windshield Wipers and Motor - Assembly, Wiper Motor (Remove and Install)
        • Windshield Wipers and Motor - Hose Washer Wiper Windshield (Remove and Install)
        • Windshield Wipers and Motor - Wiper Arm and Blade Assembly (Remove and Install)
        • Windshield Wipers and Motor - Wiper Arm (Remove and Install)
        • Windshield Wipers and Motor - Wiper Blade (Remove and Install)
      • 1753 - Horn
      • 1754 - Pedestrian Warning Speaker
      • 1755 - Accelerator Pedal
        • Accelerator Pedal (Remove and Install)
        • Brake Pedal - Accelerator Pedal Support Bracket (Remove and Install)
    • 18 - THERMAL MANAGEMENT
      • 1810 - Cabin HVAC
        • Passenger Ducting and Vents - 2nd Row Floor Y Duct (Remove and Install)
        • Blend Door Actuator - HVAC (Remove and Replace)
        • Cabin HVAC - Cabin Temperature Sensor, Fan Driven (Remove and Install)
        • Cabin HVAC - Harness - Megavac, Center (Remove and Install)
        • Cabin HVAC - HEPA Filter Cover (Remove and Install)
        • Cabin HVAC - Hepa Filter (Remove and Install)
        • Cabin HVAC - HVAC, Blower (Remove and Install)
        • Cabin HVAC - HVAC Distribution (Remove and Install)
        • Cabin HVAC - Sensor - Relative Humidity and Temp (Remove and Install)
        • Cabin HVAC - Wet Side HVAC (Remove and Install)
        • Passenger Ducting and Vents - 2nd Row Duct On Rails (Remove and Install)
        • Passenger Ducting and Vents - Air Extractor (Remove and Install)
        • Passenger Ducting and Vents - Center Console Jumper Duct (Remove and Install)
        • Passenger Ducting and Vents - Center Console Riser Duct (Remove and Install)
        • Passenger Ducting and Vents - IP Floor Duct LH Inboard (Remove and Install)
        • Passenger Ducting and Vents - IP Floor Duct RH (Remove and Install)
        • Passenger Ducting and Vents - Panel Duct, RH (Remove and Install)
        • Passenger Ducting and Vents - Jumper Floor Duct (Remove and Install)
        • Passenger Ducting and Vents - Quarter Glass Demist Duct, LH (Remove and Install)
        • Passenger Ducting and Vents - Suction Discharge Lines (Remove and Install)
        • Windshield - Temperature and Relative Humidity Sensor (Remove and Install)
      • 1820 - Refrigerant System
        • A/C Refrigerant (Recovery and Recharge)
        • Compressor - Acoustic Cover, 1KV AC Compressor, Sanden (Remove and Install)
        • Compressor - 1KV AC Compressor, 45cc, Sanden (Remove and Replace)
      • 1830 - Cooling System
        • Cooling System (Vacuum Refill)
        • Fan and Radiator - Cooling Fan Module (Remove and Install)
        • Hoses - Hose, Battery Supply (Remove and Install)
        • Hose, Front Drive Unit Supply Inline (Remove and Install)
        • Hose - Inverter to Heat Exchanger - Front Drive Unit (Remove and Install)
        • Hoses - Hose, Manifold To Radiator (Remove and Install)
        • Hoses - Powertrain Hose Bundle (Remove and Install)
        • Hoses - Hose, Powertrain Return (Remove and Install)
        • Hoses - Hose, Powertrain Supply (Remove and Install)
        • Hoses - Hose, Radiator To Manifold (Remove and Install)
        • Hose, Rdu Return (Dual Motor) (Remove and Install)
        • Hose, Rdu Supply (Dual Motor) (Remove and Install)
        • Hose - Inverter to Heat Exchanger - Rear Drive Unit - LH (Tri Motor) (Remove and Install)
        • Hose - Return - Rear Drive Unit (Tri Motor) (Remove and Install)
        • Hose - Supply - Rear Drive Unit (Tri Motor) (Remove and Install)
      • 1840 - Supermanifold
        • SuperManifold - ACC Filter (Remove and Replace)
        • SuperManifold - Chiller Filter (Remove and Replace)
        • SuperManifold - EXV4.5/VCV Coil (Remove and Replace)
        • Supermanifold - Harness - Supermanifold W/ Standalone Controller, Center (Remove and Install)
        • SuperManifold - LCCR Filter (Remove and Replace)
        • Supermanifold - Octovalve (Remove and Install)
        • Supermanifold - Service Kit, 16MM Check Valve (Remove and Install)
        • Supermanifold - Service Kit, Check Valve (Remove and Install)
        • Supermanifold - Service Kit, Chiller (Remove and Install)
        • Supermanifold - Service Kit, Desiccant (Remove and Install)
        • Supermanifold - Service Kit, Expansion Valve Coil (Remove and Install)
        • Supermanifold - Service Kit, Expansion Valve Core (Remove and Install)
        • Supermanifold - PT Sensor, High Pressure (Remove and Install)
        • Supermanifold - PT Sensor, Low Pressure (Remove and Install)
        • Supermanifold - Service Kit, Coolant Bottle (Remove and Install)
        • Supermanifold - Service - Kit, Coolant Pump (Remove and Install)
        • Supermanifold - Supermanifold (Remove and Replace)
        • SuperManifold - VCV Core (Remove and Replace)
    • 20 - SAFETY AND RESTRAINT
      • 2001 - Air Bags
        • Front Air Bags - Driver Airbag Assembly (Remove and Install)
        • Front Air Bags - Knee Airbag, LH (Remove and Install)
        • Front Air Bags - Knee Airbag, RH (Remove and Install)
        • Front Air Bags - MX - Passenger Airbag, NAR (Remove and Install)
        • Side Air Bags - Curtain Airbag, LH (Remove and Install)
        • Side Air Bags - Curtain Airbag - RH (Remove and Install)
      • 2005 - Seat Belts
        • 1st Row Seat Belts - 1R LH Retractor, Black (Remove and Install)
        • 1st Row Seat Belts - Single Fastener Seatbelt Webguide (Remove and Install)
        • 1st Row Seat Belts - ZF First Row Buckle - Sumitomo (Remove and Install)
        • 2nd Row Seat Belts - 2R Center Retractor, Black (Remove and Install)
        • 2nd Row Seat Belts - 2R Center/RH Buckle (Remove and Install)
        • 2nd Row Seat Belts - 2R Outboard Retractor, Black (Remove and Install)
        • 2nd Row Seat Belts - LH 2nd Row Buckle Mini Anchor (Remove and Install)
      • 2010 - Pre-Tensioners
        • Pre - Tensioners - ZF Lap Pretensioner - LH (Remove and Install)
      • 2020 - Sensors
        • Impact and Acceleration Sensors - 480G Impact Sensor, Dual Axis, Through Bolt (Remove and Install)
        • Impact and Acceleration Sensors - Door Pressure Sensor, PPS3E, A Key (Remove and Install)
        • Impact and Acceleration Sensors - Door Pressure Sensor, PPS3E, A Key (Remove and Replace)
        • Impact and Acceleration Sensors - Restraint Control Module (Remove and Install)
        • Impact and Acceleration Sensors - Restraint Control Module (Remove and Replace)
        • Impact and Acceleration Sensors - Single Axis, 480G, Crash Accel, Bolt (Remove and Install)
        • Impact and Acceleration Sensors - Single Axis, 480G, Crash Accel, Connector (Remove and Install)
        • Impact and Acceleration Sensors - Single Axis, 480G, Crash Accel, Perpendicular (Remove and Install)
        • Seat Track Position Sensor - 1R Seat Track Position Sensor (Remove and Install)
      • 2030 - Pedestrian Protection System
    • 21 - INFOTAINMENT
      • 2107 - Touchscreen
        • Touchscreen - Center Display Assembly (Remove and Install)
        • Touchscreen - Rear Display (Remove and Install)
      • 2110 - Car Computer
        • Car Computer - Drip Guard (Remove and Install)
        • Car Computer (Remove and Install)
        • Car Computer (Remove and Replace)
      • 2121 - Audio System - Speakers, Subwoofer, Amplifier
        • Audio Speakers - 200mm, Woofer, LH, C-Pillar, Audio (Remove and Install)
        • Audio Speakers - Assembly Microphone Telephony (Remove and Install)
        • Audio Speakers - Audio Speaker Full Range - 60mm (Remove and Install)
        • Audio Speakers - Audio, Speaker, Full Range, 100mm, Overhead (Remove and Install)
        • Audio Speakers - Audio Speaker Super Horn (Remove and Install)
        • Audio Speakers - Audio Speaker Tweeter Active 25mm (Remove and Install)
        • Audio Speakers - Audio Speaker Woofer Premium 200mm (Remove and Install)
        • Audio Speakers - Horn Assembly, Low Tone, LH (Remove and Install)
        • Audio System - Speakers, Subwoofer and Amplifier - Audio Speakers - Full Range Speaker 100mm (Remove and Install)
        • Audio System - Speakers, Subwoofer and Amplifier - Audio Speakers - Premium Speaker 200mm Woofer (Remove and Install)
        • Pedestrian Warning Speaker (Remove and Install)
      • 2123 - Audio System - AM, FM and HD Radio
      • 2125 - Audio System - Bluetooth
      • 2126 - Audio System - USB Media Port
      • 2130 - Antenna - AM, FM, and HD Radio
      • 2131 - Antenna - Satellite Radio
      • 2132 - Antenna - GPS
      • 2133 - Antenna - Wi-Fi
      • 2135 - Antennas and Amplifiers
        • Antennas and Amplifiers - Milkweed GNSS Antenna Assembly (Remove and Install)
        • Antennas and Amplifiers - TLA, Telematics Control Unit (TCU) (Remove and Install)
        • Antennas and Amplifiers - TLA, Telematics Control Unit (TCU) (Remove and Replace)
        • Antennas and Amplifiers - Tuner FM/HD (Remove and Install)
        • Antennas and Amplifiers - Antennas and Amplifiers - FM Amplifier Antenna (Remove and Install)
    • 24 - ROOF
      • 2430 - Fixed Glass Roof
    • 30 - CHASSIS
      • 3001 - Chassis and Subframes
        • Chassis and Subframes - Rear Subframe (Dual Motor) (Remove and Replace)
        • Chassis and Subframes - Rear Subframe (Tri Motor) (Remove and Replace)
        • Front Inner Panels - Megabeam (Remove and Install)
        • Front Subframe - Front Chassis Structure Assembly (Remove and Install)
        • Inspect Underbody Fastener Torque
        • Rear Subframe - Dual Rear Chassis Structure (Remove and Install)
    • 31 - SUSPENSION
      • Alignment Requirement - Suspension
      • 3100 - Adjustment
        • Four Wheel Alignment Check and Adjust
        • Four Wheel Alignment Check (No Adjustment Needed)
      • 3101 - Front Suspension (including Hubs)
        • Front Air Spring - Front Air Spring Module - LH (Remove and Install)
        • Front Knuckle - Hub and Bearing - Driven Hub - 6X139.7mm PCD - 180mm Flange (Remove and Install)
        • Front Knuckle - Hub and Bearing - Front Knuckle Assembly - LH (Remove and Install)
        • Front Knuckle - Hub and Bearing - Front Knuckle Assembly - LH (Remove and Replace)
        • Front Stabilizer Bar and Links - Front Bar 130 N/mm (Remove and Install)
        • Front Stabilizer Bar and Links - Front Stabar Link Assembly - LH (Remove and Install)
        • Front Suspension Arms - Front Lower Arm - LH (Remove and Install)
        • Front Suspension Arms - Front Upper Arm Assembly - LH (Remove and Install)
      • 3103 - Rear Suspension (including Hubs)
        • Rear Air Spring - Rear Air Spring Module - LH (Remove and Install)
        • Rear Knuckle - Hub and Bearing - Driven Hub - 6X139.7mm PCD - 180mm Flange (Remove and Install)
        • Rear Knuckle - Hub and Bearing - Rear Knuckle Assembly - LH (Remove and Install)
        • Rear Stabilizer Bar and Links - Rear Stabar Assembly (Remove and Install)
        • Rear Stabilizer Bar and Links - Rear Stabar Link - LH (Remove and Install)
        • Rear Suspension Arms - Rear Lower Arm Aeroshield - LH (Remove and Install)
        • Rear Suspension Arms - Rear Lower Arm Assembly - LH (Remove and Install)
        • Rear Suspension Arms - Rear Upper Arm Assembly - LH (Remove and Install)
        • Rear Suspension (including Hubs) - Rear Knuckle - Hub and Bearing - Lower Balljoint Assembly (Remove and Install)
        • Rear Suspension (including Hubs) - Rear Knuckle - Hub and Bearing - Upper Balljoint Assembly (Remove and Install)
      • 3110 - Air Suspension System
        • Air Suspension - Pressurize / Depressurize - Full System
        • Air Suspension Pressure Lines - Air Lines Leak (Inspection)
        • Air Suspension Pressure Lines - Fill Port (Remove and Install)
        • Air Suspension Pressure Lines - Left Airline Bundle (Remove and Install)
        • Air Suspension Pressure Lines - Rear Airlines (Remove and Install)
        • Air Suspension Pressure Lines - Right Airline Bundle (Remove and Install)
        • Air Suspension Compressor and Reservoir - Air Compressor Exhaust Assembly (Remove and Install)
        • Air Suspension Compressor and Reservoir - Air Reservoir (Remove and Install)
        • Air Suspension Compressor and Reservoir - Air Suspension Compressor (Remove and Install)
        • Air Suspension Compressor and Reservoir - Air Suspension Valve Block (Remove and Replace)
        • Air Suspension Compressor and Reservoir - Carrier Bracket - Air Suspension Compressor (Remove and Install)
        • Air Suspension Compressor and Reservoir - Inlet Airline (Remove and Install)
        • Height Controller and Sensors - Front Air Suspension Height Sensor Assembly - LH (Remove and Install)
        • Height Controller and Sensors - Rear Air Suspension Height Sensor Assembly - LH (Remove and Install)
        • Ride Height Calibration
    • 32 - STEERING
      • 3201 - Steering Rack and Lower Column
        • Front Steering Gear and Lower Column - Front Steering Actuator (Remove and Install)
        • Front Steering Gear and Lower Column - Front Steering Actuator (Remove and Replace)
        • Rear Steering Gear and Lower Column - Rear Steering Actuator (Remove and Install)
        • Rear Steering Gear and Lower Column - Rear Steering Actuator (Remove and Replace)
        • Rear Steering Gear and Lower Column - Rear Toe Link (Remove and Install)
        • Steering Gear and Lower Column - Steering Gear Inner Tie Rod - LH (Remove and Replace)
        • Steering Rack and Lower Column - Rear Steering Gear and Lower Column - Rear Steering Actuator - LPS Harness (Remove and Install)
      • 3205 - Upper Column, Steering Wheel
        • Set Handwheel Zero
        • Steering Column and Steering Feedback Actuator (Remove and Replace)
        • Steering Column and Wheel - Instrument Panel Gap Hider - Lower (Remove and Install)
        • Steering Column and Wheel - Instrument Panel - Gap Hider (Remove and Install)
        • Steering Column and Wheel - Shroud Lower Clip Instrument Panel - Steering Column (Remove and Install)
        • Steering Column and Wheel - Shroud Lower Instrument Panel - Steering Column (Remove and Install)
        • Steering Column and Wheel - Shroud Upper Instrument Panel - Steering Column (Remove and Install)
        • Steering Column and Wheel - Shroud Upper - Steering Wheel
        • Steering Column and Wheel - Steering Column Control Module (Remove and Install)
        • Steering Column and Wheel - Steering Column Control Module (Remove and Replace)
        • Steering Column and Wheel - Steering Wheel (Calibration)
        • Steering Column and Wheel - Steering Wheel Harness (Remove and Install)
        • Steering Column and Wheel - Steering Wheel Pur Heated (Remove and Install)
        • Steering Column and Wheel - Steering Wheel Pur Heated (Remove and Replace)
        • Steering Column and Wheel - Steering Wheel Switch - LH (Remove and Install)
        • Steering Column and Wheel - Steering Wheel Switch - LH (Remove and Replace)
        • Steering Column and Wheel - Steering Wheel Switch - RH (Remove and Install)
        • Steering Column and Wheel - Steering Wheel Switch - RH (Remove and Replace)
        • Upper Column and Steering Wheel - Steering Column and Wheel - Shroud Upper Instrument Panel - Steering Column (Remove and Install)
    • 33 - BRAKES
      • 3301 - Brake Discs and Calipers
        • Calipers and Pads - Rear Brake Caliper - Bleed Screw - LH (Remove and Install)
        • Calipers and Pads - Rear Brake Caliper Springs - LH (Remove and Install)
        • Clean And Lubricate Brake Calipers (Integrated Parking Brake) (Requires Code 34012501) (Maintenance)
        • Front Brake Rotors - Calipers and Pads - Front Brake Caliper - LH (Remove and Install)
        • Front Brake Rotors - Calipers and Pads - Front Brake Rotor (Remove and Install)
        • Front Brake Rotors - Calipers and Pads - Front Brake Shield - LH (Remove and Install)
        • Front Brake Rotors - Calipers and Pads - Service Front Brake Caliper Bleed Screw Kit (Remove and Replace)
        • Front Brake Rotors - Calipers and Pads - Service Front Brake Caliper Boot Kit (Remove and Install)
        • Front Brake Rotors - Calipers and Pads - Service Front Brake Caliper Spring Kit (Remove and Install)
        • Front Brake Rotors - Calipers and Pads - Service Front Brake Pad Kit (Remove and Install)
        • Rear Brake Rotors - Calipers and Pads - Rear Brake Caliper Boot - LH (Remove and Install)
        • Rear Brake Rotors - Calipers and Pads - Rear Brake Caliper - LH (Remove and Install)
        • Rear Brake Rotors - Calipers and Pads - Rear Brake Pad Kit (Remove and Install)
        • Rear Brake Rotors - Calipers and Pads - Rear Brake Rotor - Base (Remove and Install)
        • Rear Brake Rotors - Calipers and Pads - Rear Brake Shield - LH (Remove and Install)
        • Rear Brake Rotors - Calipers and Pads - SVC Rear Brake Caliper - LH (Without Pads) (Remove and Install)
        • Brake Discs and Calipers - Front Brake Rotors - Calipers and Pads - Front Brake Caliper - Performance - LH (Remove and Install)
        • Brake Discs and Calipers - Front Brake Rotors - Calipers and Pads - Front Brake Caliper - Performance without Pads - LH (Remove and Install)
        • Brake Discs and Calipers - Front Brake Rotors - Calipers and Pads- Front Brake Caliper without Pads - LH (Remove and Install)
        • Brake Discs and Calipers - Rear Brake Rotors - Calipers and Pads - Rear Brake Caliper - Performance - LH (Remove and Install)
        • Brake Discs and Calipers - Rear Brake Rotors - Calipers and Pads - Rear Brake Caliper - Performance without Pads - LH (Remove and Install)
      • 3303 - Brake Pipes and Hoses
        • Brake Fluid Bleed - One Caliper
        • Brake Fluid Bleed/Flush (Maintenance)
        • Brake Lines - Left Brake Tube Pipe Assembly (Remove and Install)
        • Brake Lines - Master Cylinder - HCU Brake Pipe Assembly (Remove and Install)
      • 3305 - Parking Brake
      • 3310 - ABS, Traction, and Stability Control
        • ABS Module and ESC Sensor - HCU Bracket Assembly (Remove and Install)
        • ABS Module and ESC Sensor - Hydraulic Control Unit (Remove and Install)
        • ABS Module and ESC Sensor - Hydraulic Control Unit (Remove and Replace)
        • ABS Module and ESC Sensor - Wheel Speed Sensor - Front - LH (Remove and Install)
        • ABS Module and ESC Sensor - Wheel Speed Sensor - Rear - LH (Remove and Install)
      • 3320 - Electromechanical Brake Booster
        • Electromechanical Brake Booster - Brake Booster Assembly (Remove and Install)
        • Electromechanical Brake Booster - Brake Remote Reservoir (Remove and Install)
        • Electromechanical Brake Booster - Remote Reservoir Tube (Remove and Install)
      • 3325 - Brake Pedal
        • Accelerator Pedal (Remove and Install)
        • Brake Pedal - Accelerator Pedal Support Bracket (Remove and Install)
        • Brake Pedal - Brake Pedal - Option (Remove and Install)
    • 34 - WHEELS AND TIRES
      • 3401 - Wheels
        • Wheel Cover - Front - LH (Remove and Install)
        • Wheel Cover - Front - LH (Remove and Replace)
        • Wheel Assembly (Remove and Install)
        • Wheels - Wheel (Remove and Install)
      • 3402 - Tires
        • Replacement Tire Information
        • Tire - Front - LH (Repair) (Tire Repair)
        • Tire Rotation (Maintenance)
        • Tires - Tire 285/65R20 Goodyear Wrangler Territory RT (Remove and Install)
      • 3404 - Tire Pressure Monitoring System (TPMS)
        • Tire Pressure Monitoring System (TPMS) - Tire Pressure Monitor Sensor - No Nut (Remove and Install)
        • TIRE PRESSURE MONITOR SENSOR (TPMS) BLUETOOTH - NO NUT - BLACK (Remove and Replace)
    • 39 - FRONT DRIVE UNIT
      • 3901 - Front Drive Unit Assembly
        • Front Drive Unit Assembly - Cable, Ground Strap, 35mm2 (Remove and Install)
        • Front Drive Unit Assembly - Du Breather Housing (Remove and Install)
        • Front Drive Unit Assembly - Electric Oil Pump 2.0 Dg (Remove and Install)
        • Front Drive Unit Assembly - Front Drive Unit (Remove and Install)
        • Front Drive Unit Assembly - Front Drive Unit (Remove and Replace)
        • Front Drive Unit Assembly - Inverter, Mount, C1PM (Remove and Install)
        • Front Drive Unit Assembly - Heat Exchanger, C1 (Remove and Install)
        • Front Drive Unit Assembly - Output Axle Seal, DVI, HNBR 44 X 67 (Remove and Replace)
        • Front Drive Unit Assembly - Front Drive Unit - Inverter NVH Covers Assembly (Remove and Install)
        • Front Drive Unit Assembly - Front Drive Unit Assembly - Bushing - Side - LH (Remove and Install)
        • Front Drive Unit Assembly - Front Drive Unit Assembly - Gearcase Bushing (Remove and Install)
        • Front Drive Unit Assembly - Front Drive Unit Assembly - Motor Side NVH Covers Assembly (Remove and Install)
      • 3920 - Front Inverter
        • Front Drive Inverter - Cover, Phase Out (Remove and Install)
        • Front Drive Inverter - Drive Inverter (Remove and Replace)
      • 3930 - Front Gearbox and Halfshafts
        • Front Drive Unit Assembly - Gearbox Fluid (Drain and Fill) (Remove and Replace)
        • Front Halfshafts - Halfshaft, 30.2mm X 597mm Shaft, Front (Remove and Install)
        • Front Halfshafts - Halfshaft - Pair (Remove and Replace)
    • 40 - REAR DRIVE UNIT
      • 4001 - Rear Drive Unit Assembly
        • Ground Strap Cable - Rear Drive Unit (Tri Motor) (Remove and Replace)
        • Dual Motor Rear Drive Unit - Drive Unit Assembly NVH Cover (Remove)
        • Heat Exchanger - Rear Drive Unit - LH (Tri Motor) (Remove and Replace)
        • Oil Pump - Rear Drive Unit - LH (Tri Motor) (Remove and Install)
        • Oil Pump - Rear Drive Unit - LH (Tri Motor) (Remove and Replace)
        • Rear Drive Unit - Cable, Ground Strap (Dual Motor) (Remove and Install)
        • Rear Drive Unit - Du Breather Housing (Remove and Install)
        • Rear Drive Unit - Electric Oil Pump 2.0 DG (Remove and Install)
        • Rear Drive Unit - Electric Oil Pump 2.0 DG (Remove and Replace)
        • Rear Drive Unit - Heat Exchanger, C1 (Remove and Install)
        • Rear Drive Unit - Inverter, Mount, C1PM (Remove and Install)
        • Rear Drive Unit - Output Axle Seal, DVI, HNBR 44 X 67 (Remove and Install)
        • Rear Drive Unit (Tri Motor) (Remove and Replace)
        • Rear Drive Unit (Dual Motor) (Remove and Install)
        • Rear Drive Unit (Dual Motor) (Remove and Replace)
        • Rear Drive Unit Assembly - Rear Drive Unit - Bushing - Side - LH (Remove and Install)
        • Rear Drive Unit Assembly - Rear Drive Unit - Gearcase Bushing (Remove and Install)
        • Rear Drive Unit Assembly - Rear Drive Unit - Inverter NVH Covers Assembly (Remove and Install)
        • Rear Drive Unit Assembly - Rear Drive Unit - Motor Side NVH Covers Assembly (Remove and Install)
      • 4010 - Rear Motor
      • 4020 - Rear Inverter
        • Front and Rear Drive Inverter - Set (Dual Motor) (Remove and Replace)
        • Front Drive Unit Assembly and LH and RH Rear Drive Inverters (Tri-Motor) (Remove and Replace)
        • Front Drive Unit and Rear Drive Inverter - LH (Tri-Motor) (Remove and Replace)
        • Front Drive Unit and Rear Drive Inverter - RH (Tri-Motor) (Remove and Replace)
        • Rear Drive Inverter - Cover, Phase Out (Remove and Install)
        • Rear Drive Inverter - Drive Inverter (Remove and Replace)
        • Rear Drive Unit Assembly - Tri Motor - Drive Inverter Assembly - LH (Remove and Replace)
        • Rear Drive Unit - Rear Drive Inverter - Set (Tri-Motor) (Remove and Replace)
      • 4030 - Rear Gearbox and Halfshafts
        • Rear Drive Unit - RDU Oil (Tri Motor) (Drain and Fill)
        • Rear Drive Unit - RDU Oil (Tri Motor) (Top Off)
        • Rear Halfshafts - Halfshaft, 33.4mm X 588mm Shaft, Rear (Remove and Install)
        • Rear Halfshafts - Halfshaft - Pair (Remove and Replace)
    • 44 - HIGH VOLTAGE SYSTEM
      • 4400 - High Voltage Testing
        • Isolation/Insulation Test
      • 4401 - Charge System Inlet
        • Charge Port Voltage Check
        • Charge Port - Assembly Charge Port Controller ECU Gen 4 (Remove and Replace)
        • Charge Port - BUSBar Chargeport Assembly (Remove and Install)
        • Charge Port - BUSBar Chargeport Assembly (Remove and Replace)
        • Charge Port - Charge Port Door (Remove and Install)
        • Charge Port - Charge Port Door (Remove and Replace)
      • 4450 - HV Harnesses
        • HV Harness - Rear Drive Unit - LH (Tri Motor) (Remove and Replace)
        • HV Harness - Rear Drive Unit - RH (Tri Motor) (Remove and Replace)
        • HV Harness - AC Compressor \(Remove and Install\)
        • HV Harnesses - Bed Outlet Assembly - Nema 5-20 / 14-50 (Remove and Install)
        • HV Harnesses - Bed Outlet - High Voltage Harness (Remove and Install)
        • HV Harnesses - Cabin Outlets - High Voltage Harness (Remove and Install)
        • HV Harnesses - Front Drive Unit - High Voltage Harness (Remove and Install)
        • HV Harnesses - HV Connector Header, Plug, 300mm2 (Remove and Install)
        • HV Harnesses - Rear Drive Unit - High Voltage Harness - Dual Motor (Remove and Install)
    • 50 - EXTERNAL CHARGING CONNECTORS
      • 5001 - Mobile Connector
        • Firmware Update - Mobile Connector
        • Remove Stuck Deadfront - Charge Handle
    • 90 - ACCESSORIES
      • Bed Floor D-Rings (Install)
      • Off Road Lightbar (Mount on Windshield and Solder Only) (Retrofit)
      • Off Road Lightbar (Remove and Install)
      • Off Road Lightbar (Remove and Replace)
      • Retrofit Cybertruck CyberTent (Retrofit)
      • Spare Tire and Tool Kit (Retrofit)
    • © Tesla 2024
    • Procedure Feedback
    • Site Feedback

    Crowsfoot or Offset Wrench Extension Calculator

    Torque Calculator Values
    Note
    1. If the angle from the extension to the torque wrench is greater than 90° (Figure 2), input E as a positive number.
    2. If the angle from the extension to the torque wrench is less than 90° (Figure 3), input E as a negative number.
    3. If the angle from the extension to the torque wrench is exactly 90°, this calculator is not needed. Torque the fastener to T1.
    Figure 1
    Figure 2
    Figure 3